2019 VOLVO XC90

ELECTRICAL SYSTEM:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.

ELECTRICAL SYSTEM:SOFTWARE

Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improper

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

SEAT BELTS:CRITICAL FASTENERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.

STEERING

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

The contact owned a 2019 Volvo XC90. The contact stated that while driving approximately 50-52 MPH, there smoke coming from the front passenger’s side wheel well of the vehicle. The contact stated that an off-duty Police Officer witnessed the failure and activated the Emergency Lights, allowing the contact to safely pull off the highway The contact immediately pulled over and stopped the vehicle. The grandson seated in the front passenger’s seat immediately exited the vehicle and the contact was able to unbuckle and removed the [XXX] from the second-row middle seat. The contact stated that moments later there were explosions, and there was black smoke and flames engulfing the vehicle. The vehicle was destroyed. There were no injuries sustained; however, all three occupants of the vehicle experienced emotional trauma from the vehicle catching on fire. Medical attention was not needed. A Police Report was filed at the scene and the vehicle was towed away. The contact stated that the

Mileage: 61,511

I am writing to formally a repeated mechanical failure involving the HVAC evaporator systems in two Volvo vehicles that I purchased within a few months of each other. The vehicles involved are: • 2019 Volvo XC90 T6 Momentum VIN: [XXX] Purchased: November 2024 • 2020 Volvo XC60 T5 Momentum Purchased: January 2025 Within a six months apart, both vehicles suffered complete air conditioning system failure due to large evaporator leaks. In total, three evaporators have now been confirmed as leaking across these two vehicles. The 2020 XC60 experienced evaporator failure in May 2025 and required full evaporator replacement under its CPO warranty. The 2019 XC90 subsequently developed the same issue. After multiple independent inspections and a full diagnostic performed by Volvo, they have confirmed that both the front and rear evaporators were leaking. The total repair estimate exceeds seven thousand dollars. Despite the statistical improbability of two vehicles purchased months apa

Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “drive” with my foot on the brake. All of the sudden the car completely turns off. Screens black, engine off. Completely black car no inside lights on. Within a couple of seconds, I hear the engine reengage and the car “starts” as normal like when you turn the switch. All of the lights and screens turn on and apple car play reconnects. The most recent two incidents were the same day and in drive having stopped at stoplights. The car goes “dead” then restarts all in drive with my foot on the brake. No warnings come up after the incident either. This time my husband and children were with me and can confirm it happened. I did not get these incidents checked out since the car was instantly back to normal with no warning messages. Very unnerving

Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “drive” with my foot on the brake. All of the sudden the car completely turns off. Screens black, engine off. Completely black car no inside lights on. Within a couple of seconds, I hear the engine reengage and the car “starts” as normal like when you turn the switch. All of the lights and screens turn on and apple car play reconnects. The most recent two incidents were the same day and in drive having stopped at stoplights. The car goes “dead” then restarts all in drive with my foot on the brake. No warnings come up after the incident either. This time my husband and children were with me and can confirm it happened. I did not get these incidents checked out since the car was instantly back to normal with no warning messages. Very unnerving

Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “drive” with my foot on the brake. All of the sudden the car completely turns off. Screens black, engine off. Completely black car no inside lights on. Within a couple of seconds, I hear the engine reengage and the car “starts” as normal like when you turn the switch. All of the lights and screens turn on and apple car play reconnects. The most recent two incidents were the same day and in drive having stopped at stoplights. The car goes “dead” then restarts all in drive with my foot on the brake. No warnings come up after the incident either. This time my husband and children were with me and can confirm it happened. I did not get these incidents checked out since the car was instantly back to normal with no warning messages. Very unnerving

Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car.

Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car.

Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car.

My engine caught on fire. Unknown cause at this time.

Rear evaporator coil (Failure) The rear evaporator coil failed on my Volvo XC90 purchased new at the dealership in 2019. This car only had 27,000 miles on it when the evaporator coil went bad. Refrigerant smells entered the cabin when AC was on while my 2 year old daughter was in the back. Having refrigerant leaking into the cabin is not great for health, especially that of a toddler. Additionally this could have caused an inability to defrost windows creating a safety hazard. All refrigerant leaked out leading to a condition where I had to drive in 90 - 100 degree temperatures with my daughter.

While driving, the brakes completely failed without any warning. There were no signs, alerts, or symptoms prior to the failure. The braking ability was suddenly and entirely lost, creating an extremely dangerous situation. Upon inspection, it was determined that the brake booster had failed. This component failure directly caused the complete loss of braking power. Because this occurred without warning or prior indication and such an unexpected failure not only poses a significant safety risk to the driver and passengers but endangers everyone on the road, and it represents a severe safety hazard. A sudden brake booster failure can easily lead to loss of vehicle control, accidents, injury, or even fatalities. Immediate action is required to address this serious issue that threatens public safety.

Vehicle started experiencing stalling and when trying to accelerate it would not pick up on speed, I have been quoted by Volvo that the supercharger is bad on a car that is only 6 years old. That repair for this is $2,000 as the engine valve also has to get cleaned out. The vehicle started having issue with AC after 2 years and now the front evaporator has gone bad and with summer Time is when I realized of this defect. $5,000 repair for the evaporator.

Vehicle started experiencing stalling and when trying to accelerate it would not pick up on speed, I have been quoted by Volvo that the supercharger is bad on a car that is only 6 years old. That repair for this is $2,000 as the engine valve also has to get cleaned out. The vehicle started having issue with AC after 2 years and now the front evaporator has gone bad and with summer Time is when I realized of this defect. $5,000 repair for the evaporator.

After a software update the backup camera’s field of view is super focused on the tailgate, license plate, and the immediate ground below. This is a safety concern as there have been a few near misses at parking lot speeds.

Car shut off while driving and rebooted. Was precessed by the infotainment system crashing and then rebooting a minute prior. Car made a sound like a grunting sound right as it shut down.

There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC around the 56,500 mile mark ([XXX]). After a couple of rounds of recharging the system with refrigerant and looking for a leak, the repair shop finally found the leak on the evaporator coil system. The repair was quoted cost $4,854.03. The evaporator coil During the summers when the AC was not working, this was definitely a safety concern. Riding in the car with no AC in the summertime in Hawaii is brutal. The $4,854.03 cost for the evaporator coil replacement, did not include the amount of money we spent the first two go arounds looking for the leak and recharging the system with refrigerant. After doing some research and talking to the repair shop the evaporator coil replacement work it seems that this is a very common failure on this model/year Volvo. I also noticed it looks like they already had a similar recall out for this failure on other similar Volvos. INFORMATION RE

The contact owns a 2019 Volvo XC90. The contact stated that after stopping and parking the vehicle, the vehicle failed to turn off. The contact's fiancée arrived on the scene and was able to turn off the vehicle; however, the vehicle later failed to restart, and the gear shifter seized. The message "Gear Lever Lock" was displayed. The vehicle was towed to an independent mechanic, who diagnosed that the panoramic sunroof seal strip had a gap, allowing debris and water into the vehicle, clogging the drain, and rendering the vehicle inoperable. The mechanic disassembled the entire interior and allowed it to dry before reassembling. The contact was informed that the front passenger’s side air bag sensor, seat belt buckle, and seat belt tensioner needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: TJ 35503.3.0 (Panoramic sunroof, sealing strip has a gap). The manufacturer was made aware of the failure. The failure mileage wa

Mileage: 65,000

The contact owns a 2019 Volvo XC90. The contact stated that after stopping and parking the vehicle, the vehicle failed to turn off. The contact's fiancée arrived on the scene and was able to turn off the vehicle; however, the vehicle later failed to restart, and the gear shifter seized. The message "Gear Lever Lock" was displayed. The vehicle was towed to an independent mechanic, who diagnosed that the panoramic sunroof seal strip had a gap, allowing debris and water into the vehicle, clogging the drain, and rendering the vehicle inoperable. The mechanic disassembled the entire interior and allowed it to dry before reassembling. The contact was informed that the front passenger’s side air bag sensor, seat belt buckle, and seat belt tensioner needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: TJ 35503.3.0 (Panoramic sunroof, sealing strip has a gap). The manufacturer was made aware of the failure. The failure mileage wa

Mileage: 65,000

The contact owns a 2019 Volvo XC90. The contact stated that after stopping and parking the vehicle, the vehicle failed to turn off. The contact's fiancée arrived on the scene and was able to turn off the vehicle; however, the vehicle later failed to restart, and the gear shifter seized. The message "Gear Lever Lock" was displayed. The vehicle was towed to an independent mechanic, who diagnosed that the panoramic sunroof seal strip had a gap, allowing debris and water into the vehicle, clogging the drain, and rendering the vehicle inoperable. The mechanic disassembled the entire interior and allowed it to dry before reassembling. The contact was informed that the front passenger’s side air bag sensor, seat belt buckle, and seat belt tensioner needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: TJ 35503.3.0 (Panoramic sunroof, sealing strip has a gap). The manufacturer was made aware of the failure. The failure mileage wa

Mileage: 65,000

There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC around the 56,500 mile mark ([XXX]). After a couple of rounds of recharging the system with refrigerant and looking for a leak, the repair shop finally found the leak on the evaporator coil system. The repair was recently completed on 10/22/2024 at the cost $4,254.03. This car has roughly 66000 miles on it now (12/07/2024). The evaporator coil During the summers when the AC was not working, this was definitely a safety concern. Riding in the car with no AC in the summertime in South Carolina is brutal. The $4,254.03 cost for the evaporator coil replacement, did not include the amount of money we spent the first two go arounds looking for the leak and recharging the system with refrigerant. After doing some research and talking to the repair shop who completed the evaporator coil replacement work it seems that this is a very common failure on this model/year Volvo. I a