2022 VOLVO XC60

ELECTRICAL SYSTEM:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

BACK OVER PREVENTION:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail

ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.

BACK OVER PREVENTION:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply w

STEERING

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.

SEAT BELTS:FRONT:RETRACTOR

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicl

The contact owns a 2022 Volvo XC60. The contact stated that while driving approximately 45 MPH during nighttime, the Forward Collision Avoidance system engaged while there were no vehicles or objects in front of the vehicle. The contact stated that the failure caused pain in her rib cage when the brake was suddenly applied. Medical attention was not sought. No warning lights were illuminated; however, the message "Front Collision Aversion Engaged" was displayed on the instrument panel. The vehicle was taken back to the residence, and the dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.

Mileage: 53,000

The contact owns a 2022 Volvo XC60. The contact stated that while operating the vehicle, the instrument cluster display screen independently reset and then displayed a blank screen. During the failure, the driver was unable to view the speedometer and the fuel gauge. There was no audible sound while activating the turn signal, and the doors failed to immediately lock and unlock while attempting to use the door switch. The vehicle was taken to the local dealer, but no cause for the failure was found. The contact stated that the failures recurred intermittently. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

Mileage: 30,000

The contact owns a 2022 Volvo XC60. The contact stated that while operating the vehicle, the instrument cluster display screen independently reset and then displayed a blank screen. During the failure, the driver was unable to view the speedometer and the fuel gauge. There was no audible sound while activating the turn signal, and the doors failed to immediately lock and unlock while attempting to use the door switch. The vehicle was taken to the local dealer, but no cause for the failure was found. The contact stated that the failures recurred intermittently. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

Mileage: 30,000

Even after the Volvo R10320 - WAM Upgrade recall, the backup camera is STILL unavailable at times when reversing. The recall and software update did not fix the issue. I would start the car and begin to reverse and met with "Camera is temporarily unavailable". I do not know what else do to as Volvo is slow to respond or provide anytime of upgrade or timely fix. This has happened multiple times and almost five times a week.

My car has been updated with software for a recall concerning the back up camera not operating when placed in reverse. This was an intermittent issue. The software has not fixed the problem as it continues to occur.

My backup camera operates intermittently, even after a recall was performed updating some software.

I purchased my 2022 Volvo XC60 in April 2025. I had no problems with the backup camera, until I installed a new version of software, 3.7, over the air, in September. The update was described as addressing a recall, for a safety issue where the backup camera would sometimes not work. Since the recall update, I've had issues with the backup camera not working, at the same time all of the cameras, proximity warnings, and rear emergency braking do not work. Far from this software update fixing a safety concern, it appears to have created one. The only answer I could get from the Volvo USA help line was to "take it to a dealer". I thought they would be more concerned given that they have just carried out a recall action that has created a safety issue!

I purchased my 2022 Volvo XC60 in April 2025. I had no problems with the backup camera, until I installed a new version of software, 3.7, over the air, in September. The update was described as addressing a recall, for a safety issue where the backup camera would sometimes not work. Since the recall update, I've had issues with the backup camera not working, at the same time all of the cameras, proximity warnings, and rear emergency braking do not work. Far from this software update fixing a safety concern, it appears to have created one. The only answer I could get from the Volvo USA help line was to "take it to a dealer". I thought they would be more concerned given that they have just carried out a recall action that has created a safety issue!

While driving on crowded I40 near Statesville NC, the engine started to stutter and moments later quit entirely. Fortunately we were able to move to the shoulder with only a few seconds to spare. This was very dangerous as we had to move through the right lane in front of speeding semi trucks. The only warning light received was that there was an engine problem, that the car would go into “safe” mode. This was mere seconds before entirely disabling the engine. Had we come to a halt on the highway there would have been a serious accident and injury to ourselves and most likely others. We contacted Volvo, a tow was dispatched and the car was winched on to a flat bed trailer and we were transported to a dealer in Hickory. Later it was confirmed that the Integrated Starter General (ISG) had failed and that power had been interrupted to the hybrid battery. There is a serious problem here and I suspect may impact other “mild hybrid” systems that install integrated alternator/starte

While driving on crowded I40 near Statesville NC, the engine started to stutter and moments later quit entirely. Fortunately we were able to move to the shoulder with only a few seconds to spare. This was very dangerous as we had to move through the right lane in front of speeding semi trucks. The only warning light received was that there was an engine problem, that the car would go into “safe” mode. This was mere seconds before entirely disabling the engine. Had we come to a halt on the highway there would have been a serious accident and injury to ourselves and most likely others. We contacted Volvo, a tow was dispatched and the car was winched on to a flat bed trailer and we were transported to a dealer in Hickory. Later it was confirmed that the Integrated Starter General (ISG) had failed and that power had been interrupted to the hybrid battery. There is a serious problem here and I suspect may impact other “mild hybrid” systems that install integrated alternator/starte

While driving on crowded I40 near Statesville NC, the engine started to stutter and moments later quit entirely. Fortunately we were able to move to the shoulder with only a few seconds to spare. This was very dangerous as we had to move through the right lane in front of speeding semi trucks. The only warning light received was that there was an engine problem, that the car would go into “safe” mode. This was mere seconds before entirely disabling the engine. Had we come to a halt on the highway there would have been a serious accident and injury to ourselves and most likely others. We contacted Volvo, a tow was dispatched and the car was winched on to a flat bed trailer and we were transported to a dealer in Hickory. Later it was confirmed that the Integrated Starter General (ISG) had failed and that power had been interrupted to the hybrid battery. There is a serious problem here and I suspect may impact other “mild hybrid” systems that install integrated alternator/starte

Volvo recall R10320 remedy failed to fix recall issue.

Manufacturer Recall NumberR10320 NHTSA Recall Number25V282 the recall for "Camera is Temporarily Not Available" was preformed at dealer on Monday 7/14/2025 today the same message appear on the display screen when I went to backup in a parking lot. Software version shows it as unto date in settings 3.7.##

Manufacturer Recall NumberR10320 NHTSA Recall Number25V282 the recall for "Camera is Temporarily Not Available" was preformed at dealer on Monday 7/14/2025 today the same message appear on the display screen when I went to backup in a parking lot. Software version shows it as unto date in settings 3.7.##

Manufacturer Recall NumberR10320 NHTSA Recall Number25V282 the recall for "Camera is Temporarily Not Available" was preformed at dealer on Monday 7/14/2025 today the same message appear on the display screen when I went to backup in a parking lot. Software version shows it as unto date in settings 3.7.##

The back up camera frequently does not work. When you put the car in reverse, the screen where the back up view should appear will state, “Camera is Temporarily Unavailable “. The dealer replaced the camera with no improvement. This fault occurs several times per week.

My vehicle is an XC60. The headlights fogged up and the fog caused issues with driving in the dark. It took four days for the fog to resolve itself. During that time, at night, you could see the fogged areas in the beam. I took the car to a Volvo dealership and they were not able to replicate the issue, likely because it is not as hot now as it was when this occurred. They told me to open a case with Volvo USA. I sent them photographs. They then responded that there was no evidence of condensation, but condensation was normal and would clear up as it did in this case. The sentence is clear that there was condensation while saying there was no condensation. The headlights are a safety issue and the car is under warranty for 10 years. The headlights should be replaced. I shouldn’t be in a position to fight a company that prides itself on safety about headlights, which are critical for safe driving at night. This is a common issue. I searched and found multiple people with the same prob

The contact owns a 2022 Volvo XC60. The contact stated while driving 50 MPH, the vehicle decelerated independently and then stalled. The contact pulled over to the side of the roadway and turned off the vehicle. While attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed back to residence and then towed to a dealer to be diagnosed. The contact was informed that there was coolant leaking into the engine, and the battery needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 22V793000 (ENGINE AND ENGINE COOLING). The manufacturer was notified of the failure. The failure mileage was unknown.

System regularly displays "Camera is temporarily unavailable" when backing up, requires full reboot of head unit to resolve. Backup cameras regularly not activating upon vehicle startup. This is a daily occurrence and has not been fixed with updates (in fact, it's gotten more frequent).

Case number 240821-000271 was opened on 8/21/24 with Volvo Car USA Support. I have three main concerns: 1) The infotainment system losing the favorites that I have saved in the Sirius application. This had been an intermittent problem that I had been having since I purchased the car. I finally took it into the service department at Volvo Cars of Gilbert on 1/7/23 for this problem (Invoice Number VOCS110975). The service department was unable to recreate the problem so they did nothing. 2)A complete car system reboot while I was driving on 6/10/24. As I was driving down the road the HVAC system shut off and the dash and infotainment system screens went blank. All car systems completely shut down except the engine. This was an extremely frightening experience as all of this happened with no warning whatsoever WHILE I WAS DRIVING. This is a huge safety issue! Within about a minute of driving like this the systems started to come back up. I proceeded home. The next morning I took the c