2014 VOLVO VNL

SEAT BELTS

Volvo Trucks North America (Volvo) is recalling certain model year 2014 VAH, VHD, VNL, and VNM trucks manufactured August 12, 2013, through November 14, 2013; and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially

POWER TRAIN:CLUTCH ASSEMBLY

Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch fr

ENGINE AND ENGINE COOLING:ENGINE

Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper opera

SERVICE BRAKES, AIR

Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Volvo is recalling certain model year 2012-2014 VHD, VNL, and VNM trucks, manufactured from April 18, 2011, through March 14, 2013, and equipped with a horizontally mounted remote battery disconnect switch. The remote battery disconnect switch was manufactured with incorrect hardware allowing the c

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings. In the affected vehicles, the active braking component of the e

POWER TRAIN:AUTOMATIC TRANSMISSION

Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco

TIRES

Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.

SERVICE BRAKES

Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.

SERVICE BRAKES, AIR:DISC:CALIPER

Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach fr

POWER TRAIN:DRIVELINE:DRIVESHAFT

Volvo Trucks North America is recalling certain model year 2013-2014 VNL vehicles manufactured April 2, 2012, through May 3, 2013; and equipped with a Meritor RPL-20 driveline transmission. The driveshaft is too weak for this application and may fail.

ELECTRICAL SYSTEM

Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS). The affected APUs have metal hou

The affected component is part of the exhaust aftertreatment system, also known as the selective catalytic reduction (SCR) system. These systems were implemented in nearly all Class 8 truck engines in the U.S. to meet 2010 emissions standards. The degradation could put the engines out of compliance with emissions standards. This is a very costly repair in excess of $10,000 in a truck with only 466,000 miles on it. we have had in many times and lots of repair cost to try to keep the truck in compliance and continues to go in Derate.

VOLVO ENGINE INJECTOR AIR LEAK ON ANTIFREEZE AND VOLVO THEY NO ONE FIX DE INJECTOARE THEY ARE BAD

THE RECALL STATES: IMPROPERLY FUNCTIONING ON-BOARD EMISSION-RELATED DIANOTIC SYSTEM THAT VIOLATES CALIFORNIA AND FEDERAL STANDARD AND REGULATIONS.

TL* THE CONTACT OWNS A 2014 VOLVO VNL. WHILE DRIVING AT A LOW SPEED, THE CONTACT NOTICED COOLANT LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE CONTACT NOTICED THAT THE GRILL WAS BENT FROM THE CONTINUAL OPENING AND CLOSING OF THE HOOD. THE DEALER DIAGNOSED THAT A VALVE AND THE GRILL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE GRILL WAS NEVER PROPERLY ATTACHED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 390,000.

Mileage: 390,000

TL* THE CONTACT OWNS A 2014 VOLVO VNL. WHILE DRIVING AT A LOW SPEED, THE CONTACT NOTICED COOLANT LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE CONTACT NOTICED THAT THE GRILL WAS BENT FROM THE CONTINUAL OPENING AND CLOSING OF THE HOOD. THE DEALER DIAGNOSED THAT A VALVE AND THE GRILL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE GRILL WAS NEVER PROPERLY ATTACHED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 390,000.

Mileage: 390,000

TL* THE CONTACT OWNS A 2014 VOLVO VNL. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 55 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRAG LINK IN THE STEERING NEEDED TO BE REPLACED.THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 229,000.

Mileage: 229,000

ON 10/1, UNIT WAS LOCATED AT MILE MARKER 153 ON I-40 NEAR ASH FORK AZ, WHEN THEIR FRONT PASSENGER STEER TIRE'S TREAD DETACHED (MICHELIN XZA 3+ 275/80/R22.5 DOT#M5EJ00EX3213). THE TREAD ACTED LIKE A FLAIL AND CAUSED APPROXIMATELY $12,000 IN DAMAGE TO THE VEHICLE. THE DRIVER WAS ABLE TO MAINTAIN CONTROL AND BRING THE TRUCK SAFELY TO THE ROAD SHOULDER. A STATE TROOPER WAS CALLED TO THE SITE. ONCE HE ARRIVED, THE TROOPER INSURED THAT THE TRUCK WAS SAFE FROM TRAFFIC AND INSPECTED FOR DEBRIS/CAUSATION. HE FOUND NO DEBRIS TO CAUSE INCIDENT. HIS OPINION, ALONG WITH THE DRIVERS, IS THAT THE TIRE FAILED. THE TROOPER WOULD NOT PROVIDE AN ACCIDENT REPORT AS NO OTHER VEHICLE WAS INVOLVED AND NO PROPERTY ADDITIONAL DAMAGED. THE TEAM PERFORMS REGULAR VISUAL AND PRESSURE INSPECTIONS. THE TRUCK WAS DISABLED FOR WEEKS FROM THE INCIDENT. ONCE REPAIRED, THE TEAM NOTICED WHAT APPEARED TO BE READ SEPARATION ON THE MATCHED FRONT DRIVER STEER TIRE (SAME DOT#) AND REPLACED TIRE FOR SAFETY REASONS. TIRES ARE

Mileage: 100,000

ON 10/1, UNIT WAS LOCATED AT MILE MARKER 153 ON I-40 NEAR ASH FORK AZ, WHEN THEIR FRONT PASSENGER STEER TIRE'S TREAD DETACHED (MICHELIN XZA 3+ 275/80/R22.5 DOT#M5EJ00EX3213). THE TREAD ACTED LIKE A FLAIL AND CAUSED APPROXIMATELY $12,000 IN DAMAGE TO THE VEHICLE. THE DRIVER WAS ABLE TO MAINTAIN CONTROL AND BRING THE TRUCK SAFELY TO THE ROAD SHOULDER. A STATE TROOPER WAS CALLED TO THE SITE. ONCE HE ARRIVED, THE TROOPER INSURED THAT THE TRUCK WAS SAFE FROM TRAFFIC AND INSPECTED FOR DEBRIS/CAUSATION. HE FOUND NO DEBRIS TO CAUSE INCIDENT. HIS OPINION, ALONG WITH THE DRIVERS, IS THAT THE TIRE FAILED. THE TROOPER WOULD NOT PROVIDE AN ACCIDENT REPORT AS NO OTHER VEHICLE WAS INVOLVED AND NO PROPERTY ADDITIONAL DAMAGED. THE TEAM PERFORMS REGULAR VISUAL AND PRESSURE INSPECTIONS. THE TRUCK WAS DISABLED FOR WEEKS FROM THE INCIDENT. ONCE REPAIRED, THE TEAM NOTICED WHAT APPEARED TO BE READ SEPARATION ON THE MATCHED FRONT DRIVER STEER TIRE (SAME DOT#) AND REPLACED TIRE FOR SAFETY REASONS. TIRES ARE

Mileage: 100,000

ON THE FIRST DAY I TOOK THIS BRAND NEW 2014 VOLVO VNL SLEEPER TRUCK OFF THE LOT THE DEF SYSTEM FAILED AND SHUT MY TRUCK DOWN I WAS BARELY ABLE TO GET IT BACK TO THE DEALER'S. MASSIVE DRIVE LINE VIBRATION ALSO FELT BUT DEALER COULD NOT FIGURE OUT THE PROBLEM SIX MONTHS LATER TRANSMISSION FAILURE. I ALSO SUFFERED 3 OF 8 SHOCK FAILURE TRUCK WAS FLOATING AND SWAYING IN HIGH WINDS VERY DANGEROUS. THE ALTERNATOR FAILED SIX MONTHS LATER NO WARNING STARTING OVER CHARGING I WAS GOING THROUGH THE SYSTEM CHECK AND DETECTED IT BEFORE IT BLEW AN ECM. I ALSO SUFFERED A OIL PRESSURE SENSOR FAILURE THIS PROBLEM HAS BEEN IN THE VOLVO TRUCKS SINCE THEIR 2009 MODEL AND THEY ARE STILL USING THE OLD SENSORS. I HAVE SUFFERED MASSIVE DOWN TIME AND LOSS OF REVENUE DUE TO THIS AND HOPE THEY IMPROVE THEIR PRODUCT. THEIR ARE MANY OTHER DRIVER SUFFERING THESE SAME PROBLEM BUT DUE TO COMPUTER ILLITERACY THEY CAN'T GIVE VOICE TO THEIR ISSUES THANKS. *TR

Mileage: 200

ON THE FIRST DAY I TOOK THIS BRAND NEW 2014 VOLVO VNL SLEEPER TRUCK OFF THE LOT THE DEF SYSTEM FAILED AND SHUT MY TRUCK DOWN I WAS BARELY ABLE TO GET IT BACK TO THE DEALER'S. MASSIVE DRIVE LINE VIBRATION ALSO FELT BUT DEALER COULD NOT FIGURE OUT THE PROBLEM SIX MONTHS LATER TRANSMISSION FAILURE. I ALSO SUFFERED 3 OF 8 SHOCK FAILURE TRUCK WAS FLOATING AND SWAYING IN HIGH WINDS VERY DANGEROUS. THE ALTERNATOR FAILED SIX MONTHS LATER NO WARNING STARTING OVER CHARGING I WAS GOING THROUGH THE SYSTEM CHECK AND DETECTED IT BEFORE IT BLEW AN ECM. I ALSO SUFFERED A OIL PRESSURE SENSOR FAILURE THIS PROBLEM HAS BEEN IN THE VOLVO TRUCKS SINCE THEIR 2009 MODEL AND THEY ARE STILL USING THE OLD SENSORS. I HAVE SUFFERED MASSIVE DOWN TIME AND LOSS OF REVENUE DUE TO THIS AND HOPE THEY IMPROVE THEIR PRODUCT. THEIR ARE MANY OTHER DRIVER SUFFERING THESE SAME PROBLEM BUT DUE TO COMPUTER ILLITERACY THEY CAN'T GIVE VOICE TO THEIR ISSUES THANKS. *TR

Mileage: 200

TL* THE CONTACT OWNS A 2014 VOLVO VNL. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO PROPERLY CLEAR THE WINDSHIELD AND REDUCED VISIBILITY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124. UPDATED 06/10/14*LJ UPDATED 8/22/2017*CN

Mileage: 124