Total Complaints
6 filings
VOLVO VN · model year
2007 VOLVO VN
6 NHTSA complaints, and 3 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2007VOLVOVN carries 6 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2007 VN is unknown or other with 1 filings, followed by wheels:rim (1) and power train:clutch assembly (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 28 investigation files overlapping the 2007 VN. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
6
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| UNKNOWN OR OTHER | 1 |
| WHEELS:RIM | 1 |
| POWER TRAIN:CLUTCH ASSEMBLY | 1 |
| ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 1 |
| POWER TRAIN | 1 |
| ENGINE | 1 |
Recalls (3)
12V51000018/10/2012
SEAT BELTS
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to th
10V57100012/11/2010
SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE
VOLVO TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 AND 2009 VHD, MODEL YEAR 2006 THROUGH 2010 VN, AND MODEL YEAR 2007 THROUGH 2009 VT TRUCKS MANUFACTURED FROM NOVEMBER 7, 2005, THROUGH OCTOBER 30, 2009, EQUIPPED WITH AN AIR RELEASE FIFTH WHEEL. THE INVERSION VALVE ON THE FRAME MAY BE ORIENTATED WHER
06V09900004/04/2006
STEERING:GEAR BOX:SHAFT SECTOR
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH DANA STEERING SHAFTS, THERE IS A POTENTIAL THAT THE STEERING SHAFT PINCH BOLT HOLE MAY BE INCORRECTLY LOCATED. THE PINCH BOLT FITS INTO A GROOVE IN THE STEERING GEAR INPUT SHAFT TO ENSURE THAT THE STEERING SHAFT DOES NOT SEPARATE FROM THE STEERING
Recent Complaints
20140209POWER TRAIN
WHILE DRIVING ON INTERSTATE 85 TRUCK STARTED MAKING NOISE AND COOLANT LIGHT CAME ON. AFTER OPENING HOOD NOTICE FAN DISLODGED AND COOLANT COMPLETELY GONE FROM RADIATOR. CALLED A REPAIR SHOP WHO DIAGNOSED THE FAN HUB BEARING HAD FAILED CAUSING THE FAN TO BREAK THEN CAUSING A CHAIN REACTION OF OTHER PARTS SUCH AS PENETRATING A HOLE IN RADIATOR AND POSSIBLY TURBO AIR TUBES AND OTHER MINOR HOSES AND BELTS AND REPLACEMENT OF FLUIDS TRANSMISSION AND COOLANT. THE TOTAL BILL ESCALATED TO ALMOST $7000.00 DOLLARS FOR WHICH IT SEEMED TO BE OVER BILLED BY THE REPAIR SHOP OF ABOUT 2000.00 DOLLARS. THIS COULD OF BEEN PREVENTED IF A SIMPLE DESIGN OF A BRACE TO HOLD FAN IN PLACE WHEN FAN HUB FAILS. *TR
Mileage: 789,000
20140209ENGINE
WHILE DRIVING ON INTERSTATE 85 TRUCK STARTED MAKING NOISE AND COOLANT LIGHT CAME ON. AFTER OPENING HOOD NOTICE FAN DISLODGED AND COOLANT COMPLETELY GONE FROM RADIATOR. CALLED A REPAIR SHOP WHO DIAGNOSED THE FAN HUB BEARING HAD FAILED CAUSING THE FAN TO BREAK THEN CAUSING A CHAIN REACTION OF OTHER PARTS SUCH AS PENETRATING A HOLE IN RADIATOR AND POSSIBLY TURBO AIR TUBES AND OTHER MINOR HOSES AND BELTS AND REPLACEMENT OF FLUIDS TRANSMISSION AND COOLANT. THE TOTAL BILL ESCALATED TO ALMOST $7000.00 DOLLARS FOR WHICH IT SEEMED TO BE OVER BILLED BY THE REPAIR SHOP OF ABOUT 2000.00 DOLLARS. THIS COULD OF BEEN PREVENTED IF A SIMPLE DESIGN OF A BRACE TO HOLD FAN IN PLACE WHEN FAN HUB FAILS. *TR
Mileage: 789,000
20100916POWER TRAIN:CLUTCH ASSEMBLY
TL*THE CONTACT OWNS A 2007 VOLVO VN. WHILE THE VEHICLE WAS STOPPED HE DISENGAGED THE CLUTCH AND THE VEHICLE BEGAN TO MOVE FORWARD. HE APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE CONTINUED TO MOVE FORWARD UNTIL HE SHUT THE ENGINE OFF. THE VEHICLE WAS TOWED AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE CLUTCH SPRING BROKE AND IT WAS REPAIRED. THE FAILURE DID NOT RECUR. HE ALSO STATED THAT THE VEHICLE EXPERIENCED THREE SEPARATE FAILURES IN WHICH THE ENGINE TURBO WOULD FAIL. HE EXPERIENCED A LOSS OF ENGINE POWER WHILE DRIVING ON THREE OCCASIONS IN WHICH THE VEHICLE WAS BE TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 253,000. UPDATED 12/15/10*LJ UPDATED 12/27/10
Mileage: 253,000
20100916ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL*THE CONTACT OWNS A 2007 VOLVO VN. WHILE THE VEHICLE WAS STOPPED HE DISENGAGED THE CLUTCH AND THE VEHICLE BEGAN TO MOVE FORWARD. HE APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE CONTINUED TO MOVE FORWARD UNTIL HE SHUT THE ENGINE OFF. THE VEHICLE WAS TOWED AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE CLUTCH SPRING BROKE AND IT WAS REPAIRED. THE FAILURE DID NOT RECUR. HE ALSO STATED THAT THE VEHICLE EXPERIENCED THREE SEPARATE FAILURES IN WHICH THE ENGINE TURBO WOULD FAIL. HE EXPERIENCED A LOSS OF ENGINE POWER WHILE DRIVING ON THREE OCCASIONS IN WHICH THE VEHICLE WAS BE TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 253,000. UPDATED 12/15/10*LJ UPDATED 12/27/10
Mileage: 253,000
20080522UNKNOWN OR OTHER
2007 VOLVO CONVENTIONAL WAS STRUCK BY A TIRE WHILE DRIVING ON THE OHIO TURNPIKE. CONSUMER STATES THAT THE TIRE CAME OFF ANOTHER VEHICLE AND THEN HIT THE TRUCK. *KB
20080522WHEELS:RIM
2007 VOLVO CONVENTIONAL WAS STRUCK BY A TIRE WHILE DRIVING ON THE OHIO TURNPIKE. CONSUMER STATES THAT THE TIRE CAME OFF ANOTHER VEHICLE AND THEN HIT THE TRUCK. *KB
Compare 2007VOLVOVN to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2007 VOLVO VN have?▼
The 2007 VOLVO VN has 6 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2007 VOLVO VN?▼
Yes, the 2007 VOLVO VN has 3 recall(s). The most common affected component is SEAT BELTS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2007 VOLVO VN?▼
The most-complained component for the 2007 VOLVO VN is UNKNOWN OR OTHER with 1 complaints. Other frequently reported areas include WHEELS:RIM and POWER TRAIN:CLUTCH ASSEMBLY.
Is the 2007 VOLVO VN safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.