Total Complaints
3 filings
VOLVO VHD · model year
2007 VOLVO VHD
3 NHTSA complaints, and 10 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2007VOLVOVHD carries 3 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 1 fire, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2007 VHD is engine and engine cooling:cooling system with 2 filings, followed by engine and engine cooling:exhaust system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 10 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 28 investigation files overlapping the 2007 VHD. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
3
Complaints
0
Crashes
1
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 2 |
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
Recalls (10)
18V76600030/10/2018
EXTERIOR LIGHTING
Volvo Trucks North America (Volvo) is recalling certain 2004-2019 Volvo VHD trucks equipped with snow plow lamp preparation kits. The snow plow headlights can be turned on without other exterior lights, and high beam indicator will not work when the snow plow high beams are on. As such, these vehicl
13V26800026/06/2013
POWER TRAIN:CLUTCH ASSEMBLY
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch fr
07V32300024/07/2007
STEERING
ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.
07V49600023/10/2007
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PI
09V17300021/05/2009
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
12V51000018/10/2012
SEAT BELTS
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to th
07V57300014/12/2007
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
10V57100012/11/2010
SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE
VOLVO TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 AND 2009 VHD, MODEL YEAR 2006 THROUGH 2010 VN, AND MODEL YEAR 2007 THROUGH 2009 VT TRUCKS MANUFACTURED FROM NOVEMBER 7, 2005, THROUGH OCTOBER 30, 2009, EQUIPPED WITH AN AIR RELEASE FIFTH WHEEL. THE INVERSION VALVE ON THE FRAME MAY BE ORIENTATED WHER
07V34500007/08/2007
FUEL SYSTEM, DIESEL
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
06V09900004/04/2006
STEERING:GEAR BOX:SHAFT SECTOR
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH DANA STEERING SHAFTS, THERE IS A POTENTIAL THAT THE STEERING SHAFT PINCH BOLT HOLE MAY BE INCORRECTLY LOCATED. THE PINCH BOLT FITS INTO A GROOVE IN THE STEERING GEAR INPUT SHAFT TO ENSURE THAT THE STEERING SHAFT DOES NOT SEPARATE FROM THE STEERING
Recent Complaints
20101212ENGINE AND ENGINE COOLING:COOLING SYSTEM
2007 VOLVO VHD HEAVY TRUCK. VOLVO VED12 ENGINE. EGR COOLER FAILURE RESULTING IN HEAVY TRUCK DISABLED ON HIGHWAY. NEAR MISS ACCIDENT FROM VEHICLES APPROACHING FROM REAR. ENVIRONMENTAL DISCHARGE OF ENGINE COOLANT AND HEAVY SMOKE. SPEAKING WITH VOLVO TRUCK REPRESENTATIVES AND OTHER VOLVO TRUCK OWNERS, IT IS LIKELY THAT THIS IS A SYSTEMATIC PROBLEM FOR VOLVO TRUCKS WITH VOLVO VED-12 ENGINES. *TR
Mileage: 227,000
20101212ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
2007 VOLVO VHD HEAVY TRUCK. VOLVO VED12 ENGINE. EGR COOLER FAILURE RESULTING IN HEAVY TRUCK DISABLED ON HIGHWAY. NEAR MISS ACCIDENT FROM VEHICLES APPROACHING FROM REAR. ENVIRONMENTAL DISCHARGE OF ENGINE COOLANT AND HEAVY SMOKE. SPEAKING WITH VOLVO TRUCK REPRESENTATIVES AND OTHER VOLVO TRUCK OWNERS, IT IS LIKELY THAT THIS IS A SYSTEMATIC PROBLEM FOR VOLVO TRUCKS WITH VOLVO VED-12 ENGINES. *TR
Mileage: 227,000
20090712FireENGINE AND ENGINE COOLING:COOLING SYSTEM
HORTON FAN HUB FAILURE SIMILAR TO ACTION NUMBER EA09-008 FOR FAILURE IN KENWORTH AND PETERBILIT TRUCKS. I HAVE A VOLVO TRUCK (2007 VHD) THAT IS ON ITS THIRD HORTON FAN HUB. VERY EXPENSIVE FAILURE, IDENTICAL DESIGN PROBLEM TO KENWORTH AND PETERBILT, ITS TIME TO LINK THIS PROBLEM TO VOLVO TOO. *TR
Mileage: 45,000
Compare 2007VOLVOVHD to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2007 VOLVO VHD have?▼
The 2007 VOLVO VHD has 3 NHTSA complaints, 0 crashes, 1 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2007 VOLVO VHD?▼
Yes, the 2007 VOLVO VHD has 10 recall(s). The most common affected component is EXTERIOR LIGHTING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2007 VOLVO VHD?▼
The most-complained component for the 2007 VOLVO VHD is ENGINE AND ENGINE COOLING:COOLING SYSTEM with 2 complaints. Other frequently reported areas include ENGINE AND ENGINE COOLING:EXHAUST SYSTEM.
Is the 2007 VOLVO VHD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.