Total Complaints
5 filings
VOLVO V70XC · model year
2004 VOLVO V70XC
5 NHTSA complaints. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004VOLVOV70XC carries 5 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 1 fire, 1 injury, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2004 V70XC is fuel/propulsion system with 2 filings, followed by fuel system, gasoline (1) and seats (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause.
NHTSA currently has 28 investigation files overlapping the 2004 V70XC. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
5
Complaints
0
Crashes
1
Fires
1
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| FUEL/PROPULSION SYSTEM | 2 |
| FUEL SYSTEM, GASOLINE | 1 |
| SEATS | 1 |
| SUSPENSION | 1 |
Recent Complaints
20170520SUSPENSION
I WAS DEPARTING MY HOME VILLAGE ABOUT A BLOCK FROM MY HOME AND I HEARD A LOUD BANG IN THE FRONT DRIVER SIDE AT ABOUT 15 MPH!! NO BUMP.. NOTHING! I LOOKED UNDER THE CAR AND THERE WAS NO OBVIOUS ISSUE AT THE INITIAL LOOK AND I DROVE ANOTHER QUARTER MILE AND HEARD A SLIGHT GRIND OR NOISE ON SMALL BUMPS... THEN A CLANK. I BACKED UP AND THERE WAS A PIECE OF THE COIL SPRING ON THE ROAD!!!! THE FRONT LEFT - DRIVERS SIDE - COIL SPRING SNAPPED IN TWO. AT 101,000 MILES. THE CLEAN BREAK AND NO RUST OR UNUSUAL CORROSION INDICATES A FAULTY METAL. HOW CAN I TRUST THE VOLVO XC AGAIN!! SAFETY AND VOLVO ARE NO LONGER WORDS THAT SHOULD BE USED TOGETHER. MY COMPLAINTS TO VOLVO AMERICA WERE RESPONDED TO WITH NO CONSIDERATION TO THE MAGNITUDE OF THE ISSUE. VOLVO DID NOT STAND BEHIND THE OBVIOUS FLAW IN THE CONSTRUCTION OF THE VEHICLE. MANY OTHER COMPLAINTS ON NHTSA AND ONLINE FORUMS INDICATE A COMMON ISSUE WITH VOLVO XC SUSPENSION COIL SPRINGS. SO DANGEROUS!
Mileage: 101,000
20150921FUEL/PROPULSION SYSTEM
ENTERING MY VEHICLE I SMELLED A STRONG ODOR OF GASOLINE. UPON INVESTIGATION, I FOUND THIS WAS DUE TO A CRACKED FUEL PUMP. BECAUSE OF THIS VERY PROBLEM, THIS MAKE AND MODEL OF VEHICLE WAS OFFICIALLY RECALLED BY VOLVO IN 2009 AS PART OF NHTSA ACTION NUMBER : PE09039 NHTSA RECALL CAMPAIGN NUMBER : 09V483000 . HOWEVER THE RECALL ONLY APPLIES TO VEHICLES SOLD IN AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES. THE PROBLEM CAN HAPPEN TO ANY OF THESE CARS REGARDLESS OF WHERE THEY WERE SOLD. THE TEMPERATURE FLUCTUATIONS THAT MAY BE RESPONSIBLE FOR THE SAFETY HAZARD OCCUR IN NEW ENGLAND AS WELL AS THE SOUTH AND WEST. THE DEFECTIVE PART AND SAFETY ISSUE EXISTS FOR ALL OWNERS OF THESE CARS AND EVERY ONE OF THEM SHOULD BE RECALLED.
Mileage: 890,000
20150319FireSEATS
THE DRIVER SIDE SEAT WARMER CAUGHT FIRE. IT BURNED A HOLE THROUGH THE SIDE OF THE SEAT COVER AND ALSO CAUSED A MILD BURN TO MY LEG. I STOPPED THE CAR, SHUT OF THE SEAT WARMER, AND WAS ABLE TO EXTINGUISH THE FIRE WHILE IT WAS STILL SMALL. A SEARCH ON THE INTERNET REVEALED THAT OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR
Mileage: 234,123
20121216FUEL/PROPULSION SYSTEM
FUEL SMELL COMING FROM TRUNK. POSSIBLE COMBUSTION. PREVIOUS RECALL WAS NOT EXTENDED TO COLORADO, BUT AS THE FRONT RANGE SUMMER TEMPERATURES AND DRYNESS ARE AN INDICATOR OF FAILURE, I WORRY THAT THIS RECALL SHOULD BE EXTENDED TO COLORADO OWNERS. *TR
Mileage: 105,000
20090921FUEL SYSTEM, GASOLINE
THE FUEL PUMP IN MY 2004 VOLVO XC70 FAILED, CAUSING GAS TO LEAK FROM THE VEHICLE. I UNDERSTAND FROM A NYT ARTICLE THAT THERE ARE SEVERAL COMPLAINTS INTO NHTSA REGARDING A SIMILAR CONDITION IN THE 2004 XC90. THE LEAKING PUMP WAS REPAIRED BY A VOLVO DEALER AT CONSIDERABLE ($1300) COST. *TR
Mileage: 57,000
Compare 2004VOLVOV70XC to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 VOLVO V70XC have?▼
The 2004 VOLVO V70XC has 5 NHTSA complaints, 0 crashes, 1 fires, 1 injuries, and 0 deaths reported.
What are the most common problems with the 2004 VOLVO V70XC?▼
The most-complained component for the 2004 VOLVO V70XC is FUEL/PROPULSION SYSTEM with 2 complaints. Other frequently reported areas include FUEL SYSTEM, GASOLINE and SEATS.
Is the 2004 VOLVO V70XC safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2004 VOLVO V70XC; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.