Total Complaints
4 filings
VOLVO S90 · model year
2020 VOLVO S90
4 NHTSA complaints, and 3 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2020VOLVOS90 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2020 S90 is service brakes with 1 filings, followed by wheels (1) and suspension (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 28 investigation files overlapping the 2020 S90. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES | 1 |
| WHEELS | 1 |
| SUSPENSION | 1 |
| FORWARD COLLISION AVOIDANCE: WARNINGS | 1 |
Recalls (3)
25V17900024/03/2025
ELECTRICAL SYSTEM:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
20V14400012/03/2020
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
21V41400002/06/2021
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Recent Complaints
20220823FORWARD COLLISION AVOIDANCE: WARNINGS
On 8/22 while driving on a city road in extreme rainy conditions the vehicle in front of me drove through standing water, which created significant spray. As a result the City Safety feature of my Volvo S90 engaged in an extreme fashion. Without any risk of an impending collision the City Safety feature determined the water spray to be an obstacle and fully engaged the brakes (ABS event) to avoid the impending collision including engaging seat-belt pre-tensioning. I was lucky as the drive behind me was paying attention and swerved to avoid rear ending my abruptly stopping vehicle without any intervention from me as the driver. I believe that the issue was caused due to the City Safety system incorrectly detecting the water spray as an impeding crash. This seems to be a system calibration that could have been addressed during development. I wanted to notify NHTSA of this situation so you can be aware and monitor the impact of these driver assist features on overall road safety.
20211207SERVICE BRAKES
- Brakes, Wheels, and possibly suspension. - Car shudders under braking, impacts stopping ability. All tires vibrate while driving. Wheels are warped/damaged. - Vehicle went to the dealer. Replaced all four rotors, repaired all for rims. - I have reached out to the manufacturer for support. They declined to get involved. - No messages or warnings
20211207WHEELS
- Brakes, Wheels, and possibly suspension. - Car shudders under braking, impacts stopping ability. All tires vibrate while driving. Wheels are warped/damaged. - Vehicle went to the dealer. Replaced all four rotors, repaired all for rims. - I have reached out to the manufacturer for support. They declined to get involved. - No messages or warnings
20211207SUSPENSION
- Brakes, Wheels, and possibly suspension. - Car shudders under braking, impacts stopping ability. All tires vibrate while driving. Wheels are warped/damaged. - Vehicle went to the dealer. Replaced all four rotors, repaired all for rims. - I have reached out to the manufacturer for support. They declined to get involved. - No messages or warnings
Compare 2020VOLVOS90 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2020 VOLVO S90 have?▼
The 2020 VOLVO S90 has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2020 VOLVO S90?▼
Yes, the 2020 VOLVO S90 has 3 recall(s). The most common affected component is ELECTRICAL SYSTEM:SOFTWARE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2020 VOLVO S90?▼
The most-complained component for the 2020 VOLVO S90 is SERVICE BRAKES with 1 complaints. Other frequently reported areas include WHEELS and SUSPENSION.
Is the 2020 VOLVO S90 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.