2019 VOLVO S60

SUSPENSION:REAR

Volvo Car USA LLC (Volvo) is recalling certain 2019 S60 vehicles. The rear suspension toe link flange lock nuts may not have been properly tightened, possibly resulting in a sudden change in vehicle handling.

AIR BAGS:FRONTAL

Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

The crimping on the A/C hose from the firewall to the compressor failed and leaked all the freon from the system. This is a design flaw, the mounting location causes excess vibration in the hose leading to the crimping failure. There are countless forum posts and other complaints filed by owners of the same vehicle for the exact same A/C hose. This should be a recall from Volvo. It is a major safety issue for customers like me who live in a humid environment, without A/C the windshield can fog over and hinder visibility. I contacted Volvo Customer Care for reimbursement and was denied as my car was not under warranty. My car only has 40,000 miles on it and this part shouldnt fail in this manner, especially at my low mileage. I have since purchased their extended warranty as this part will eventually fail again (from the design flaw in A/C system mounting location) and I don't want to pay the large repair costs again. The NHTSA should investigate this with all owners of this year/make/m

The crimping on the A/C hose from the firewall to the compressor failed and leaked all the freon from the system. This is a design flaw, the mounting location causes excess vibration in the hose leading to the crimping failure. There are countless forum posts and other complaints filed by owners of the same vehicle for the exact same A/C hose. This should be a recall from Volvo. It is a major safety issue for customers like me who live in a humid environment, without A/C the windshield can fog over and hinder visibility. I contacted Volvo Customer Care for reimbursement and was denied as my car was not under warranty. My car only has 40,000 miles on it and this part shouldnt fail in this manner, especially at my low mileage. I have since purchased their extended warranty as this part will eventually fail again (from the design flaw in A/C system mounting location) and I don't want to pay the large repair costs again. The NHTSA should investigate this with all owners of this year/make/m

The DIM (Driver Instrument Module) flickers intermittently and I have no idea when it's going to go out completely. It actually does go out and there's a solid white panel or colored lines, but it comes back in. This displays the speedometer & fuel. This is a safety issue. I would hate for this to go completely out while I am driving. I do not know the cause for the malfunction. However, per the Volvo tech; they're aware this is a reoccurring issue.

Passenger seat was unbolted from floor during a service appointment and not secured when dealer returned vehicle to me. Passenger safety was at risk due to the seat rocking during acceleration and deceleration and in turns. The issue was confirmed by the dealer and has since been repaired. No warnings issued by vehicle. The dealer error occurred 10/16/24. It was corrected 10/17/24 after vehicle was returned to dealer. This was a result of dealer negligence.

2019 Volvo S60 headlamp system malfunction alert headlights/foglights to blink or turn off when turning the vehicle at night. I keep my headlights on auto so they are on during the day and I have only seen the error at night

Have there been complaints about the Pirelli tires with foam inlays falling apart because the foam comes unattached, then causing misalignment. Car becomes unsafe to drive as the tires start to disintegrate. My car started shaking so bad it became difficult to drive. Turned out foam inlay had become unattached which caused uneven wear and some tire disintegration along with the alignment getting out of whack. Tire size 235/40R19 96V pirelli p-zero - It happened with all four tires. Two in the front were relatively new and had less than 10000 miles on them

The passenger seat belt failed and will not retract. People riding in my car are not safe with the seatbelt hanging loose. I read this was a recall which included 2019 S60s but my specific VIN is not including for some reason.

Since purchase of my vehicle, the vehicle has had a vibration on the highway from 72-83mph with 2 different sets of wheels AND tires, both Pirelli tires but different models. My local Volvo dealer refused to address the issue due to the issue occurring over the speed limit. So they were no help. There are quite a few other 2019 and up Volvo S60 and XC90 owners that experience this same issue. The issue is felt through the bottom of the seats, backrest and steering wheel. You can also visually see the vibration if there is a bottle in the cup holder. The steering wheel "shakes" left to right.

Since purchase of my vehicle, the vehicle has had a vibration on the highway from 72-83mph with 2 different sets of wheels AND tires, both Pirelli tires but different models. My local Volvo dealer refused to address the issue due to the issue occurring over the speed limit. So they were no help. There are quite a few other 2019 and up Volvo S60 and XC90 owners that experience this same issue. The issue is felt through the bottom of the seats, backrest and steering wheel. You can also visually see the vibration if there is a bottle in the cup holder. The steering wheel "shakes" left to right.

Since purchase of my vehicle, the vehicle has had a vibration on the highway from 72-83mph with 2 different sets of wheels AND tires, both Pirelli tires but different models. My local Volvo dealer refused to address the issue due to the issue occurring over the speed limit. So they were no help. There are quite a few other 2019 and up Volvo S60 and XC90 owners that experience this same issue. The issue is felt through the bottom of the seats, backrest and steering wheel. You can also visually see the vibration if there is a bottle in the cup holder. The steering wheel "shakes" left to right.

Sudden, Extreme vibration of front tires on I-95 West Palm Beach FL. Drove immediately to Schumacher Volvo to keep initial service appointment. Service manager advised to replace all 4 tires due to previous experience with OEM Perelli tire failures on Volvo vehicles. Replaced all 4 tires at Costco at $1112+ cost. All photos show failure of foam/padding inside tires by Pirelli P Zero Run Flat. Tire size: 235/40/19 XL

235/40/19 XL RUN FLAT: At 20,750 miles, Sudden Extreme Vibration at Interstate Speed. Confirmed by Schumacher Volvo Service on 28 Oct 2023. Service Writer and Technician advised tire/s failing due to 'foam' separating inside tire. Rotated tires and could not determine which tire. Advised to replace all tires due to experience with same problem on same tires. Recommended purchasing another brand at Costco.

Brake rotors warp prematurely, dealership fighting on covering for warranty. Only 10,000 miles and they're bad again. Second time in 10 months.

After taking vehicle in for a service SRS airbag light and getting it fixed under warranty the same light has come back on.

On December 24, I was about a quarter mile into my drive when the car shut off. The dashboard went blank and I had to coast to a stop. I was unable to restart or use any parts of my car except for the emergency blinker. Nothing alerted me on my dashboard prior to this incident. I could not use the SOS alert button in the car. I had a half tank of gas. I had to wait in the 9 degreeF cold for 2 hours before it could be towed to the service center. My speed was approximately 25MPH on a local road and I don't know what would have happened if this occurred at any higher speed with more traffic. Prior to this on 11/15/22, I had another incident with this car. I could not open the doors with the key FOB and then I could not start the car. A battery jump was attempted by the tow service and it did not work. The car was towed to Hudson Valley Volvo service center where they completed software control module downloading, electrical equipment trouble shooting etc., for 3 days and I was able

On December 24, I was about a quarter mile into my drive when the car shut off. The dashboard went blank and I had to coast to a stop. I was unable to restart or use any parts of my car except for the emergency blinker. Nothing alerted me on my dashboard prior to this incident. I could not use the SOS alert button in the car. I had a half tank of gas. I had to wait in the 9 degreeF cold for 2 hours before it could be towed to the service center. My speed was approximately 25MPH on a local road and I don't know what would have happened if this occurred at any higher speed with more traffic. Prior to this on 11/15/22, I had another incident with this car. I could not open the doors with the key FOB and then I could not start the car. A battery jump was attempted by the tow service and it did not work. The car was towed to Hudson Valley Volvo service center where they completed software control module downloading, electrical equipment trouble shooting etc., for 3 days and I was able

Headlight Failure. Light flickers on and off intermittently and triggers " low beam headlamp malfunction" on dashboard. No vehicle accidents or other trauma to the affected headlight. Only remedy is to replace headlight at a cost of $3,400.

I was driving down our main road and I saw and smelled smoke coming out of the air vents, then a warning light came on my dashboard for my 12V battery I pulled over right away and opened the trunk and saw fire on the left-hand side. I attempted to extinguish the fire myself using soda, I was pulling clothing (2 shirts and napkins) out of the car and burned my hand We towed the car to Volvo and they are claiming it’s not their fault We have only had the car for 4 months And my husband could have died or worse if my child was in the back seat!

The contact owns a 2019 Volvo S60. The contact stated while the vehicle was stopped with the auto brake feature on, the vehicle inadvertently accelerated. The contact pressed on the brakes and continued to his destination. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 20,695.

Mileage: 20,695

I was driving down our main road and I saw and smelled smoke coming out of the air vents, then a warning light came on my dashboard for my 12V battery I pulled over right away and opened the trunk and saw fire on the left-hand side. I attempted to extinguish the fire myself using soda, I was pulling clothing (2 shirts and napkins) out of the car and burned my hand