Total Complaints
9 filings
Volvo S60 · model year
2009 Volvo S60
9 NHTSA complaints, 1 crash report, and 3 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 9
- Recalls
- 3
The verdict
The 2009 Volvo S60 posts top-quartile complaint standing among its own model-year siblings.
- Top 21%
- fewest complaints, own model years
- 3
- recall campaigns
The 2009VolvoS60 carries 9 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 1 crash, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2009 S60 is air bags with 2 filings, followed by fuel system, gasoline (1) and electrical system (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 3 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 28 investigation files overlapping the 2009 S60. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
9
Complaints
1
Crashes
0
Fires
0
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2009 Volvo S60
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
1 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| AIR BAGS | 2 |
| FUEL SYSTEM, GASOLINE | 1 |
| ELECTRICAL SYSTEM | 1 |
| TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS | 1 |
| VEHICLE SPEED CONTROL | 1 |
| STRUCTURE:BODY | 1 |
| UNKNOWN OR OTHER | 1 |
| STEERING | 1 |
Recalls (3)
21V76600030/09/2021
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
10V59100022/11/2010
SEATS
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
10V56600008/11/2010
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Recent Complaints
20260128STEERING
The contact owns a 2009 Volvo S60. The contact stated that while driving at an undisclosed speed, the column turn signal lever detached. The contact stated that the turn signal and headlight switches were inoperable due to the failure. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure, and an appointment was scheduled for a future date. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.
Mileage: 155,000
20230928CrashAIR BAGS
Driving at 25 mph and the airbag spontaneously deployed. Exploded. Dust. Noise. No impact no accident. Hurt my hand. Busted the turn signal arm Caused me to drive over a median and damage the under carriage of the car.
20211218UNKNOWN OR OTHER
I am unable to service my car to fix the recall, because there is no Volvo dealer where I live.
20211218AIR BAGS
I am unable to service my car to fix the recall, because there is no Volvo dealer where I live.
20200421STRUCTURE:BODY
TL* THE CONTACT OWNS A 2009 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR DRIVER'S SIDE DOOR OPENED INDEPENDENTLY ON 10/19. CONSUMER MENTIONED THAT WHEN SHE HITS A BUMP THE DOOR AJAR WARNING LIGHT ILLUMINATED, AT ANY SPEED. CONSUMER ALSO STATED DOOR WOULD NOT OPEN FROM OUTSIDE WHEN UNLOCKED, THIS WOULD HAPPEN ONCE IN AWHILE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.*DT*JB
20170501VEHICLE SPEED CONTROL
ACCELERATING ON INTERSTATE AND ALL OF A SUDDEN COMPLETY LOST ENGINE POWER. ENGINE WOULD CONTINUE RUNNING, BUT WOULD NOT ACCELERATE. COULD HAVE EASILY GOTTEN INTO A WRECK IF THERE HAD BEEN MORE TRAFFIC ON THE INTERSTATE. ENDED UP GETTING TOWED AND HAVING TO REPLACE THE THROTTLE UNIT WHICH COST ALMOST $1000, THIS COULD HAVE BEEN A VERY DANGEROUS SITUATION WITH A VERY BAD OUTCOME IF TRAFFIC HAD BEEN HEAVIER.
Mileage: 126,000
20150409ELECTRICAL SYSTEM
I KEEP GETTING A MESSAGE THAT THE TIRE PRESSURE MONITORING SYSTEM NEEDS SERVICE EVEN THOUGH THE TIRES HAVE THE CORRECT PRESSURE. I BELIEVE THERE IS A DEFECT IN THIS SAFETY RELATED SYSTEM. IT IS AN ISSUE THAT MANY VOLVO OWNERS HAVE REPORTED, YET VOLVO CONTINUALLY FAILS TO ADDRESS THE ISSUE. *TR
Mileage: 87,500
20150409TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
I KEEP GETTING A MESSAGE THAT THE TIRE PRESSURE MONITORING SYSTEM NEEDS SERVICE EVEN THOUGH THE TIRES HAVE THE CORRECT PRESSURE. I BELIEVE THERE IS A DEFECT IN THIS SAFETY RELATED SYSTEM. IT IS AN ISSUE THAT MANY VOLVO OWNERS HAVE REPORTED, YET VOLVO CONTINUALLY FAILS TO ADDRESS THE ISSUE. *TR
Mileage: 87,500
20100520FUEL SYSTEM, GASOLINE
2009 VOLVO S60 AWD - WHEN FILLING WITH GASOLINE AT VARIOUS GAS STATIONS, GASOLINE OVERFLOWS AND SPILLS OUT OF THE FUEL FILLER NECK WHEN THE TANK IS FULL. THIS IS WITH THE LOCK MECHANISM ENGAGED ON THE GAS PUMP HANDLE. I HAVE OBSERVED THIS AT MULTIPLE GAS STATIONS AND DIFFERENT PUMPS AT THOSE GAS STATIONS. I HAVE TAKEN OTHER VEHICLES TO THE SAME STATIONS AND PUMPS AND FILLED THEIR TANKS IN THE SAME FASHION, AND THE LOCK MECHANISM ON THE PUMP HANDLE AUTOMATICALLY DISENGAGES AND NO GAS OVERFLOWS WHEN THE TANK IS FULL AND REACHES CAPACITY. I HAVE ALREADY TAKEN THIS VEHICLE ONCE PREVIOUSLY IN SEPTEMBER 2009 AND THEY FOUND NO ISSUE. I AM TIRED OF DEALING WITH IT AND WORRIED ABOUT A FIRE OCCURRING DUE TO THIS. THE GAS SPILLS OUT AND ON TO THE PAINT ON THAT SIDE OF THE VEHICLE AND ONTO THE GROUND. *TR
Mileage: 8,400
Compare 2009VolvoS60 to Similar Vehicles
NHTSA Investigations
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2009 Volvo S60 have?▼
The 2009 Volvo S60 has 9 NHTSA complaints, 1 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2009 Volvo S60?▼
Yes, the 2009 Volvo S60 has 3 recall(s). The most common affected component is AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2009 Volvo S60?▼
The most-complained component for the 2009 Volvo S60 is AIR BAGS with 2 complaints. Other frequently reported areas include FUEL SYSTEM, GASOLINE and ELECTRICAL SYSTEM.
Is the 2009 Volvo S60 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2009 Volvo S60; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.