2002 VOLVO S60

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE PRESSURE LABEL IS INCORRECT. THESE VEHICLES DID NOT HAVE THE "MAX LOAD VEHICLE CAPACITY WEIGHT" INFORMATION ON THE LABEL.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLIN

VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Island

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.

BOTH FRONT AIRBAGS DEPLOYED ON ITS OWN IN THE GARAGE

Mileage: 120,800

I WAS INVOLVED IN A CAR ACCIDENT IN BRONX, NY ON 8/16/2017 THAT CAUSED SEVERE DAMAGE TO MY 2002 VOLVO S60. THANKFULLY, I WAS THE ONLY ONE IN MY CAR. I HAD JUST LEFT MY LAST DESTINATION, MOVING SLOWLY AND DRIVING STRAIGHT FOR A SHORT BLOCK OR SO, WHEN MY 2002 VOLVO S60, WITH AN ODOMETER READING OF 45,000 MILES, BEGAN TO ACCELERATE OUT OF NOWHERE AND RACE - ALL ON ITS OWN. I TRIED BRAKING (FOOT AND HAND) BUT IT WAS TOO SUDDEN AND NEITHER COULD SLOW IT DOWN. THE CAR ACCELERATED OUT OF MY CON

Mileage: 44,500

NOTICED A BURNING SMELL WHILE DRIVING, AND SMOKE EMANATING FROM LEFT SIDE OF DRIVER'S SEAT. FELT AROUND AND MY HAND WAS BURNED. PULLED OVER TO FIND THAT THE HEATING ELEMENT INSIDE THE SEAT HAD BURNED THROUGH THE CUSHION AND LEATHER LEAVING A HOLE ON THE SIDE OF THE DRIVER'S SEAT. SEARCHING THE INTERNET, THIS APPEARS TO HAVE ALSO HAPPENED TO OTHER DRIVERS. *TR

Mileage: 109,000

THERE WERE FOUR OCCUPANTS IN THE VEHICLE. AS WE WERE DRIVING HOME FROM THE MALL, WE NOTICED A BRIEF INTERRUPTION IN THE LIGHTS AND RADIO. A FEW MILES DOWN THE ROAD, THERE WAS AN ELECTRICAL FAILURE AND THE CAR SHUT OFF IN THE MIDDLE OF THE ROAD, BUT WE WERE ABLE TO GET IT CRANKED BACK UP IN LESS THAN A MINUTE. WE DROVE APPROXIMATELY TWO MORE MILES AND PULLED INTO OUR DRIVEWAY AND SHUT THE CAR OFF. WE HEARD A SOUND LIKE AN ALARM, BUT IT WAS SO FAINT; BEFORE WE HAD TIME TO THINK ABOUT IT FURTHE

Mileage: 133,000

THERE WERE FOUR OCCUPANTS IN THE VEHICLE. AS WE WERE DRIVING HOME FROM THE MALL, WE NOTICED A BRIEF INTERRUPTION IN THE LIGHTS AND RADIO. A FEW MILES DOWN THE ROAD, THERE WAS AN ELECTRICAL FAILURE AND THE CAR SHUT OFF IN THE MIDDLE OF THE ROAD, BUT WE WERE ABLE TO GET IT CRANKED BACK UP IN LESS THAN A MINUTE. WE DROVE APPROXIMATELY TWO MORE MILES AND PULLED INTO OUR DRIVEWAY AND SHUT THE CAR OFF. WE HEARD A SOUND LIKE AN ALARM, BUT IT WAS SO FAINT; BEFORE WE HAD TIME TO THINK ABOUT IT FURTHE

Mileage: 133,000

TL* THE CONTACT OWNS A 2002 VOLVO S60 2.4. THE CONTACT WAS DRIVING 70 MPH WHEN A LOUD EXPLOSION EMITTED FROM UNDER THE HOOD AND SMOKE ENTERED THE INTERIOR. THE VEHICLE THEN STALLED AND WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT OIL WAS NOT FLOWING INTO THE ENGINE AND THE BEARINGS WERE MELTED. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 49,000.

Mileage: 49,000

TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT WAS DRIVING 10 MPH WHEN ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE OF THE VEHICLE WHICH CAUSED THE CONTACT TO STRIKE HER HEAD ON THE WINDOW AND SUFFER INJURIES. THE FRONT AND SIDE AIR BAGS DID NOT DEPLOY AND THE VEHICLE WAS DESTROYED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE NON-DEPLOYMENT OF THE AIR BAGS AND THE MANUFACTURER STATED THAT THEY WOULD SEND AN INVESTIGATOR TO EXAMINE WHY THE AIR BAGS DID NOT DEPLOY. SHE STATED THAT IF

Mileage: 148,000

I PRESENTLY OWN A 2002 VOLVO S60 SEDAN. ON OCTOBER 14TH, 2009, AT APPROX. 5:30 AM, THE FRONT DRIVERS SIDE BALL JOINT SEPARATED FROM MY VEHICLE, CAUSING FAILURE OF MY UPPER BALL JOINT, THEN SEPARATING MY CV JOINT AND SHAFT FROM MY TRANSMISSION. THIS IN TURN, CAUSED EXTENSIVE BODY DAMAGE TO MY VEHICLE. I THANK GOD, THAT I WAS ONLY TRAVELING 20 MILES PER HOUR. IF I WAS ON THE HIGHWAY, I WOULD NOT BE WRITING THIS TODAY. I NOTIFIED DALZELL VOLVO IN DEDHAM, MASS. AND ALSO FILED A CLAIM WITH VOLVO OF N

Mileage: 89,000

I HAVE A VOLVO S60 2002 AND IN OCTOBER IN A CHEKPOINT THE BORDER PATROL AGENT NOTICED AN ODOR OF FUEL AND A LEAK HE WAS SOME WHAT ALARMED AND SO I WAS INSPECTED AND SO ON I STARTED TO RESEARCH FOR THIS PROBLEM AND FOUND THAT MY CAR HAD A RECALL ON THE FUEL PUMP NHTSA CAMPAIGN 07V152000 THAT MATCHED ALL THE SY MPTOMS AND SO I CALL TO VOLVO AND THEY SAID THAT I DON'T HAVE A RECALL BUT AN EXTENDED WARRANTY ON THE FUEL PUMP, AND SO I WENT TO THE DEALER LEFT THE CAR PICKED IT UP AND NOW MY CAR NOT ON

Mileage: 70,000

I HAVE A 2002 VOLVO S 60 AWD WITH THE OPTIONAL 17" X 7.5" "THOR" WHEELS AND PIRELLI TIRES. I HAVE BEEN THROUGH 3 SETS OF PIRELLI TIRES IN LESS THAN 20,000 MILES. PIRELLI IS NOT INTERESTED IN THIS ISSUE AS REPEATED ATTEMPTS TO CONTACT THEM HAVE PROVEN UNSUCCESSFUL. DUE TO THE ONGOING PROBLEMS I AM HAVING WITH MY VEHICLE'S TIRES, I HAVE BEEN RESEARCHING THE PIRELLI TIRES COMBINED WITH THE VOLVO S 60 AWD AND HAVE FOUND MANY ALARMING STORIES REGARDING SAFETY CONCERNS WITH MY VEHICLE COMBINED WITH

Mileage: 10,000