2004 NISSAN 350Z

POWER TRAIN:CLUTCH ASSEMBLY

ZF SERVICE IS RECALL CERTAIN CLUTCH KIT ASSEMBLIES, PART NUMBER SX: K70358-01, SHIPPED TO WHOLESALERS AS SERVICE PARTS BETWEEN SEPTEMBER 1, 2010, AND MARCH 8, 2011. THESE SERVICE PARTS ARE INTENDED FOR USE ON MODEL YEAR 2003-2006 NISSAN 350Z AND INFINITI G35 VEHICLES. THE SX: K70358-01 CLUTCH KIT

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.

FUEL SYSTEM, GASOLINE

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FUEL FILLER HOSE MAY CRACK AND RESULT IN FUEL LEAKAGE FROM THE HOSE WHILE REFUELING.

My 350Z was overheating so I took it to Sun Devil Auto in Sun City West. Sam Malone inspected it. He said I needed a new radiator, hoses, gaskets for a price of $1400.00+ .I went to the Firestone dealer in Surprise on Meeker, he told me to go put antifreeze in and check ot out. I did and no overheating now? Mr. Malone lied to me and I want him fired.

The contact owns a 2004 Nissan 350Z. The contact stated while refueling the vehicle, after stepping away from the vehicle, the contact was alerted by his passenger that there was a fuel leak underneath the vehicle. The contact stated that the passenger was alerted by the odor of gasoline. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel pump filler neck needed to be replaced. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 131,000.

Mileage: 131,000

The airbag light came on for no reason, has never come on before. No accidents, fender bender, no bumps. Shop read an error code of B1129. Checked right passenger SRS seat connections as code suggests and reset the light. Light came back on in two days. Shop says airbag may not deploy and can not determine the exact cause. could easily cost over a $1000 to fix depending on issue. Airbags should not have issues like this. Nissan already has a service campaign for the same issue on later model 350Z. Please encourage Nissan to include the 2004 model as well. From all my research into resolving this issue, I can see there are a lot of other 350Z owners affected as well. Please help us. Thank you, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact's girlfriend owns a 2004 Nissan 350Z. The contact stated that upon refueling the gas tank, a large amount of gasoline began to leak out from the gas tank and underneath the vehicle. The contact also stated that upon entering the vehicle, a strong fuel odor began to emit from the vehicle. Due to the failure, the contact had the vehicle towed to his home. The contact called the dealer and they informed him that there were no recalls on the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 05V555000 (Fuel System, Gasoline) which he linked to the failure. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 115,000.

Mileage: 115,000

I PURCHASED 4 NEW TIRES FOR MY 2004 NISSAN 350Z, THEY ARE THE FALKEN PRO G5 SPORT A/S TIRES P225/45R18 ON THE FRONT. 245/45/R18 ON THE REAR ON 2/06/19 THE MILEAGE IN WAS 16,292. ON 1/15/20 I TOOK THE CAR OUT AND THE CAR WAS BOUNCING ALL OVER THE ROAD, I TOOK IT BACK TO DISCOUNT TIRES IN LAS VEGAS NEVADA ON THAT SAME DAY AND THEY SAID IT WAS THE BALANCE OF THE TIRES. WHEN THE TECHNICIAN TRIED TO BALANCE THE TIRES HE SAID THEY ARE OFF BY OVER 1 OUNCE. ANOTHER TECH CAME AND TRIED TO BALANCE THE TIRES AND FOUND A BULGE ON ALL 4 TIRES AND OPTED TO REPLACE THEM ALL,I ONLY HAD 69 MILES ON THE TIRES! I HAVE TO SAY IN ALL MY YEARS I HAVE NEVER SEEN TIRES DEVELOP BULGES LIKE THESE AND ALL 4 NEEDING REPLACEMENT WITH ONLY 69 MILES ON THEM! I AM VERY NERVOUS WITH THESE TIRES BEING THAT THEY ARE INSTALLED ON A NISSAN 350Z WITH THE POWER THE VEHICLE HAS.

Mileage: 16,361

HELLO, I WAS LEAVING A STOP SIGN BARELY MOVING AND ALL OF A SUDDEN IT SOUNDED LIKE A GUN GOING OFF IN MY CAR. BEFORE I COULD GRASP MY NEXT THOUGHT MY CAR FLIPPED COMPLETELY OVER ON ITS SIDE NO TIRES TOUCHING THE GROUND! I HAD TO CRAWL OUT PASSENGER WINDOW . UPON INSPECTION OF VEHICLE THIS IS WHAT WAS FOUND.

Mileage: 155

HELLO, I WAS LEAVING A STOP SIGN BARELY MOVING AND ALL OF A SUDDEN IT SOUNDED LIKE A GUN GOING OFF IN MY CAR. BEFORE I COULD GRASP MY NEXT THOUGHT MY CAR FLIPPED COMPLETELY OVER ON ITS SIDE NO TIRES TOUCHING THE GROUND! I HAD TO CRAWL OUT PASSENGER WINDOW . UPON INSPECTION OF VEHICLE THIS IS WHAT WAS FOUND.

Mileage: 155

HELLO, I WAS LEAVING A STOP SIGN BARELY MOVING AND ALL OF A SUDDEN IT SOUNDED LIKE A GUN GOING OFF IN MY CAR. BEFORE I COULD GRASP MY NEXT THOUGHT MY CAR FLIPPED COMPLETELY OVER ON ITS SIDE NO TIRES TOUCHING THE GROUND! I HAD TO CRAWL OUT PASSENGER WINDOW . UPON INSPECTION OF VEHICLE THIS IS WHAT WAS FOUND.

Mileage: 155

I BOUGHT A 2004 Z350 AND I BOUGHT IT ON MOTHER'S DAY LAST MONTH AND I GOT THE CAR IN THE ABARAT WAS ALREADY ON THE CAR THE LIGHT WAS ALREADY ON WHEN I PURCHASED A CAR FROM A DEALERSHIP AND I WAS TOLD THAT IT WAS AGAINST THE LAW TO SELL A CAR WITH THE AIRBAG LIGHT ON.

Mileage: 135,000

MY CAR LIGHT JUST CAME ON. I NEVER HAD AN ACCIDENT WITH MY CAR SINCE I PURCHASED IT FROM PALM SPRINGS NISSAN. IN 2004

Mileage: 16,700

350Z RECALL. 2004 350Z . ORIGINAL OWNER OF CAR. A COUPLE WEEKS AGO, WHILE DRIVING CAR HESITATED, THEN RESUMED BUT CHECK ENGINE LIGHT TCS OFF LIGHT AND SLIP LIGHTS ON, AND REMAINED ON. THIS WEEK WHILE DRIVING 40MPH WITHOUT WARNING THE CAR HESITATED BUT ACTUALLY STALLED. I WAS ABLE TO SOMEWHAT SAFELY PULL TO RIGHT SIDE OF ROAD. AFTER 15 MINUTES OF MAKING SEVERAL PHONECALLS THE CAR JUST STARTED AS IF NOTHING WAS WRONG AND I DROVE IT HOME. TODAY IT STARTED FINE. WHILE ENROUTE TO NISSAN DEALERSHIP SERVICE GARAGE 1 MILE TO GO WHEN AT 70MPH STALLS WHILE IN NEARING FIVE OCLOCK TRAFFIC. THANKFULLY ABLE TO SOMEWHAT SAFELY GET OUT OF DRIVING LANE ONTO SHOULDER WITH STEERING WHEEL AND BRAKE PEDAL INCREASINGLY BECOMING HARDER TO OPERATE, PUT ON FLASHERS AND WAITED. I WAS ABLE TO START AFTER 15 MINUTES WITHOUT ANY ACCIDENTS AND SHAKILY TOOK TO DEALERSHIP.

Mileage: 153,000

SERVICE ENGINE WARNING LIGHT IS ON. CAR TURNS OF WITHOUT WARNING WHILE OPERATING. CAM SHAFT SENSOR WARNING. CAR IS CURRENTLY PARKED OUTSIDE HOME.

Mileage: 117,000

AIRBAG WARNING LIGHT ILLUMINATED ON DASH ON 2004 350Z NISSAN. THIS VEHICLE IS NOT LISTED FOR NISSAN AIRBAG RECALL. WITHIN WARRANTY PERIOD THE AIRBAG WAS PREVIOUSLY REPLACED BY PLANET NISSAN (DEALER LAS VEGAS, NV) IN 2004 OR 2005, NOT SURE OF SPECIFIC DATE. DEALERSHIP SAID IT WASN'T COVERED UNDER WARRANTY BUT THEY WOULD TAKE CARE OF IT.

Mileage: 16,500

HAPPENED IN THE DRIVEWAY, FORTUNATELY. WHEN THE CLUTCH PEDAL WAS DEPRESSED, IT STAYED DOWN, AND IN GEAR. IT WAS DIFFICULT TO FORCE THE CAR OUT OF GEAR. I WAS THEN ABLE TO MANUALLY LIFT THE PEDAL, AND PUMP IT SOFTLY TO MAKE IT STAY UP. THIS HAS NOT HAPPENED SINCE. IT IS A HYDRAULIC CLUTCH' NO LEAKS, AND CLUTCH REPLACED 2 YEARS AGO. THE CAR HAS BEEN WELL MAINTAINED WITH ONLY 55K MILES ON IT. LOOKING ON THE INTERNET I SEE THIS IS A COMMON PROBLEM, AND VERY UNSAFE IF YOU ARE DRIVING AND CAN'T GET IT OUT OF GEAR.

Mileage: 54,000

I HAVE HAD A PROBLEM WITH THE NEUTRAL SAFETY SWITCH CAUSING THE CAR TO PERIODICALLY NOT START. A MECHANIC MADE A PREVIOUS DIAGNOSIS BUT SAID THERE WERE NO SAFETY CONCERNS. THE CAR EVENTUALLY WOULD START ALL, REQUIRING DOWNTIME FOR REPAIR. SOMETIMES AFTER SITTING OVER NIGHT AND SOMETIMES AFTER SEVERAL ERRANDS THE CAR WON'T START BUT NEVER THIS SUDDEN STALL. TODAY, THE CAR STALLED WHILE I WAS IN THE MIDDLE OF SLOWING DOWN TO MAKE A LEFT HAND TURN. IT WAS A TWO LANE MOUNTAIN ROAD. CARS WERE ABLE TO GET AROUND ME WITHOUT INCIDENT AND I WAS ABLE TO COAST BACKWARDS TO A PLACE OF SAFETY. I LET THE CAR SIT FOR ABOUT 10 MIN. WHICH IS MY USUALLY WHAT I DO WHEN IT WON'T START. PUT IT IN NEUTRAL AFTER RELEASING THE LOCKED GEAR SHIFT, WITH FOOT ON THE BREAK, STARTED THE CAR. I AM THANKFUL THAT I HADN'T YET MERGED ONTO THE FREEWAY. *TR

Mileage: 135,000

TL* THE CONTACT OWNS A 2004 NISSAN 350Z. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER RESET THE AIR BAG SENSOR, BUT THE FAILURE RECURRED. THE VEHICLE WAS BROUGHT BACK TO THE DEALER WHO STATED THAT BOTH THE DRIVER AND PASSENGER SIDE AIR BAG MODULES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 111,000. JCC

Mileage: 111,000

ON 2004 NISSAN 350Z THE CONVERTIBLE TOP WILL STICK IN THE HALF OPEN HALF CLOSED POSITION. NISSAN WILL NOT HELP FIX THIS COSTLY REPAIR $2200-$3000. THE MOTORS THAT CONTROL THE TOP CALLED THE (FIFTH BOW MOTOR) WILL GO OUT WITHOUT NOTICE. NO WAY TO MANUALLY CLOSE THE TOP. MANY OTHERS ON NISSAN FORUM SITE HAVE REPORTED THIS SAME ISSUE. I PAID NISSAN TO FIX THIS PROBLEM COST ME $2800.00. NOW IT IS DOING THE SAME THING LESS THAN 3 YEARS LATER. (I CAN SUPPLY THE PART NUMBER IS NEEDED). *TR

Mileage: 85,000

AIR BAG FAULT LIGHT FOR PASSENGER SEAT STAYED ON. INVESTIGATION BY NISSAN DETERMINED IT TO BE A FAULTY SENSOR. ANOTHER INCIDENT OCCURRED ON 3/05/14, WITH SAME PROBLEM. APPEARS TO BE THE SAME PROBLEM AS RECALL OF 2013-2014 NISSANS. I THINK RECALL SHOULD BE EXTENDED TO INCLUDE MY 2004 Z350. *TR

Mileage: 28,517

MY DAUGHTER WAS DRIVING IN ORLANDO WHEN HER CHECK ENGINE LIGHT AND THE SLIP CONTROL LIGHT CAME ON AND THE ENGINE LOST POWER AND STALLED. WE HAD TO HAVE THE VEHICLE TOWED TO AN ORLANDO NISSAN DEALER. THEY DIAGNOSED IT AS THE CAMSHAFT AND CRANKSHAFT SENSORS AND WE HAD TO HAVE IT FIXED AT A COST OF $815.65. I RECENTLY CONTACTED NISSAN ABOUT THIS AS I SAW THERE WAS A NISSAN RECALL (NO. R2022) ON THE CAMSHAFT AND CRANKSHAFT SENSORS. HOWEVER, NISSAN INFORMED ME THAT MY CAR WAS NOT INCLUDED IN THE RECALL AS THE RECALL WAS FOR 2003 VEHICLES. THEY STATED THE RECALL WAS VIN SPECIFIC. I BELIEVE IT SHOULD BE SYMPTOM SPECIFIC AS THE SYMPTOMS OF THE VEHICLE IN THIS INCIDENT WERE EXACTLY THE SAME AS WHAT WAS DESCRIBED IN THE RECALL. *TR

Mileage: 120,000

MY DAUGHTER WAS DRIVING IN ORLANDO WHEN HER CHECK ENGINE LIGHT AND THE SLIP CONTROL LIGHT CAME ON AND THE ENGINE LOST POWER AND STALLED. WE HAD TO HAVE THE VEHICLE TOWED TO AN ORLANDO NISSAN DEALER. THEY DIAGNOSED IT AS THE CAMSHAFT AND CRANKSHAFT SENSORS AND WE HAD TO HAVE IT FIXED AT A COST OF $815.65. I RECENTLY CONTACTED NISSAN ABOUT THIS AS I SAW THERE WAS A NISSAN RECALL (NO. R2022) ON THE CAMSHAFT AND CRANKSHAFT SENSORS. HOWEVER, NISSAN INFORMED ME THAT MY CAR WAS NOT INCLUDED IN THE RECALL AS THE RECALL WAS FOR 2003 VEHICLES. THEY STATED THE RECALL WAS VIN SPECIFIC. I BELIEVE IT SHOULD BE SYMPTOM SPECIFIC AS THE SYMPTOMS OF THE VEHICLE IN THIS INCIDENT WERE EXACTLY THE SAME AS WHAT WAS DESCRIBED IN THE RECALL. *TR

Mileage: 120,000