2003 VOLKSWAGEN PASSAT

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

FUEL SYSTEM, GASOLINE:DELIVERY

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/s

The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and informed the contact that the parts needed for the repair could not be found. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 07V375000 (Fuel System, Gasoline); however, the VIN was included but the vehicle was not repaired. The failure mileage was approximately 133,000.

Mileage: 133,000

The contact owns a 2003 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 06V017000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2003 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, coolant leaked onto the front passenger’s side floorboard. The contact stated that the coolant leak was underneath the glove compartment area. The vehicle was taken to an independent mechanic, and the contact was advised to have the vehicle taken to the Volkswagen dealer. The contact visited the dealer and discussed the reoccurring failure and was informed that the heater coil was designed incorrectly, and the failure was due to the design of the heater coil. The contact was informed that the heater coil needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 72,000.

Mileage: 72,000

Vehicle has major fuel pump issue, currently at 132,000 and noticing loss of power, car shaking, and occasional stall. A code reader is unable able to detect the issue which is a major concern. I have contacted the volkswagen Manufacturer and I consistently keep getting ignored after bringing up the recall that was put out for the fuel pump. While driving on the highway my rear and front suspension failed and dropped suddenly while moving slowly during traffic. I whave only been able to repair the front shocks and struts so far, but the rear are needed as well. I would like to state that all the parts are original manufacturer parts.

Vehicle has major fuel pump issue, currently at 132,000 and noticing loss of power, car shaking, and occasional stall. A code reader is unable able to detect the issue which is a major concern. I have contacted the volkswagen Manufacturer and I consistently keep getting ignored after bringing up the recall that was put out for the fuel pump. While driving on the highway my rear and front suspension failed and dropped suddenly while moving slowly during traffic. I whave only been able to repair the front shocks and struts so far, but the rear are needed as well. I would like to state that all the parts are original manufacturer parts.

The contact owns a 2003 Volkswagen Passat. The contact stated that while driving approximately 35 mph the vehicle's speed suddenly begin to reduce and smoke was present coming from the engine compartment. After stopping and exiting the vehicle became engulfed in flames. The fire department was called to the scene and extinguished the flames and the vehicle was towed away. During the incident, the vehicle was destroyed. The local dealer and manufacturer were notified of the incident but no assistance was offered. The failure mileage was 150,000.

Mileage: 150,000

I PURCHASED A USED 2003 VW PASSAT FROM A PRIVATE DEALER DROVE THE CAR FIVE MONTHS AND THE TIMING BELT CAME OFF WHILE I WAS DRIVING. I ALMOST GOT INTO AN ACCIDENT BUT AVOIDED IT. THIS PARTICULAR VEHICLE AND ONES LIKE IT WAS RECALLED IN 3/7/2014 FOR ENGINE AND ENGINE COOLING ENGINE PROBLEMS THAT CAUSES THE TIMING BELT TO COME OFF WHILE DRIVING. RECALL: 14E007000 BECAUSE OF THE TIMING BELT FAILURE. I CONTACTED A VW DEALERSHIP AND THEY SAID THE RECALL DIDN'T APPLY TO MY CAR. I FIND THAT INSULTING CONSIDER ING WHAT I JUST EXPERIENCED.

Mileage: 180,000

I PURCHASED A USED 2003 VW PASSAT FROM A PRIVATE DEALER DROVE THE CAR FIVE MONTHS AND THE TIMING BELT CAME OFF WHILE I WAS DRIVING. I ALMOST GOT INTO AN ACCIDENT BUT AVOIDED IT. THIS PARTICULAR VEHICLE AND ONES LIKE IT WAS RECALLED IN 3/7/2014 FOR ENGINE AND ENGINE COOLING ENGINE PROBLEMS THAT CAUSES THE TIMING BELT TO COME OFF WHILE DRIVING. RECALL: 14E007000 BECAUSE OF THE TIMING BELT FAILURE. I CONTACTED A VW DEALERSHIP AND THEY SAID THE RECALL DIDN'T APPLY TO MY CAR. I FIND THAT INSULTING CONSIDER ING WHAT I JUST EXPERIENCED.

Mileage: 180,000

I PURCHASED A USED 2003 VW PASSAT FROM A PRIVATE DEALER DROVE THE CAR FIVE MONTHS AND THE TIMING BELT CAME OFF WHILE I WAS DRIVING. I ALMOST GOT INTO AN ACCIDENT BUT AVOIDED IT. THIS PARTICULAR VEHICLE AND ONES LIKE IT WAS RECALLED IN 3/7/2014 FOR ENGINE AND ENGINE COOLING ENGINE PROBLEMS THAT CAUSES THE TIMING BELT TO COME OFF WHILE DRIVING. RECALL: 14E007000 BECAUSE OF THE TIMING BELT FAILURE. I CONTACTED A VW DEALERSHIP AND THEY SAID THE RECALL DIDN'T APPLY TO MY CAR. I FIND THAT INSULTING CONSIDER ING WHAT I JUST EXPERIENCED.

Mileage: 180,000

RECALL 26E5 VOLKSWAGEN NOT COMPLETED

MY SON WAS DRIVING (IN MOTION) ON HWY 17 IN MILLER COUNTY MO WITH SEAT HEATER ON SATURDAY NOV. 28, 2020. SEAT CAUGHT ON FIRE. I HAD NOTICED WHEN I HAD SEAT HEATER ON PREVIOUSLY IT BECAME SO HOT AS TO BURN LEGS. THIS IS A SERIOUS PROBLEM. IT COULD HAVE BURNED MY CAR COMPLETELY. VERY DANGEROUS.

Mileage: 121,365

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE THE VEHICLE WAS AT A STAND STILL, THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TIMING CHAIN ACTUATOR/SOLENOID NEEDED TO BE REPLACED. THE CONTACT STATED A LOCAL DEALER WAS CONTACTED ABOUT OPEN RECALLS AND STATED THAT THERE WAS NO RECALL ON VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.

Mileage: 180,000

FUEL TANK LEAKING WHEN FULL ON DRIVERS SIDE DIRECTLY UNDER REAR PASSENGER SEAT. WHICH HAPPENS TO BE WHERE MY CHILDREN SIT. IT LEAKS UNTIL IT'S A LITTLE OVER HALF FULL THEN STOPS.

Mileage: 140,000

THIS CAR ONLY HAS 65000 ORIGINAL ONE OWNER MILES AND HAS EXPERIENCED ALL & MORE OF THE CURRENT RECALLS WITH SAME MODEL YR, VW LOCAL DEALERSHIPS (2) REFUSE TO ACKNOWLEDGE THE PROBLEMS (ONE EVEN TRIED TO DOUBLE CHARGE ME FOR BOSCH ABS PART LAST YEAR BEFORE THE RECALL TO FIX) AND NUMEROUS EMAILS TO VW HAVE GONE UNANSWERED. MOST RECENT ISSUES IN LAST 1.5YRS HAVE BEEN FUEL PUMP WENT OUT AND I PAID TO REPLACE (DEALER SCAMMED US BY THROWING OUT DEAD BRAND NEW AAA STAMPED AND WARRANTED BATTERY, THEY SD WE NEEDED NEW ONE AND OLD ONE ALREADY PICKED UP FROM DEALER TO EXPOSE OF, CHARGED $200 FOR THAT AS WELL. I PAID FOR THE ABS LIGHT REPAIR WHICH I HAVE PAID AND DIAGNOSED NUMEROUS TIMES FOR LAST 10YRS TO FIX AND FINALLY JUST PAID THE OVER $1000. TO GET IT FIXED FOR SAFETY REASONS. 9 MONTHS AGO REAR BRAKE LIGHTS WOULD COME ON RANDOMLY WHEN PARKED AND LOCKED KILLING THE BATTERY. I WOULD DRIVE IT TO CHARGE IT UP BUT SINCE IT IS A CAR WE DON'T DRIVE OFTEN OR FAR, IT CONTINUED TO DO THE SAME FOR A FEW

Mileage: 57,665

THIS CAR ONLY HAS 65000 ORIGINAL ONE OWNER MILES AND HAS EXPERIENCED ALL & MORE OF THE CURRENT RECALLS WITH SAME MODEL YR, VW LOCAL DEALERSHIPS (2) REFUSE TO ACKNOWLEDGE THE PROBLEMS (ONE EVEN TRIED TO DOUBLE CHARGE ME FOR BOSCH ABS PART LAST YEAR BEFORE THE RECALL TO FIX) AND NUMEROUS EMAILS TO VW HAVE GONE UNANSWERED. MOST RECENT ISSUES IN LAST 1.5YRS HAVE BEEN FUEL PUMP WENT OUT AND I PAID TO REPLACE (DEALER SCAMMED US BY THROWING OUT DEAD BRAND NEW AAA STAMPED AND WARRANTED BATTERY, THEY SD WE NEEDED NEW ONE AND OLD ONE ALREADY PICKED UP FROM DEALER TO EXPOSE OF, CHARGED $200 FOR THAT AS WELL. I PAID FOR THE ABS LIGHT REPAIR WHICH I HAVE PAID AND DIAGNOSED NUMEROUS TIMES FOR LAST 10YRS TO FIX AND FINALLY JUST PAID THE OVER $1000. TO GET IT FIXED FOR SAFETY REASONS. 9 MONTHS AGO REAR BRAKE LIGHTS WOULD COME ON RANDOMLY WHEN PARKED AND LOCKED KILLING THE BATTERY. I WOULD DRIVE IT TO CHARGE IT UP BUT SINCE IT IS A CAR WE DON'T DRIVE OFTEN OR FAR, IT CONTINUED TO DO THE SAME FOR A FEW

Mileage: 57,665

THIS CAR ONLY HAS 65000 ORIGINAL ONE OWNER MILES AND HAS EXPERIENCED ALL & MORE OF THE CURRENT RECALLS WITH SAME MODEL YR, VW LOCAL DEALERSHIPS (2) REFUSE TO ACKNOWLEDGE THE PROBLEMS (ONE EVEN TRIED TO DOUBLE CHARGE ME FOR BOSCH ABS PART LAST YEAR BEFORE THE RECALL TO FIX) AND NUMEROUS EMAILS TO VW HAVE GONE UNANSWERED. MOST RECENT ISSUES IN LAST 1.5YRS HAVE BEEN FUEL PUMP WENT OUT AND I PAID TO REPLACE (DEALER SCAMMED US BY THROWING OUT DEAD BRAND NEW AAA STAMPED AND WARRANTED BATTERY, THEY SD WE NEEDED NEW ONE AND OLD ONE ALREADY PICKED UP FROM DEALER TO EXPOSE OF, CHARGED $200 FOR THAT AS WELL. I PAID FOR THE ABS LIGHT REPAIR WHICH I HAVE PAID AND DIAGNOSED NUMEROUS TIMES FOR LAST 10YRS TO FIX AND FINALLY JUST PAID THE OVER $1000. TO GET IT FIXED FOR SAFETY REASONS. 9 MONTHS AGO REAR BRAKE LIGHTS WOULD COME ON RANDOMLY WHEN PARKED AND LOCKED KILLING THE BATTERY. I WOULD DRIVE IT TO CHARGE IT UP BUT SINCE IT IS A CAR WE DON'T DRIVE OFTEN OR FAR, IT CONTINUED TO DO THE SAME FOR A FEW

Mileage: 57,665

I NOTICED A STAIN UNDER MY CAR WHILE IT WAS PARKED IN THE STREET. I FIGURED OUT THAT VW HAD A RECALL ON THE FUEL TANK VENT WHICH REQUIRED REPLACING THE WHOLE FUEL TANK. THE TANK RUNS ABOUT $922 AND IT TAKES UP TO 11 HOURS LABOR TIME. I STARTED A CHAT WITH A VWOA REP TO LOOK INTO THIS ISSUE. SHE SAID THERE ARE NO CURRENT RECALLS OR CAMPAIGNS ON MY VEHICLE AT THIS TIME. SHE ALSO STATED THAT MY CAR'S 26E5/R5 RECALL, IT COVERS ALL 1999-2005 PASSAT AND PASSAT WAGON (5TH GEN) EQUIPPED WITH GAS ENGINES. INSTALL UNDERBODY HEAT SHIELD(S): INSPECT/REPLACE FUEL LINE, FUEL TANK: UPDATE SOFTWARE, IF NECESSARY, HAD BEEN PERFORMED ON 03/12/09 BUT HAS NO SERVICE RECORD TO TELL ME WHAT WAS DONE. IT MAY NOT HAVE ACTUALLY BEEN REPLACED. SHE ALSO SAID VWOA WILL NOT FIX NOR HELP ME FIX IT. I FEEL THAT IF A RECALL FOR AS HUGE SAFETY ISSUE THAT THIS IS, SHOULD NOT FAIL IN THE SAME MANOR AS THE ORIGINAL PART DID. THAT TELLS ME THEY JUST REPLACED IT WITH THE SAME PROBLEM PART IN HOPES THAT THE CAR WOULDN'T BE

Mileage: 124,084

05/01/2019 CAR HAD A DEAD BATTERY---CHARGE OVER NIGHT STILL WOULD NOT START---HAD THE CAR TOWED TO AUTO SHOP--UPON ARRIVAL WITH KEY ON APPROX. 15 MIN DRIVE--SMOKE STARTED BILLOWING---DISCONNECTED BATTERY---DRIVERS SIDE SEAT WARMER COMPLETELY MELTED--MECHANIC SAYS UNIT PULLING 30 AMPS--THERE WAS A PREVIOUS RECALL--NOT SURE IF TOTALLY CORRECTED--DONOT WANT TO REPLACE IMMEDIATELY--PLEASE ADVISE

Mileage: 56,000

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT HOLD FUEL AND THE TANK HAD TO CONSTANTLY BE REFILLED. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ELLIS MOTORCARS INC (2235 E SOUTH BLVD, MONTGOMERY, AL 36116, (334) 280-1021) WHERE IT WAS DIAGNOSED THAT THE COOLANT SYSTEM AND THE TIMING CHAIN NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT HOLD FUEL AND THE TANK HAD TO CONSTANTLY BE REFILLED. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ELLIS MOTORCARS INC (2235 E SOUTH BLVD, MONTGOMERY, AL 36116, (334) 280-1021) WHERE IT WAS DIAGNOSED THAT THE COOLANT SYSTEM AND THE TIMING CHAIN NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000