2001 VOLKSWAGEN EUROVAN

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

ON CERTAIN MINIVANS EQUIPPED WITH CHILD RESTRAINT ANCHORAGES (TETHER ANCHORAGES) FOR USE IN CONJUNCTION WITH CHILD RESTRAINTS INSTALLED IN THE THREE REARMOST SEATING POSITIONS, THE "SAFETY FIRST" PORTION OF THE OWNER'S MANUAL DELIVERED WITH THESE VEHICLES INCORRECTLY INSTRUCTS OWNERS TO GUIDE THE TE

RELIABLE INTERNET AUTOMOTIVE SOURCES HAVE LISTED EXCESSIVE WEAR OF THE INTERMEDIATE (BALANCE SHAFT) VALVE TIMING CHAIN SPROCKET IN EARLY 2001 24-VALVE VR6 ENGINES. THE INADEQUATELY HARDENED SPROCKET TEETH WILL VEER EXCESSIVELY, SUCH THAT CHAIN "JUMPEDS" A TOOTH AND SINCE THE VR6 IS AN "INTERFERENCE" VALVE-TRAIN ENGINE, THE ENGINE WILL ESSENTIALLY BE IRREPARABLY DAMAGED. *TR

Mileage: 141,000

DRIVER SEAT HEATER CAUGHT FIRE AND MELTED HOLE IN SEAT. THIS IS A VERY DANGEROUS AND SHOULD BE A RECALL ITEM. *TR

Mileage: 147,000

ENGINE COOLING FAN BLADE FAILURE. THE LARGER OF THE 2 FAN BLADE WHEELS HAS A LARGE MISSING PIECE WHICH HAS SOMEHOW DISINTEGRATED WITHOUT ANY REASONABLE EXPLANATION. I UNDERSTAND THERE WAS AN INVESTIGATION OF THE EUROVAN ENGINE COOLING FAN BLADE, HOWEVER A RECALL HAS NOT BEEN ISSUED, WHILE THERE WAS A RECALL ON THE RIALTA, WHICH USES THE SAME FAN AS THE EUROVAN. *TR

Mileage: 103,550

TRAVELING WITH TWO OTHER RIALTA MOTOR HOMES VISITING JOSHIA TREE NP WHEN I HEARD A BANGING SOUND LIKE SOMETHING HITTING UNDER MY RIALTA. I IMMEDIATELY NOTED AN INCREASE IN WATER TEMPERATURE AND THEN THE RED WARNING LIGHT CAME ON THE DASH. I PULLED TO THE SIDE OF THE ROAD, OPENED THE HOOD, BUT COULD NOT SEE A BUSTED HOSE, BUT THERE WAS ANTIFREEZE ON THE GROUND. I HAD A SPARE GALLON WITH ME AND FILLED THE RESERVOIR TO RECOMMENDED LEVEL, DROVE ABOUT 3-4 MILES AND HAD TO REPEAT PROCEDURE. AGAIN I WENT ABOUT 3-4 MILES AND HAD TO USE WATER THIS TIME. A PARK RANGER GAVE ME THE NAME OF A REPAIR SHOP IN TWENTYNINE, PALMS WHICH WAS ABOUT 3 MILES AWAY. I REFILLED THE RESERVOIR WITH WATER TO GET ME TO THE SHOP. UPON INSPECTION, A HOLE WAS FOUND IN THE RADIATOR. WHEN THE COOLING SYSTEM WAS DISMANTLED, ONE COOLING FAN HAD COMPLETELY DISINTEGRATED AND THERE WAS A HOLE IN THE SHROUD APPARENTLY WHERE PART OF THE FAN BRACKET THAT HAD BROKEN OFF WENT THROUGH THE SHROUD INTO THE RADIATOR. PARTS HAV

Mileage: 68,507

TL*- THE CONTACT STATED THAT WHILE HAVING THE WHEELS ON THE 2001 VOLKSWAGEN EURO VAN WITH14000 FAILURE MILEAGE INSPECTED DUE TO CONSTANT AIR LEAKAGE THE MECHANIC DISCOVERED STRESS CRACKS IN THE TWO REAR WHEELS. THE CURRENT MILEAGE WAS 16100.*AK

Mileage: 14,000

DT*: THE CONTACT STATED WHILE DRIVING SMOKE WAS SMELLED. THE SMOKE WAS DISCOVERED COMING FROM THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY DETERMINED THE SEAT HEATER BURNED THE SEAT. THE HEATER AND SEAT WERE REPLACED. AFTER PICKING UP THE VEHICLE FROM THE DEALERSHIP, WHILE DRIVING HOME THE ENGINE BLEW AND THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP AGAIN. THE DEALERSHIP INSPECTED AND DETERMINED THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE.

Mileage: 52,000

DT*: THE CONTACT STATED WHILE DRIVING SMOKE WAS SMELLED. THE SMOKE WAS DISCOVERED COMING FROM THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY DETERMINED THE SEAT HEATER BURNED THE SEAT. THE HEATER AND SEAT WERE REPLACED. AFTER PICKING UP THE VEHICLE FROM THE DEALERSHIP, WHILE DRIVING HOME THE ENGINE BLEW AND THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP AGAIN. THE DEALERSHIP INSPECTED AND DETERMINED THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE.

Mileage: 52,000

DT: CONTACT STATES VEHICLE WILL NOT START. HOWEVER, AFTER WRIGGLING THE IGNITION SWITCH THE VEHICLE WILL START. THE SERVICE DEALER STATED IT WOULD BE AN EXPENSIVE REPAIR, THE WRIGGLING OF THE IGNITION MIGHTL RESOLVE THE PROBLEM.*AK

VEHICLE EXPERIENCED ELECTRICAL WIRING PROBLEMS IN FRONT WINDOWS ON BOTH SIDES. WHEN PRESSING THE BUTTON DOWN TO LOWER THE WINDOW SMOKE CAME OUT OF THE DOOR. CONSUMER TOOK VEHICLE TO A LOCAL REPAIR SHOP, AND REPLACED THE WIRING WHICH CONTROLLED BOTH FRONT WINDOWS. ALSO, THE WIRING BURNED DOWN TO THE CONTROL PANEL.*AK.....CONSUMER PAID $491,98 FOR REPAIRS. *AK

Mileage: 58,500

VEHICLE EXPERIENCED ELECTRICAL WIRING PROBLEMS IN FRONT WINDOWS ON BOTH SIDES. WHEN PRESSING THE BUTTON DOWN TO LOWER THE WINDOW SMOKE CAME OUT OF THE DOOR. CONSUMER TOOK VEHICLE TO A LOCAL REPAIR SHOP, AND REPLACED THE WIRING WHICH CONTROLLED BOTH FRONT WINDOWS. ALSO, THE WIRING BURNED DOWN TO THE CONTROL PANEL.*AK.....CONSUMER PAID $491,98 FOR REPAIRS. *AK

Mileage: 58,500

INTERMEDIATE DRIVE GEAR WHICH CONTROLS CAM SHAFT AND VALVE TRAIN FAILED DUE TO NON HARDENED METAL . TOTAL FAILURE OF ENGINE WAS TO ENSUE, ACCORDING TO VOLKSWAGEN(MAKER OF VEHICLE), IF DRIVEN FURTHER. THE CAR WAS BEING USED TO TRANSPORT MY FAMILY TO SEATTLE ,WA FROM SANTA ROSA,CA. THE FAILURE OCCURRED 500 MILES FROM HOME AND 75 MILES FROM NEAREST DEALER. WAS ADVISED BY VW THAT A VW DEALER MUST SERVE AS THE DIAGNOSTIC CENTER . THE FAILURE OCCURED IN WINTER AND WITH VIRTUALLY NO WARNING--THE "CHECK ENGINE " LIGHT ILLUMINATED AND THE ENGINE MADE A GROANING SOUND. THE VAN (EUROVAN 2001) WAS TRANSPORTED BY TRUCK TO CORVALLIS,OR FOR REPAIRS. VEHICLE IS PRRESENTLY STILL THERE AND UNDERGOING GEAR REPLACEMENT. I WAS TOLD BY THE VW SERVICE ADVISOR AT CORVALLIS THAT VW HAD BUILT AN UNKNOWN NUMBER OF ENGINES WITH THIS DEFECT BUT DID NOT KNOW IN WHICH VEHICLES THEY WERE PLACED. THE VEHICLE IN QUESTION HAS 27,000+/- ORIGINAL MILES ON ENGINE AND ALL SERVICES RECOMMENDED BY VW WERE MADE AT VW DEALERSH

Mileage: 27,000

MY BRAKES ARE SOFT AND FAIL TO KEEP THE CAR AT REST. THE PROBLEM STARTED ON 09/29/2004. SINCE THEN THE VW DEALER WAS NOT ABLE TO FIND THE PROBLEM EVEN THOUGH MANY PARTS WERE REPLACED. *JB

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXP

Mileage: 60,000

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXP

Mileage: 60,000

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXP

Mileage: 60,000

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXP

Mileage: 60,000

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXP

Mileage: 60,000

AIR CONDITIONER COMPRESSOR FAILURE AT JUST OVER 25,000 MILES. OTHER VOLKSWAGEN EUROVAN DRIVERS HAVE REPORTED SIMILAR FAILURES, INCLUDING SEIZING OF THE COMPRESSOR, IMMEDIATE LOSS OF THE COMPRESSOR DRIVE BELT, AND A RESULTING LOSS OF POWER STEERING CONTROL, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL.*AK

Mileage: 25,750

AIR CONDITIONER COMPRESSOR FAILURE AT JUST OVER 25,000 MILES. OTHER VOLKSWAGEN EUROVAN DRIVERS HAVE REPORTED SIMILAR FAILURES, INCLUDING SEIZING OF THE COMPRESSOR, IMMEDIATE LOSS OF THE COMPRESSOR DRIVE BELT, AND A RESULTING LOSS OF POWER STEERING CONTROL, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL.*AK

Mileage: 25,750

VW USED PLASTIC IN THE EUROVAN'S OIL FILTER HOUSING. DURING TWO OIL CHANGES (5,000 MILES AND THEN AT 64,000 MILES) THE PLASTIC OIL FILTER HOUSING WAS CRACKED DURING ROUTINE OIL CHANGES WHICH THEN CAUSED OIL LOSS AND SUBSEQUENT ENGINE DAMAGE/FAILURES. AS A RESULT OUR EUROVAN HAS SPENT 5 MONTHS IN THE SHOP FOR ONE ENGINE REBUILD AND THEN ONE ENGINE REPLACEMENT!*JB

Mileage: 5,000