2000 VOLKSWAGEN EUROVAN

I WAS DRIVING IN TOWN ON A CITY STREET ON MY WAY TO CHURCH AND THE DRIVERS SIDE SEAT HEATER BURNED THROUGH AND MELTED MY COAT A LITTLE BIT. MY BACK FELT BURNED A LITTLE BIT BUT WENT AWAY AFTER AWHILE SO I DID NOT HAVE ANY LASTING PAIN. BUT MY GOOD CHURCH COAT WAS LEFT WITH A SLIGHTY MELTED AREA ON IT. THE PASSENGER SIDE DID NOT BURN BECAUSE THE HEATER DOESNT WORK ANYMORE.

Mileage: 216,312

I WAS DRIVING IN TOWN ON A CITY STREET ON MY WAY TO CHURCH AND THE DRIVERS SIDE SEAT HEATER BURNED THROUGH AND MELTED MY COAT A LITTLE BIT. MY BACK FELT BURNED A LITTLE BIT BUT WENT AWAY AFTER AWHILE SO I DID NOT HAVE ANY LASTING PAIN. BUT MY GOOD CHURCH COAT WAS LEFT WITH A SLIGHTY MELTED AREA ON IT. THE PASSENGER SIDE DID NOT BURN BECAUSE THE HEATER DOESNT WORK ANYMORE.

Mileage: 216,312

THE ISSUE WITH THE VEHICLE IS THAT AN EXCESSIVE AMOUNT OF PRESSURE AND HEAT BUILDS UP INSIDE THE GAS TANK WHILE DRIVING AT ANY SPEED AND TO EVEN A GREATER EXTENT WHEN IN STOP-N-GO TRAFFIC OR SITTING IN THE PARKING LOT IDLING. THE RESULT IS THAT WHEN OPENING THE GAS CAP FROM HOT FUMES AND FUEL SPRAY OUT AFTER RUNNING THE VEHICLE FOR LESS THAN AN HOUR. THERE ARE NO CHECK ENGINE LIGHTS OR CHECKS IN PLACE TO WARN OR PREVENT THIS FROM HAPPENING. IT IS A MAJOR SAFETY CONCERN! I HAVE BEEN WORKING WITH THE VW DEALER FOR OVER ONE YEAR NOW BUT STILL NO RESOLVE. UNDER THE DIRECTION OF VW OF AMERICA THEIR CERTIFIED MECHANICS HAVE SYSTEMATICALLY REPLACED ALMOST ALL OF THE COMPONENTS RELATING TO THE FUEL SYSTEM BUT TO NO RESOLVE. AT THIS POINT THE PROBLEM STILL PERSIST AND THE DEALERSHIP IS RELUCTANT TO ACKNOWLEDGE THAT THE GAS TANK IS ACTUALLY HEATING UP EVEN THOUGH THEY HAVE REPRODUCED THE RESULTS IN THEIR SHOP. I DO HAVE A VIDEO OF THE PROBLEM IN ACTION BUT AM UNABLE TO SHARE THAT WITH YOU THRO

Mileage: 180,000

FAN FOR COOLING THE AIR CONDITIONING UNIT (IN ENGINE COMPARTMENT) BLEW APART, DAMAGING ELECTRONIC COMPONENTS ADJACENT TO IT. THE OTHER FAN (FOR ENGINE COOLING) FAILED LAST YEAR. *TR

Mileage: 97,000

TL*THE CONTACT OWNS A 2000 VOLKSWAGEN EUROVAN. THE CONTACT STATED THAT THE METAL BRACKET, WHICH HOLDS THE LUGGAGE RACK ONTO THE VEHICLE, WAS RUSTED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT IT WAS CAUSED BY THE WEATHER. THE CURRENT MILEAGE WAS 90,000 AND FAILURE MILEAGE WAS 30,000. UPDATED 10/18/07 *TR

Mileage: 30,000

ENGINE COOLING FAN ON DRIVER'S (LEFT) SIDE BROKE AND LOST A PIECE, CAUSING THE FAN TO BECOME UNBALANCED. THE LACK OF BALANCE CAUSED SEVERE VIBRATION IN THE CAR. CAR IS CURRENTLY IN THE SHOP FOR REPAIR (REPLACEMENT) OF THE FAN. *TR

Mileage: 89,000

MY KID PULLED ON HIS SEAT BELT TO FASTEN IT, AND THE MALE LATCH CAME DETACHED FROM THE BELT. THE LATCH IS MADE BY TRW-AUTOMOTIVE, THE WORLD'S LARGEST PROVIDER OF SEAT BELT SYSTEMS. IT HAS THE FOLLOWING IDENTIFICATION: 0006 5980 TRW. THE SEAT BELT THAT FAILED IS A LAP-BELT ONLY (CENTER-SEAT). THE LATCH CONSISTS OF TWO SLIDING METAL PARTS AND A PLASTIC COVER. WHEN THE PLASTIC COVER BREAKS, THE BELT COMES LOOSE FROM THE MALE LATCH. THE SEAT BELT CAN FAIL IN A CRASH RESULTING IN INJURY FROM THE CRASH. I REPORTED THIS TO VW CUSTOMER CARE, 800-822-8987. THEY ENTERED IT INTO THEIR DATABASE, AND TOLD ME TO GO TO A VW DEALER TO GET A REPAIR. *NM

Mileage: 76,000

MY WIFE, ON A RECENT DRIVE FROM NO. CALIFORNIA TO SOUTHERN CA NOTED AN UNUSUAL SOUND FROM UNDER THE HOOD. NO OVERHEATING OR OTHER ISSUES THOUGH. WHEN SHE STOPPED SHE NOTED ONE OF THE PLASTIC RADIATOR FANS WAS BROKEN IN MULTIPLE PIECES. SINCE SHE WAS AWAY FROM HOME I TOLD HER TO GO TO THE LOCAL DEALER FOR REPAIRS. THEY DECIDED THE ENTIRE FAN ASSEMBLY HAD TO BE REPLACED, AND THAT THE RADIATOR HAD TO BE REPLACED AS WELL. THE PARTS ALONE WERE ABOUT $2300 TOTAL REPAIR FOR THIS ABOUT $2900. WHEN THEY RETURNED THE CAR SHE FOUND THAT THE AC WAS NO LONGER WORKING. SO BACK TO THE DEALER. THEY STATED THE AC COMPRESSOR WAS BAD (BTW THE AC WORKED WELL PRIOR TO THE RADIATOR EVENT) SO THE COMPRESSOR AND EVAPORATOR/DRYER WERE REPLACED ANOTHER $1200 APPROX. THEN UPON RETURNING HOME TO NO. CAL. THE AC STILL DIDN'T WORK. NOW WE WENT TO THE LOCAL DEALER AND THEY STATED THE HIGH AND LOW PRESSURE HOSES TO THE AC WERE BAD AND NEEDED TO BE REPLACED, PARTS ALONE $750 THE DEALER IN LONG BEACH DID KICK IN $

Mileage: 61,000

2000 VOLKSWAGEN EUROVAN ENGINE COOLING FAN BROKE APART.*MR WHILE DRIVING THE VEHICLE BEGAN TO VIBRATE VIOLENTLY. THE CONSUMER PULLED OFF TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE. UPON INSPECTION HE NOTICED THAT ONE OF THE COOLING FANS HAD BROKEN. THE CONSUMER DID SOME RESEARCH ABOUT FOUND OUT THAT 1998-2000 EUROVANS HAD BEEN RECALLED FOR THE EXACT SAME PROBLEM BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED DUE TO VIN. *NM

Mileage: 28,718

THREE TIMES IN THE LAST 3 YEARS (2003-2005) I HAVE HAD TO REPLACE MY ENGINE COOLING FANS ON A 2000 VW EUROVAN, TWICE BECAUSE THEY EXPLODED. IN EACH CASE ADDITIONAL DAMAGE WAS INCURRED DUE TO THE FLYING PIECES OF FAN. THE VW DEALERS (IN NJ, VA/FL, AND PA) ASSERTED THAT THERE WAS NO HISTORY OF THIS OCCURRING, DESPITE CORRESPONDENCE BETWEEN VW AND NHTSA IN 2003. *NM

Mileage: 50,000

DT:I BRAKE LIGHT WILL COME ON . WHEN THE BRAKE LIGHT COMES ON THE HEADLIGHTS GO OFF/THE WINDSHIELD WIPERS STOP FUNCTIONING, AND AIR CONDITIONER (A/C) STOPS. THE NEW DEALER COULD NOT FIND CAUSE OF THE PROBLEM, AND CLAIMED THAT IT WAS NORMAL. IT WAS HAPPENING QUITE FREQUENTLY. CONSUMER HAS TEENAGE CHILDREN, AND IF THIS HAD HAPPENED ON THE INTERSTATE,ONE OF MY CHILDREN COULD HAVE DIED. IF HEADLIGHTS HAD BEEN TURNED ON, AND IF I CONSUMER PULLED ON THEM HIGH BEAM WOULD STICK AND STAY ON. CONSUMER WOULD ONLY HAVE HIGH BEAMS. ALSO, THE WINDSHIELD WIPERS WILL COME ON. *AK

Mileage: 93,000

DT:I BRAKE LIGHT WILL COME ON . WHEN THE BRAKE LIGHT COMES ON THE HEADLIGHTS GO OFF/THE WINDSHIELD WIPERS STOP FUNCTIONING, AND AIR CONDITIONER (A/C) STOPS. THE NEW DEALER COULD NOT FIND CAUSE OF THE PROBLEM, AND CLAIMED THAT IT WAS NORMAL. IT WAS HAPPENING QUITE FREQUENTLY. CONSUMER HAS TEENAGE CHILDREN, AND IF THIS HAD HAPPENED ON THE INTERSTATE,ONE OF MY CHILDREN COULD HAVE DIED. IF HEADLIGHTS HAD BEEN TURNED ON, AND IF I CONSUMER PULLED ON THEM HIGH BEAM WOULD STICK AND STAY ON. CONSUMER WOULD ONLY HAVE HIGH BEAMS. ALSO, THE WINDSHIELD WIPERS WILL COME ON. *AK

Mileage: 93,000

DT:I BRAKE LIGHT WILL COME ON . WHEN THE BRAKE LIGHT COMES ON THE HEADLIGHTS GO OFF/THE WINDSHIELD WIPERS STOP FUNCTIONING, AND AIR CONDITIONER (A/C) STOPS. THE NEW DEALER COULD NOT FIND CAUSE OF THE PROBLEM, AND CLAIMED THAT IT WAS NORMAL. IT WAS HAPPENING QUITE FREQUENTLY. CONSUMER HAS TEENAGE CHILDREN, AND IF THIS HAD HAPPENED ON THE INTERSTATE,ONE OF MY CHILDREN COULD HAVE DIED. IF HEADLIGHTS HAD BEEN TURNED ON, AND IF I CONSUMER PULLED ON THEM HIGH BEAM WOULD STICK AND STAY ON. CONSUMER WOULD ONLY HAVE HIGH BEAMS. ALSO, THE WINDSHIELD WIPERS WILL COME ON. *AK

Mileage: 93,000

AIR CONDITIONING (A/C) FAILURE. THE AC SYSTEM IN MY VOLKS EUROVAN HAS FAILED THREE TIMES OVER THE LAST THREE YEARS. EACH TIME IT HAS BEEN $1400 REPAIR. I HAVE TALKED TO OTHER EUROVAN OWNERS AND THEY ARE HAVING THE SAME PROBLEM. IN FACT THE LOCAL DEALERSHIP SERVICE CENTER TOLD ME VW NEEDS TO RECALL THESE VANS BECAUSE IT IS A CHRONIC PROBLEM. I CALLED VW USA AND THEY DIDN'T OFFER ANY SERVICE. THE VAN AC HAS FAILED ON THE FOLLOWING DATES. DEC 02, JUNE 04, AND MAR 2005. *AK

Mileage: 80,000

I AM AN OWNER OF 2000 VOLKSWAGON CAMPER OWNER. MY ENGINE COOLING FANS CAME APART. I WOULD LIKE TO KNOW WHY IT IS NOT RECALLED. IN MAY 2004, I RECEIVED FROM VOLKSWAGEN A STICKER TO PUT AT THE SIDE OF THE HOOD FOR WARNING THE ENGINE COOLING FANS MAY CAUSE PERSONAL INJURY. IT WAS NOT A RECALL NOTICE. ON JULY 4 WEEKEND, I PLANNED WITH THE FAMILY FROM SAN FRANCISCO TO CENTRAL CALIFORNIA SHAVER LAKE FOR A RETREAT. WE DRIVE UP ON ROUTE 168. SUDDENLY WE HEARD A LOUD NOISE FROM OUR 2000 VW CAMPER. WE ASK EACH OTHER WHAT IT WAS. WE THOUGHT IT MIGHT BE SOMETHING WE HIT UNDERNEATH THE CAMPER. WE STILL CONTINUED ON OUR WAY. WITHIN FEW MINUTES, ANOTHER LOUD NOISES AGAIN. WE KNOW THAT MUST BE SOMETHING WRONG WITH THE CAMPER. WE PULL TO THE SIDE AND I COULD HEAR A HUM SOUND THAT I NEVER HEARD BEFORE. I OPEN THE HOOD AND FOUND SOME HARD-PLASTIC PARTS NEAR THE HOOD. THERE WERE TWO FANS AND THE NOISE WAS COME FROM THE FANS. BOTH FANS WERE INCINERATED EXCEPT THE CENTER HUB STILL SPINNING WE HAVE CA

Mileage: 47,003

SIMULTANEOUS FAILURE OF INSULATION ON MANY WIRES IN DRIVER'S DOOR WIRING HARNESS CAUSED SPARKS, AND ELECTRICAL MALFUNCTION OF POWER WINDOWS, POWER LOCKS, DASH LIGHTS, AND LICENSE PLATE LIGHTS. HEAT FROM EXCESSIVE CURRENT AND SPARKS COULD HAVE RESULTED IN FIRE. ACCIDENT COULD HAVE BEEN CAUSED BY DRIVER LEANING OVER TO PASSENGER SIDE IN ORDER TO OPERATE PASSENGER WINDOW. OTHER PROBLEMS SUCH AS DEAD BATTERY, ENGINE FAILURE, OR SECURITY FAILURE COULD ALSO BE CAUSED BY DEFECT.DEFECT APPEARS TO BE IN DESIGN OF WIRING HARNESS WHICH FLEXES AT THE EXACTLY THE SAME POINT WHEN DOOR IS OPENED AND CLOSED COMBINED WITH POOR QUALITY MATERIAL USED FOR WIRING INSULATION. INSULATION HAS CRACKED AND SPLIT APART ON MANY OF THE WIRES IN THE DOOR WIRING HARNESS ALLOWING BARE COPPER TO COME INTO CONTACT RANDOMLY FROM WIRE TO WIRE.*AK

Mileage: 49,000

SIMULTANEOUS FAILURE OF INSULATION ON MANY WIRES IN DRIVER'S DOOR WIRING HARNESS CAUSED SPARKS, AND ELECTRICAL MALFUNCTION OF POWER WINDOWS, POWER LOCKS, DASH LIGHTS, AND LICENSE PLATE LIGHTS. HEAT FROM EXCESSIVE CURRENT AND SPARKS COULD HAVE RESULTED IN FIRE. ACCIDENT COULD HAVE BEEN CAUSED BY DRIVER LEANING OVER TO PASSENGER SIDE IN ORDER TO OPERATE PASSENGER WINDOW. OTHER PROBLEMS SUCH AS DEAD BATTERY, ENGINE FAILURE, OR SECURITY FAILURE COULD ALSO BE CAUSED BY DEFECT.DEFECT APPEARS TO BE IN DESIGN OF WIRING HARNESS WHICH FLEXES AT THE EXACTLY THE SAME POINT WHEN DOOR IS OPENED AND CLOSED COMBINED WITH POOR QUALITY MATERIAL USED FOR WIRING INSULATION. INSULATION HAS CRACKED AND SPLIT APART ON MANY OF THE WIRES IN THE DOOR WIRING HARNESS ALLOWING BARE COPPER TO COME INTO CONTACT RANDOMLY FROM WIRE TO WIRE.*AK

Mileage: 49,000

POWER WINDOWS FAILED TO OPERATE. THIS WAS CAUSED BY AN ELECTRICAL FIRE IN THE WIRING HARNESS THAT BURNT THE INSULATION.*AK

Mileage: 70,000

POWER WINDOWS FAILED TO OPERATE. THIS WAS CAUSED BY AN ELECTRICAL FIRE IN THE WIRING HARNESS THAT BURNT THE INSULATION.*AK

Mileage: 70,000

CONSUMER STATED THAT WHILE HE WAS DRIVING COOLING FAN DISINTEGRATED AND BROKE INTO A THOUSAND PIECES, AND A PIECE GOT LODGED IN THE POWER STEERING FAN BELT. THIS CAUSED CONSUMER TO LOSE POWER STEERING. HE CALLED THE MANUFACTURER BUT COULD NOT GET HELP. CONSUMER WAS TOLD THEY WOULD HAVE TO CHARGE HIM AT THE TUNE OF $1000.00 TO REPAIR THE PROBLEM.*AK