1994 PLYMOUTH GRAND VOYAGER

MY CRUISE CONTROL SYSTEM DOES NOT WORK. I HAVE CHECKED ALL THE FUSES. THEY ARE ALL OK. WHEN CONTACTING SEVERAL MECHANIC AND READING ON-LINE FROM OTHER OWNERS WITH SIMILAR PROBLEM, IT IS COMMONLY REVEALED THAT THE AIR BAG SPRING IN THE STEERING WHEEL MAY HAVE GONE BAD WHICH IS NOT UNCOMMON. THE VEHICLE, OTHERWISE IS OPERABLE. I WONDER IF THIS REVELATION IS TRUE, ARE THERE ANY OTHER SERIOUS RISKS THAT COULD BE ASSOCIATED WITH THIS.

Mileage: 196,000

MY CRUISE CONTROL SYSTEM DOES NOT WORK. I HAVE CHECKED ALL THE FUSES. THEY ARE ALL OK. WHEN CONTACTING SEVERAL MECHANIC AND READING ON-LINE FROM OTHER OWNERS WITH SIMILAR PROBLEM, IT IS COMMONLY REVEALED THAT THE AIR BAG SPRING IN THE STEERING WHEEL MAY HAVE GONE BAD WHICH IS NOT UNCOMMON. THE VEHICLE, OTHERWISE IS OPERABLE. I WONDER IF THIS REVELATION IS TRUE, ARE THERE ANY OTHER SERIOUS RISKS THAT COULD BE ASSOCIATED WITH THIS.

Mileage: 196,000

MY CRUISE CONTROL SYSTEM DOES NOT WORK. I HAVE CHECKED ALL THE FUSES. THEY ARE ALL OK. WHEN CONTACTING SEVERAL MECHANIC AND READING ON-LINE FROM OTHER OWNERS WITH SIMILAR PROBLEM, IT IS COMMONLY REVEALED THAT THE AIR BAG SPRING IN THE STEERING WHEEL MAY HAVE GONE BAD WHICH IS NOT UNCOMMON. THE VEHICLE, OTHERWISE IS OPERABLE. I WONDER IF THIS REVELATION IS TRUE, ARE THERE ANY OTHER SERIOUS RISKS THAT COULD BE ASSOCIATED WITH THIS.

Mileage: 196,000

TL* THE CONTACT OWNS A 1994 PLYMOUTH VOYAGER. THE CONTACT STATED THAT SHE HAD TO REPLACE THE WINDOW SHIELD WIPER MOTOR THREE TIMES IN A ONE YEAR PERIOD. THE CONTACT FOUND NHTSA RECALL CAMPAIGN ID NUMBER: 99V189000 (VISIBILITY: WINDSHIELD WIPER/WASHER LINKAGES), WHICH DEALT WITH THE DRIVER'S SIDE PIVOT ASSEMBLY. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS INFORMED THAT THERE WAS NOTHING THAT COULD BE DONE TO REPAIR THE PROBLEM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 68,000. UPDATED 8/8/12 *CN UPDATED 08/14/12

Mileage: 68,000

TL* THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AS IT OPERATED AS NORMAL. THE FAILURE BEGAN TO RECUR INTERMITTENTLY SO THE VEHICLE WAS TAKEN TO VARIOUS INDEPENDENT REPAIR FACILITIES WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE FUEL PUMP WAS REPLACED BUT THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS UNAVAILABLE.

Mileage: 200,000

VEHICLE HANDLING DEGRADED DUE TO REAR AXLE/BEAM FAILURE. THE HANDLING OF THE MINIVAN WAS SIGNIFICANTLY DIFFERENT. I INSPECTED THE VEHICLE AND NOTICED THE REAR WHEEL HAD A SIGNIFICANT NEGATIVE CAMBER WHEN IT HAS A SOLID REAR AXLE/BEAM. I JACKED THE CAR UP AND INSPECTED THE REAR / AXLE AND BEAM AND SAW A NEAR COMPLETE RUST THROUGH OF THE REAR AXLE/BEAM. THE RUST RESULTED IN THE REAR AXLE BENDING UPWARDS NEAR THE RIGHT REAR WHEEL CASTING/HUB. THIS IN TURN YIELDED THE NEGATIVE CAMBER. THE FAILURE WAS CAUGHT PRIOR TO OCCURRING WHILE AT NORMAL SPEEDS (55 MPH). THERE IS NO QUESTION THAT IF THIS HAD FAILED AT 55 MPH IT WOULD HAVE RESULTED IN COMPLETE LOSS OF CONTROL. THE DRIVERS SIDE REAR WHEEL ASSEMBLY WOULD HAVE ONLY BEEN HELD ON BY A SHOCK ABSORBER AND BRAKE LINE. I HAVE NOT YET FINALIZE HOW TO REPAIR THIS BUT LOOKING AT THE REAR AXLE/BEAM ASSEMBLY IT WILL TAKE A COMPLETE REPLACEMENT OF THIS ASSEMBLY. I'D EXPECT THIS TO BE A $2000 REPAIR. I HAVE DETAILED PHOTOGRAPHS AND A REPORT

Mileage: 133,900

TL*THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. THE CONTACT IS EXPERIENCING A LEAK IN THE FUEL SYSTEM NEXT TO THE EXHAUST MANIFOLD. HE TOOK HIS VEHICLE TO THE LOCAL DEALER AND WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V268000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THEY REPLACED THE FUEL RAIL, BUT WOULD NOT REPAIR IT WITH A FREE SERVICE CHARGE. THE CURRENT AND FAILURE MILEAGES WERE 180,000.

Mileage: 180,000

TL*THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. WHILE DRIVING 4 MPH, THE REAR DRIVER SIDE AXLE SNAPPED. THE VEHICLE SHOOK VIOLENTLY AND THE CONTACT HEARD A SQUEALING NOISE RIGHT BEFORE THE FAILURE OCCURRED. THIS IS THE FOURTH TIME THAT THE AXLE HAS BEEN TOWED AND REPAIRED. THE CURRENT MILEAGE IS 115,000 AND FAILURE MILEAGE WAS 110,000.

Mileage: 110,000

FATIGUE CRACKING OF THE DRIVER'S SIDE DOOR HINGE PILLAR AROUND THE HINGE. THE CRACK HAS PROGRESSED ROUGHLY 50% OF THE WAY AROUND THE HINGE AND WILL LEAD TO COMPLETE SEPARATION OF THE HINGE FROM THE PILLAR WITHOUT REPAIR. THIS CAR HAS HAD NO ACCIDENTS. THE INCIDENT DATE IS THE APPROXIMATE DATE THE CRACK WAS FIRST DETECTED. *JB

Mileage: 200,000

NHTS CAMPAIGN 99V189000 CONCERNS A FAILURE OF WINDSHIELD WIPER LINKAGES ON 1993 PLYMOUTH VOYAGERS LEADING TO TOTAL LOSS OF WIPER FUNCTION. THIS HAPPENED TO MY DAUGHTER TODAY DURING A STORM, FORCING HER TO RETURN HOME VERY SLOWLY. NO ACCIDENT, NO ONE HURT. (NOTE THAT I AM A REGISTERED PROFESSIONAL ENGINEER.) UPON HER RETURN, I INSPECTED AND FOUND THAT: 1. THE WIPER MOTOR WAS RUNNING AND COULD BE AUDIBLY HEARD WHILE THE WIPERS SAT MOTIONLESS. 2. THE TWO WIPERS WERE LINKED TOGETHER AND COULD BE MOVED EASILY BY HAND. 3. THE RUNNING WIPER MOTOR WOULD NOT MOVE THE WIPERS. AT THAT POINT I REMOVED THE 3 BOLTS HOLDING THE WIPER MOTOR IN PLACE AND LOOKED INSIDE THE WIPER ARM CAVITY. I FOUND WIPER DRIVE ARM TO BE DETACHED FROM THE ROTATING ARM ON THE DRIVE MOTOR SHAFT. I HAVE DIGITAL PHOTOGRAPHS AVAILABLE IF YOU WOULD LIKE TO SEE THEM. THE REASON FOR MY REPORT IS THIS: THE VAN WHICH THIS HAPPENED TO IS A 1994 GRAND VOYAGER, SAME BODY STYLE AS THE 1993. HOW DOES ONE SUGGEST THAT

Mileage: 140,000

CONSUMER CLOSED THE SLIDING PASSENGER DOOR WHICH HAS BEEN DIFFICULT TO OPEN AND CLOSE FOR SOME TIME, AND CURRENTLY IT FELL OFF. ALSO, WHEN DRIVING THE AUTOMATIC LOCKS KEPT LOCKING, AND THE BELL KEPT GOING ON. THE INTERIOR LIGHTS FLASHED, AND THE DOOR AJAR LIGHT CAME ON.*AK

Mileage: 105,752

CONSUMER CLOSED THE SLIDING PASSENGER DOOR WHICH HAS BEEN DIFFICULT TO OPEN AND CLOSE FOR SOME TIME, AND CURRENTLY IT FELL OFF. ALSO, WHEN DRIVING THE AUTOMATIC LOCKS KEPT LOCKING, AND THE BELL KEPT GOING ON. THE INTERIOR LIGHTS FLASHED, AND THE DOOR AJAR LIGHT CAME ON.*AK

Mileage: 105,752

WITHOUT WARNING THE TOP HINGE OF THE HYDRAULIC LIFT OF THE TAILGATE SNAPPED WHILE I WAS DRIVING. HYDRAULIC "TUBE" WAS SENT INTO THE CEILING OF THE VAN, CAUSING THE INTERIOR AND CEILING TO HAVE SEVERE DAMAGE. HATCH CANNOT BE OPENED WITHOUT REMOVING HYDRAULIC ASSEMBLY.*AK

CAR WAS RECALLED TO CORRECT AIR BAG LIGHT MALFUNCTION, BUT PRESENTLY THE AIRBAG LIGHT CONTINUED TO COME ON, AND IT SMELLED AS IF SOMETHING ELETRICAL WAS BURNING. MY RADIO WENT OUT, THE INTERIOR LIGHTS WOULDN'T COME ON AND THE CAR SIMPLY WOULDNOT EVEN TURN OVER. THE CAR WAS REPAIRED, SITING A FUSE ON 11/23/04. THE SMELL OF BURNING RUBBER OR SOMETHING ELECTRICAL WAS NOTED , THE INTERIOR LIGHTS WENT DIM, LIGHTS APPEARED ON DASH, SPEED WAS REDUCED SO RAPIDLY IT FELT AS IF SOMETHING HAS FALLEN FROM THE BOTTOM OF VEHICLE. I BELIEVE THAT MY INSTRUMENT CLUSTER PANEL IS SHORTING OUT DUE TO THIS MALFUNCTION. PLEASE HELP ME.*AK

Mileage: 69,000

CAR WAS RECALLED TO CORRECT AIR BAG LIGHT MALFUNCTION, BUT PRESENTLY THE AIRBAG LIGHT CONTINUED TO COME ON, AND IT SMELLED AS IF SOMETHING ELETRICAL WAS BURNING. MY RADIO WENT OUT, THE INTERIOR LIGHTS WOULDN'T COME ON AND THE CAR SIMPLY WOULDNOT EVEN TURN OVER. THE CAR WAS REPAIRED, SITING A FUSE ON 11/23/04. THE SMELL OF BURNING RUBBER OR SOMETHING ELECTRICAL WAS NOTED , THE INTERIOR LIGHTS WENT DIM, LIGHTS APPEARED ON DASH, SPEED WAS REDUCED SO RAPIDLY IT FELT AS IF SOMETHING HAS FALLEN FROM THE BOTTOM OF VEHICLE. I BELIEVE THAT MY INSTRUMENT CLUSTER PANEL IS SHORTING OUT DUE TO THIS MALFUNCTION. PLEASE HELP ME.*AK

Mileage: 69,000

WHILE DRIVING 70 MPH, THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION. BOTH FRONTAL AIR BAGS FAILED TO DEPLOY AND BOTH FRONTAL SEAT BELTS FAILED TO LOCK. THIS CAUSED THE PASSENGER TO SUSTAINED MINOR INJURIES AND WAS TRANSPORTED TO THE HOSPITAL. THE VEHICLE WAS TOWED TO A GARAGE. THE CAUSE HAS NOT BEEN DETERMINED AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *JB *TC

Mileage: 155,975

WHILE DRIVING 70 MPH, THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION. BOTH FRONTAL AIR BAGS FAILED TO DEPLOY AND BOTH FRONTAL SEAT BELTS FAILED TO LOCK. THIS CAUSED THE PASSENGER TO SUSTAINED MINOR INJURIES AND WAS TRANSPORTED TO THE HOSPITAL. THE VEHICLE WAS TOWED TO A GARAGE. THE CAUSE HAS NOT BEEN DETERMINED AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *JB *TC

Mileage: 155,975

PLASTIC HEADLIGHTS GET CLOUDY AND SIGNIFICANTLY REDUCE LIGHT OUTPUT AND THUS VISIBILITY DURING NIGHT TIME DRIVING. I HAVE EXPERIENCED THIS WITH SEVERAL CHRYSLER CORPORATION MINIVANS AND A NISSAN ALTIMA, HOWEVER, A QUICK TOUR THRU A PARKING LOT WILL IDENTIFY NUMEROUS CAR MAKES AND MODELS WITH CLOUDED HEADLIGHTS. IF THE PLASTIC CAN'T BE MANUFACTURED IN A WAY THAT PREVENTS IT FROM GETTING CLOUDY OR YELLOW, MANUFACTURERS SHOULD BE REQUIRED TO USE GLASS. *AK

WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONSUMER WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *JB

I WAS DRIVING A GROUP OF STUDENTS WHEN I HEARD A LOUD EXPLOSION AND LOST ALL GEARS ON MY TRANSMISSION. I STOPPED THE VEHICLE, TRIED TO PUT IT IN PARK AND IT KEPT ROLLING. THE INTERIOR OF THE TRANSMISSION HAD BLOWN. AT THE SAME TIME, IT BLEW OUT THE STARTER AND THE MAIN DRIVE. IF I CAN FIND A USED OR REBUILT TRANSMISSION, IT WILL COST ME $1,000 FOR THE TRANSMISSION PLUS LABOR COSTS. BEEN SEARCHING 2 WEEKS WITH NO LUCK. IT'S ABOUT TIME SOMEONE TAKES THESE REPORTS SERIOUSLY. AN INVESTIGATION NEEDS TO BE STARTED. I BOUGHT THIS VAN FROM MY DAD WHO REPLACED THE TRANSMISSION IN 1999. IT'S 2004 AND IT NEEDS REPLACED AGAIN.*AK