2022 HYUNDAI SANTA FE PLUG-IN HYBRID

SEAT BELTS:PRETENSIONER

Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe HEV and Santa Fe PHEV vehicles. The instrument cluster liquid-crystal display (LCD) may invert the image on the screen upon vehicle startup, making the display illegible. As such, these vehicles fail to comply with the requirements

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe Plug-In Hybrid vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirem

TRAILER HITCHES

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water acc

This is a 2022 Santa Fe PHEV with just 33k miles on it. While driving on freeway, vehicle displayed warning sign for "Check Hybrid System" and the Check Engine light and Battery light switched on. Sensing a loss of power with the acceleration, I managed to get off the freeway and had to get the vehicle towed to the nearest dealership. Once they checked the vehicle, they reported they had to recalibrate the HSG resolver motor and claimed the issue was now fixed. I collected the vehicle back from the dealership and to my horror, on the drive back home, the exact same problem resurfaced and I experienced a loss of power and stalling again. Now I have to tow the vehicle to another dealer again. Searching the internet for this problem shows that many other drivers have experienced and reported this issue, so I am recording my formal complaint. Twice in the space of a few days, I have experienced a safety issue that could have affected myself and my family and other drivers on the road. Hyu

First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months in the service center with continuously new issues. Every time they assure us it is fixed and we try to take it home, it develops another failure and the check engine light returns. The technicians have told us they have no explanation for the multiple failures and are not confident they can permanently fix the vehicle. The failures are unrelated and are with the manifold, gasket, CVVD,, oxygen sensor, and battery. A bolt also sheared off in this time frame and had to be drilled out. In the last failure, the car began smoking heavily and dripping oil. We've requested a replacement. Hyundai said they will not replace the vehicle (nor buy back) and it is acceptable that multiple systems and

First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months in the service center with continuously new issues. Every time they assure us it is fixed and we try to take it home, it develops another failure and the check engine light returns. The technicians have told us they have no explanation for the multiple failures and are not confident they can permanently fix the vehicle. The failures are unrelated and are with the manifold, gasket, CVVD,, oxygen sensor, and battery. A bolt also sheared off in this time frame and had to be drilled out. In the last failure, the car began smoking heavily and dripping oil. We've requested a replacement. Hyundai said they will not replace the vehicle (nor buy back) and it is acceptable that multiple systems and

First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months in the service center with continuously new issues. Every time they assure us it is fixed and we try to take it home, it develops another failure and the check engine light returns. The technicians have told us they have no explanation for the multiple failures and are not confident they can permanently fix the vehicle. The failures are unrelated and are with the manifold, gasket, CVVD,, oxygen sensor, and battery. A bolt also sheared off in this time frame and had to be drilled out. In the last failure, the car began smoking heavily and dripping oil. We've requested a replacement. Hyundai said they will not replace the vehicle (nor buy back) and it is acceptable that multiple systems and

I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took car and immediately noticed grinding noises and straight back to Hyundai. They claim it's fine. Today same issue with reversing and aggressive car jolting. Hyundai is going to take it back tomorrow. I do not feel safe in this vehicle. It felt like the transmission was going to give out on the freeway. The rpm are maxing out at 5-20 mph and sometimes don't want to engage in drive. Extremely unsafe for freeway driving. There is something terribly wrong with this cars engine or transmission. Unsafe for Hyundai to release for use.

I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took car and immediately noticed grinding noises and straight back to Hyundai. They claim it's fine. Today same issue with reversing and aggressive car jolting. Hyundai is going to take it back tomorrow. I do not feel safe in this vehicle. It felt like the transmission was going to give out on the freeway. The rpm are maxing out at 5-20 mph and sometimes don't want to engage in drive. Extremely unsafe for freeway driving. There is something terribly wrong with this cars engine or transmission. Unsafe for Hyundai to release for use.

I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took car and immediately noticed grinding noises and straight back to Hyundai. They claim it's fine. Today same issue with reversing and aggressive car jolting. Hyundai is going to take it back tomorrow. I do not feel safe in this vehicle. It felt like the transmission was going to give out on the freeway. The rpm are maxing out at 5-20 mph and sometimes don't want to engage in drive. Extremely unsafe for freeway driving. There is something terribly wrong with this cars engine or transmission. Unsafe for Hyundai to release for use.

I believe my vehicle is part of the parking prawn recall. It jerked and jolt when in park very aggressively. When we proceeded to try to move the car in reverse it did not budge.

The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however the issue would eventually happen again. This has happened while driving on the highway and other various road situations without warning and making the vehicle very unsafe. I have taken my vehicle to Hyundai Ourisman in Bowie, Maryland (the dealership where I purchased the vehicle) three times over two years and they have failed to fix the problem. They have even replaced the battery in the car.

The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however the issue would eventually happen again. This has happened while driving on the highway and other various road situations without warning and making the vehicle very unsafe. I have taken my vehicle to Hyundai Ourisman in Bowie, Maryland (the dealership where I purchased the vehicle) three times over two years and they have failed to fix the problem. They have even replaced the battery in the car.

The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however the issue would eventually happen again. This has happened while driving on the highway and other various road situations without warning and making the vehicle very unsafe. I have taken my vehicle to Hyundai Ourisman in Bowie, Maryland (the dealership where I purchased the vehicle) three times over two years and they have failed to fix the problem. They have even replaced the battery in the car.

Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting to slow the car. Attached photo shows an indicated speed of 0mph, however was travelling approximately 50mph at this time. I also have video of the errors occurring, but there is not a way to upload video.

Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting to slow the car. Attached photo shows an indicated speed of 0mph, however was travelling approximately 50mph at this time. I also have video of the errors occurring, but there is not a way to upload video.

Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting to slow the car. Attached photo shows an indicated speed of 0mph, however was travelling approximately 50mph at this time. I also have video of the errors occurring, but there is not a way to upload video.

Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on the freeway and lost acceleration causing me to pull off the road in median. The third time, I was at a stoplight and when the light turned green, I had almost no movement after edging into the intersection. Eventually, at about 5 mph, the car regained speed. The check light went on in the first event and the car was supposedly repaired at the second dealership by re-tensioning "pins". However, no lights or warnings went on for incident #2 or #3 that occurred after the earlier repair effort. The vehicle is currently at the dealership service center for it's 7th day of "unable to replicate the problem" after incident #3.

Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on the freeway and lost acceleration causing me to pull off the road in median. The third time, I was at a stoplight and when the light turned green, I had almost no movement after edging into the intersection. Eventually, at about 5 mph, the car regained speed. The check light went on in the first event and the car was supposedly repaired at the second dealership by re-tensioning "pins". However, no lights or warnings went on for incident #2 or #3 that occurred after the earlier repair effort. The vehicle is currently at the dealership service center for it's 7th day of "unable to replicate the problem" after incident #3.

Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on the freeway and lost acceleration causing me to pull off the road in median. The third time, I was at a stoplight and when the light turned green, I had almost no movement after edging into the intersection. Eventually, at about 5 mph, the car regained speed. The check light went on in the first event and the car was supposedly repaired at the second dealership by re-tensioning "pins". However, no lights or warnings went on for incident #2 or #3 that occurred after the earlier repair effort. The vehicle is currently at the dealership service center for it's 7th day of "unable to replicate the problem" after incident #3.

From park to Drive or reverse there’s an issues with changing in between doing so. Loud noise and shake to the car when engaging in the new gear. Then it sounds like the cars accelerating but parked, not moving. When you put it back in drive a loud thud then revving noise occurs. Once driving again just after there’s little to no movement when you put your foot on the pedal. When you drive it’s slow to go. You can hear the car trying but you’re hit going the same pace as the other cars on the road. Seems unsafe. This has happened more than once. I mentioned it to the delayer they said it was fine. No issues.

While driving on the freeway, another vehicle passed me in the lane to the right of me. Right before it passed me, my car triggered automatic emergency braking for no reason. It was very terrifying. The other car was in its own lane the entire time. This has happened multiple times.

The contact owns a 2022 Hyundai Santa Fe. The contact received a notification for NHTSA Campaign Number: 23V181000 (Trailer Hitches); however, the parts for the repair were unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.