Total Complaints
848 filings
FORD EXPLORER · model year
1992 FORD EXPLORER
848 NHTSA complaints, 54 crash reports for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 1992FORDEXPLORER carries 848 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 54 crashes, 84 fires, 65 injuries, and 4 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 1992 EXPLORER is tires:tread/belt with 71 filings, followed by tires (62) and service brakes, hydraulic:antilock/traction control/electronic limited slip (41). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 13 investigation files overlapping the 1992 EXPLORER, and 1 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
848
Complaints
54
Crashes
84
Fires
65
Injuries
4
Deaths
Crashes Reported
54 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
Above median complaint volume — review patterns below.
Complaints by Component
| Component | Count |
|---|---|
| TIRES:TREAD/BELT | 71 |
| TIRES | 62 |
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 41 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 41 |
| ENGINE AND ENGINE COOLING:ENGINE | 38 |
| SUSPENSION:FRONT | 34 |
| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | 21 |
| STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT | 20 |
| POWER TRAIN:MANUAL TRANSMISSION | 19 |
| SUSPENSION | 19 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | 18 |
| VISIBILITY:SUN/MOON ROOF ASSEMBLY | 18 |
| STRUCTURE:BODY:DOOR | 17 |
| EQUIPMENT:MECHANICAL:CARRIER/RACK | 17 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | 15 |
Recent Complaints
20150327FireFUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE REVERSING, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 444,980. UPDATED 5/18/15*CN THE REPAIR SHOP REPLACED THE FUEL VAPOR CANISTER. ALSO, THE VEHICLE WOULD NOT GO IN REVERSE. UPDATED 06/02/15*JB
Mileage: 444,980
20150327FirePOWER TRAIN
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE REVERSING, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 444,980. UPDATED 5/18/15*CN THE REPAIR SHOP REPLACED THE FUEL VAPOR CANISTER. ALSO, THE VEHICLE WOULD NOT GO IN REVERSE. UPDATED 06/02/15*JB
Mileage: 444,980
20150327FireENGINE
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE REVERSING, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 444,980. UPDATED 5/18/15*CN THE REPAIR SHOP REPLACED THE FUEL VAPOR CANISTER. ALSO, THE VEHICLE WOULD NOT GO IN REVERSE. UPDATED 06/02/15*JB
Mileage: 444,980
20131022FireELECTRICAL SYSTEM
MY CAR CAUGHT FIRE AT PARKING LOT WHEN I TRIED STARTING IT UP AFTER MY GIRLS AND I GOT BACK IN CAR AFTER BEING AT MALL FOR ABOUT 2 HOURS FLAMES COMING OUT FROM BOTTOM AND TOP OF ENGINE AND FRONT DASH. THANK GOD WE GOT OUT IN TIME. MY CARS ELECTRICAL WIRES FOR EVERYTHING IS MELTED AND IM UNSURE HOW MUCH MORE IS DAMAGED SINCE IM NOT A MECHANIC. *TR
20131022FireENGINE
MY CAR CAUGHT FIRE AT PARKING LOT WHEN I TRIED STARTING IT UP AFTER MY GIRLS AND I GOT BACK IN CAR AFTER BEING AT MALL FOR ABOUT 2 HOURS FLAMES COMING OUT FROM BOTTOM AND TOP OF ENGINE AND FRONT DASH. THANK GOD WE GOT OUT IN TIME. MY CARS ELECTRICAL WIRES FOR EVERYTHING IS MELTED AND IM UNSURE HOW MUCH MORE IS DAMAGED SINCE IM NOT A MECHANIC. *TR
20131022FireUNKNOWN OR OTHER
MY CAR CAUGHT FIRE AT PARKING LOT WHEN I TRIED STARTING IT UP AFTER MY GIRLS AND I GOT BACK IN CAR AFTER BEING AT MALL FOR ABOUT 2 HOURS FLAMES COMING OUT FROM BOTTOM AND TOP OF ENGINE AND FRONT DASH. THANK GOD WE GOT OUT IN TIME. MY CARS ELECTRICAL WIRES FOR EVERYTHING IS MELTED AND IM UNSURE HOW MUCH MORE IS DAMAGED SINCE IM NOT A MECHANIC. *TR
20130216SEAT BELTS
DRIVER'S SIDE SEAT BELT LATCH (FEMALE PIECE) DISENGAGED WHILE DRIVING. LATCH WILL NO LONGER STAY ENGAGED WITH THE MALE PART OF THE SEAT BELT IN A RELIABLE MANNER. *TR
Mileage: 250,000
20120727ENGINE
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT HE ATTEMPTED TO STOP THE VEHICLE, BUT THE VEHICLE CONTINUED TO ACCELERATE. THE CONTACT SLAMMED THE GEAR INTO PARK AND TURNED THE ENGINE OFF. UPON RESTART, THE VEHICLE FUNCTIONED AS NORMAL. THE CONTACT STATED THAT HE INSPECTED THE VEHICLE AND NOTICED THAT THERE WAS A PIECE OF PLASTIC IN THE HOSE THAT RAN FROM AIR FILTER TO THE AIR INTAKE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 102,000. UPDATED 08/28/12*LJ THE CONSUMER STATED THAT IT IS ALSO IMPORTANT TO NOTE THAT THE RUBBER RING UNDER THE C-CLAMP- THAT THE PLASTIC HOSE IS ATTACHED TO THE AIR-INTAKE WITH WAS THE REASON FOR THE MALFUNCTION. THE RUBBER CORRODED TO THE POINT THAT A PIECE OF IT BROKE OFF AND WAS SUCKED INTO THE ENGINE. THE ENTIRE HOSE HAD TO BE REPLACED BECAUSE THAT PART ISN'T SOLD SEPARATELY. UPDATED 09/05/2012 *JS
Mileage: 102,000
20120423WHEELS
I WAS TRAVELING DOWN HIGHWAY AND THE SPARE TIRE CABLE BROKE AND THE WHEEL FELL OUT AND GOT JAMMED UNDER THE EXPLORER. LUCKILY I SOME HOW WAS ABLE TO GET PULLED OVER BEFORE THEIR WAS AN ACCIDENT. AFTER THAT HAD HAPPEN I FOUND OUT THAT THEY HAD A RECALL ON THE CABLES DUE TO THEM BREAKING. *TR
Mileage: 126,135
20120423TIRES:TEMPORARY/EMERGENCY SPARE TIRE
I WAS TRAVELING DOWN HIGHWAY AND THE SPARE TIRE CABLE BROKE AND THE WHEEL FELL OUT AND GOT JAMMED UNDER THE EXPLORER. LUCKILY I SOME HOW WAS ABLE TO GET PULLED OVER BEFORE THEIR WAS AN ACCIDENT. AFTER THAT HAD HAPPEN I FOUND OUT THAT THEY HAD A RECALL ON THE CABLES DUE TO THEM BREAKING. *TR
Mileage: 126,135
20120423STRUCTURE:BODY
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THERE WERE NUMEROUS CRACKS NEAR THE REAR WINDSHIELD, NEXT TO THE MANUFACTURING EMBLEM.THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.
Mileage: 145,000
20120131SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES AT LOW SPEEDS, SHE NOTICED A GRINDING NOISE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE FRONT DRIVER AND PASSENGER SIDE BRAKES AND ROTORS NEEDED TO BE REPLACED. IN ADDITION, WHEN TURNING THE HEATER ON SHE COULD SMELL ANTI-FREEZE AND ALSO NOTICED A LEAK. THE INDEPENDENT MECHANIC ADVISED HER THAT THE HEATER COIL AS WELL AS THE BRAKE LINES NEEDED TO BE REPLACED DUE TO SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.
20120131ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES AT LOW SPEEDS, SHE NOTICED A GRINDING NOISE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE FRONT DRIVER AND PASSENGER SIDE BRAKES AND ROTORS NEEDED TO BE REPLACED. IN ADDITION, WHEN TURNING THE HEATER ON SHE COULD SMELL ANTI-FREEZE AND ALSO NOTICED A LEAK. THE INDEPENDENT MECHANIC ADVISED HER THAT THE HEATER COIL AS WELL AS THE BRAKE LINES NEEDED TO BE REPLACED DUE TO SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.
20110726SEAT BELTS
DRIVER'S SEAT BELT SOCKET NO LONGER LATCHES. FORD DEALER ADVISES REPLACEMENT IS DISCONTINUED. AFTER MARKET ALTERNATIVES NOT AVAILABLE. WITH "CLICKET OR TICKET" PROGRAMS IN PLACE VEHICLE BECOMES INOPERATIVE. *TR
Mileage: 170,000
20100520SERVICE BRAKES, HYDRAULIC:POWER ASSIST
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THE BRAKE PEDAL WOULD FEEL SPONGY WHEN DEPRESSED AND WOULD INCREASE STOPPING DISTANCE. THE VEHICLE PREVIOUSLY RECEIVED REPAIRS UNDER NHTSA RECALL CAMPAIGN ID NUMBER 96V024001 (SERVICE BRAKES, HYDRAULIC: POWER ASSIST: HYDRAULIC). THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED THAT THERE WAS A MISSING STUD AND NUT FROM THE MASTER CYLINDER. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS ALREADY REPAIRED UNDER THE RECALL CAMPAIGN AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 220,000.
Mileage: 220,000
20090902STEERING
TL*THE CONTACT OWNS A 1992 FORD EXPLORER XLT. THE CONTACT STATES WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A LOUD SQUEALING NOISE COMING FROM THE FRONT END OF THE VEHICLE . THERE WAS ALSO EXCESSIVE VIBRATION. THE DRIVER CONTINUED OPERATION WITH CAUTION. WHENEVER THE SPEED RATE WAS REDUCED THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 130,000.
Mileage: 130,000
20090902SUSPENSION:FRONT
TL*THE CONTACT OWNS A 1992 FORD EXPLORER XLT. THE CONTACT STATES WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A LOUD SQUEALING NOISE COMING FROM THE FRONT END OF THE VEHICLE . THERE WAS ALSO EXCESSIVE VIBRATION. THE DRIVER CONTINUED OPERATION WITH CAUTION. WHENEVER THE SPEED RATE WAS REDUCED THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 130,000.
Mileage: 130,000
20090513FireELECTRICAL SYSTEM
WENT TO FORD DEALER 3 MONTHS AGO ABOUT CHECK ENGINE LIGHT SAID OXYGEN SENSOR OR COLD WEATHER IT BE FINE ON MY WAY HOME SUNDAY IT HAD A BAD MISS THEN FIRE SHOT THROUGH MY FLOOR BOARD AND DASH ALL MY DOORS INSTANTLY LOCKED I BARELY MADE IT OUT OF MY VEHICLE IF WIFE AND CHILDREN HAD BEEN IN PROB WOULDN'T BE HERE AT THE SECOND I MADE IT OUT OF MY CAR I TURNED AND WATCHED THE STEERING WHEEL HIT THE SEAT I OWN I 1992 FORD EXPLORER I CAN BE REACHED I HAVE CONTACTED AN ATTORNEY LOCALLY. *TR
Mileage: 105,000
20080602STRUCTURE
TL*THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT THE RIGHT HYDRAULIC LIFT BRACKET DETACHED FROM THE VEHICLE. AS A RESULT, THE LIFT GATE FELL ON THE CONTACTS HEAD. THE CONTACT SUSTAINED BRUISES TO THE BACK OF THE HEAD. THERE IS A RECALL FOR THE STRUCTURE: BODY: HATCHBACK/LIFTGATE: SUPPORT DEVICE (NHTSA CAMPAIGN ID #95I007000) HOWEVER, THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED. THE CONTACT FELT THAT HIS VEHICLE SHOULD HAVE BEEN INCLUDED. THE FAILURE MILEAGE WAS 250,000 AND CURRENT MILEAGE WAS 255,000.
Mileage: 250,000
20080124STEERING: STEERING WHEEL/HANDLE BAR
A BLACK TAR-LIKE SUBSTANCE IS LEAKING OUT OF THE STEERING WHEEL. *TR
Compare 1992FORDEXPLORER to Similar Vehicles
NHTSA Investigations 1 Open
Frequently Asked Questions
How many complaints does the 1992 FORD EXPLORER have?▼
The 1992 FORD EXPLORER has 848 NHTSA complaints, 54 crashes, 84 fires, 65 injuries, and 4 deaths reported.
What are the most common problems with the 1992 FORD EXPLORER?▼
The most-complained component for the 1992 FORD EXPLORER is TIRES:TREAD/BELT with 71 complaints. Other frequently reported areas include TIRES and SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP.
Is the 1992 FORD EXPLORER safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.