Total Complaints
8 filings
BMW Z4 · model year
2020 BMW Z4
8 NHTSA complaints, 3 crash reports, and 6 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2020BMWZ4 carries 8 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 3 crashes, 0 fires, 0 injuries, and 0 fatalities. For crash performance, NHTSA's New Car Assessment Program gave this cohort an overall Not Rated/5 rating, with Not Rated/5 front crash, Not Rated/5 side crash, and Not Rated/5 rollover scores derived from standardized barrier and dynamic tests.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2020 Z4 is steering with 2 filings, followed by service brakes (2) and structure:body (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 6 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 34 investigation files overlapping the 2020 Z4. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
8
Complaints
3
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
3 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
NHTSA NCAP overall: Not Rated/5 — Not rated
· Front: Not Rated/5
· Side: Not Rated/5
· Rollover: Not Rated/5
Complaints by Component
| Component | Count |
|---|---|
| STEERING | 2 |
| SERVICE BRAKES | 2 |
| STRUCTURE:BODY | 1 |
| ENGINE | 1 |
| SUSPENSION | 1 |
| ELECTRICAL SYSTEM | 1 |
Recalls (6)
19V85000027/11/2019
EXTERIOR LIGHTING:HEADLIGHTS
BMW of North America, LLC (BMW) is recalling certain 2020 Z4 M40i, Z4 sDrive30i, 330i and 330i xDrive vehicles as well as 2020 Toyota Supra vehicles. The headlight control units may fail causing a loss of one or both of the headlights.
19V68400027/09/2019
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Con
20V51600027/08/2020
EXTERIOR LIGHTING:HEADLIGHTS
BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflec
25V63600023/09/2025
ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
20V70000012/11/2020
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
BMW of North America, LLC (BMW) is recalling certain 2020-2021 Z4 and 2020-2021 Toyota Supra vehicles. The weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail.
21V59800002/08/2021
ENGINE
BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical
Recent Complaints
20260219ELECTRICAL SYSTEM
Engine starter safety recall came out in September 2025, with no remedy or parts existing for fixing it. 5 months later, and no timeframe is provided for a remedy. This is a major fire risk given the amount of rain now that could corrode the starter and lead to a fire.
20201126SERVICE BRAKES
DON'T KNOW WHAT IS CAUSING IT. THERE IS MAJOR SQUEAKING/WHINING/GRINDING NOISE IF EVEN A TINY BIT OF WATER GETS IN THERE AND LAST COUPLE DAYS AFTER THAT. AND WHEN YOU TURN THE STEERING WHEEL TO THE LEFT THE SQUEAKING/WHINING GETS LOUDER. AND WHEN DOES DO THIS THE SUSPENSION IF YOU HIT EVEN A SMALL BUMP WILL BOTTOM OUT AND MAKE GRINDING NOISES. BMW HAS LOOKED AT THE CAR COUPLE TIMES FIRST TIME THEY SAID THERE WAS RUST. SECOND TIME THEY COULDN'T FIND ANYTHING WRONG WITH IT.
Mileage: 3,000
20201126STEERING
DON'T KNOW WHAT IS CAUSING IT. THERE IS MAJOR SQUEAKING/WHINING/GRINDING NOISE IF EVEN A TINY BIT OF WATER GETS IN THERE AND LAST COUPLE DAYS AFTER THAT. AND WHEN YOU TURN THE STEERING WHEEL TO THE LEFT THE SQUEAKING/WHINING GETS LOUDER. AND WHEN DOES DO THIS THE SUSPENSION IF YOU HIT EVEN A SMALL BUMP WILL BOTTOM OUT AND MAKE GRINDING NOISES. BMW HAS LOOKED AT THE CAR COUPLE TIMES FIRST TIME THEY SAID THERE WAS RUST. SECOND TIME THEY COULDN'T FIND ANYTHING WRONG WITH IT.
Mileage: 3,000
20201126SUSPENSION
DON'T KNOW WHAT IS CAUSING IT. THERE IS MAJOR SQUEAKING/WHINING/GRINDING NOISE IF EVEN A TINY BIT OF WATER GETS IN THERE AND LAST COUPLE DAYS AFTER THAT. AND WHEN YOU TURN THE STEERING WHEEL TO THE LEFT THE SQUEAKING/WHINING GETS LOUDER. AND WHEN DOES DO THIS THE SUSPENSION IF YOU HIT EVEN A SMALL BUMP WILL BOTTOM OUT AND MAKE GRINDING NOISES. BMW HAS LOOKED AT THE CAR COUPLE TIMES FIRST TIME THEY SAID THERE WAS RUST. SECOND TIME THEY COULDN'T FIND ANYTHING WRONG WITH IT.
Mileage: 3,000
20201007CrashSTRUCTURE:BODY
WAS IN A DRIVE THRU ON 9/6/2020 WAITING OUR TURN. APPROX. 7 CARS IN FRONT OF US. AS WE ARE SLOWLY MOVING UP TO ORDER, CAR IN IDLE, FOOT ON BRAKE. AS WE ARE MOVING FORWARD, WHEN WE WERE UP TO 3 CARS, STILL IDLING AND FOOT ON BRAKE, THE CAR HAD FULLY ACCELERATED, BRAKE NOT HOLDING THE CAR, INCHING FORWARD DUE TO THE FORCE OF THE ACCELERATION. TRIED TO SHIFT INTO NEUTRAL, WENT INTO REVERSE. TRIED AGAIN TO SHIFT INTO NEUTRAL, WENT INTO DRIVE, STILL INCHING FORWARD, AT THIS TIME I PUSHED THE OFF BUTTON TO STOP THE CAR. RESULT OF COLLISION WITH THE VEHICLE IN FRONT OF US. WE HAVE PHOTOS BUT NOT ON THIS COMPUTER.
Mileage: 3,300
20201007CrashSERVICE BRAKES
WAS IN A DRIVE THRU ON 9/6/2020 WAITING OUR TURN. APPROX. 7 CARS IN FRONT OF US. AS WE ARE SLOWLY MOVING UP TO ORDER, CAR IN IDLE, FOOT ON BRAKE. AS WE ARE MOVING FORWARD, WHEN WE WERE UP TO 3 CARS, STILL IDLING AND FOOT ON BRAKE, THE CAR HAD FULLY ACCELERATED, BRAKE NOT HOLDING THE CAR, INCHING FORWARD DUE TO THE FORCE OF THE ACCELERATION. TRIED TO SHIFT INTO NEUTRAL, WENT INTO REVERSE. TRIED AGAIN TO SHIFT INTO NEUTRAL, WENT INTO DRIVE, STILL INCHING FORWARD, AT THIS TIME I PUSHED THE OFF BUTTON TO STOP THE CAR. RESULT OF COLLISION WITH THE VEHICLE IN FRONT OF US. WE HAVE PHOTOS BUT NOT ON THIS COMPUTER.
Mileage: 3,300
20201007CrashENGINE
WAS IN A DRIVE THRU ON 9/6/2020 WAITING OUR TURN. APPROX. 7 CARS IN FRONT OF US. AS WE ARE SLOWLY MOVING UP TO ORDER, CAR IN IDLE, FOOT ON BRAKE. AS WE ARE MOVING FORWARD, WHEN WE WERE UP TO 3 CARS, STILL IDLING AND FOOT ON BRAKE, THE CAR HAD FULLY ACCELERATED, BRAKE NOT HOLDING THE CAR, INCHING FORWARD DUE TO THE FORCE OF THE ACCELERATION. TRIED TO SHIFT INTO NEUTRAL, WENT INTO REVERSE. TRIED AGAIN TO SHIFT INTO NEUTRAL, WENT INTO DRIVE, STILL INCHING FORWARD, AT THIS TIME I PUSHED THE OFF BUTTON TO STOP THE CAR. RESULT OF COLLISION WITH THE VEHICLE IN FRONT OF US. WE HAVE PHOTOS BUT NOT ON THIS COMPUTER.
Mileage: 3,300
20191214STEERING
BMW'S LANE DEPARTURE SYSTEM ACTUALLY PULLS THE CAR'S STEERING LEFT OR RIGHT, AND COULD CAUSE THE CAR TO COLLIDE WITH ANOTHER VEHICLE OR RUN OFF THE ROAD. I EXPERIENCED THIS WHILE DRIVING ON THE FREEWAY IN SOUTHERN CALIFORNIA. THE LANE DEPARTURE SYSTEM ALMOST PULLED MY VEHICLE INTO THE ADJACENT LANE.
Mileage: 200
Compare 2020BMWZ4 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2020 BMW Z4 have?▼
The 2020 BMW Z4 has 8 NHTSA complaints, 3 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What is the safety rating for the 2020 BMW Z4?▼
The 2020 BMW Z4 received an overall NHTSA safety rating of Not Rated/5, front crash rating of Not Rated/5, side crash rating of Not Rated/5, and rollover rating of Not Rated/5.
Are there any recalls for the 2020 BMW Z4?▼
Yes, the 2020 BMW Z4 has 6 recall(s). The most common affected component is EXTERIOR LIGHTING:HEADLIGHTS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2020 BMW Z4?▼
The most-complained component for the 2020 BMW Z4 is STEERING with 2 complaints. Other frequently reported areas include SERVICE BRAKES and STRUCTURE:BODY.
Is the 2020 BMW Z4 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. The 2020 BMW Z4 has an NHTSA safety rating of Not Rated/5. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.