Total Complaints
9 filings
BMW Z3 · model year
2002 BMW Z3
9 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2002BMWZ3 carries 9 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2002 Z3 is air bags with 2 filings, followed by steering (2) and seat belts (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 34 investigation files overlapping the 2002 Z3. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
9
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| AIR BAGS | 2 |
| STEERING | 2 |
| SEAT BELTS | 1 |
| SERVICE BRAKES | 1 |
| ELECTRONIC STABILITY CONTROL (ESC) | 1 |
| ELECTRICAL SYSTEM | 1 |
| EXTERIOR LIGHTING | 1 |
Recalls (1)
06E02600023/03/2006
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D
Recent Complaints
20200718ELECTRICAL SYSTEM
WHEN HEADLIGHTS ARE TURNED ON THE LEFT BLINKERS STARTS BLINKING RAPIDLY AND IS VERY DIM SO NOT REALLY VISIBLE. WHEN HEADLIGHTS ARE OFF IT OPERATES NORMALLY. THIS HAPPENS WHEN STATIONARY AND WHEN MOVING. I HAVE SEEN A NUMBER OF SAME PROBLEMS REPORTED ON BMW FORUMS LIKE FOLLOWS: HTTPS://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=537810://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=537810
Mileage: 55,000
20200718EXTERIOR LIGHTING
WHEN HEADLIGHTS ARE TURNED ON THE LEFT BLINKERS STARTS BLINKING RAPIDLY AND IS VERY DIM SO NOT REALLY VISIBLE. WHEN HEADLIGHTS ARE OFF IT OPERATES NORMALLY. THIS HAPPENS WHEN STATIONARY AND WHEN MOVING. I HAVE SEEN A NUMBER OF SAME PROBLEMS REPORTED ON BMW FORUMS LIKE FOLLOWS: HTTPS://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=537810://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=537810
Mileage: 55,000
20191205AIR BAGS
AIR BAG FAULT LIGHT IS COMING IN AND OUT ON THE VEHICLE DISPLAY
Mileage: 69,000
20190928SERVICE BRAKES
2002BMW Z3. THE ABS/DSC SYSTEM MALFUNCTIONS AT SPEEDS ABOVE 40MPH. THE RIGHT FRONT BRAKE ENGAGES AND ABRUPTLY FORCES THE CAR TO PULL HARD RIGHT. THE ABS LIGHTS ON THE DISPLAY PANEL. NO BUMPS OR BAD ROAD CONDITIONS WERE EXPERIENCED PRIOR TO OR AT THE TIME THIS MALFUNCTION OCCURS. THIS IS A VERY SERIOUS SAFETY ISSUE ENDANGERING NOT ONLY THE DRIVER, BUT ALL VEHICLE DRIVERS IN PROXIMITY.
Mileage: 35,200
20190928ELECTRONIC STABILITY CONTROL (ESC)
2002BMW Z3. THE ABS/DSC SYSTEM MALFUNCTIONS AT SPEEDS ABOVE 40MPH. THE RIGHT FRONT BRAKE ENGAGES AND ABRUPTLY FORCES THE CAR TO PULL HARD RIGHT. THE ABS LIGHTS ON THE DISPLAY PANEL. NO BUMPS OR BAD ROAD CONDITIONS WERE EXPERIENCED PRIOR TO OR AT THE TIME THIS MALFUNCTION OCCURS. THIS IS A VERY SERIOUS SAFETY ISSUE ENDANGERING NOT ONLY THE DRIVER, BUT ALL VEHICLE DRIVERS IN PROXIMITY.
Mileage: 35,200
20190928STEERING
2002BMW Z3. THE ABS/DSC SYSTEM MALFUNCTIONS AT SPEEDS ABOVE 40MPH. THE RIGHT FRONT BRAKE ENGAGES AND ABRUPTLY FORCES THE CAR TO PULL HARD RIGHT. THE ABS LIGHTS ON THE DISPLAY PANEL. NO BUMPS OR BAD ROAD CONDITIONS WERE EXPERIENCED PRIOR TO OR AT THE TIME THIS MALFUNCTION OCCURS. THIS IS A VERY SERIOUS SAFETY ISSUE ENDANGERING NOT ONLY THE DRIVER, BUT ALL VEHICLE DRIVERS IN PROXIMITY.
Mileage: 35,200
20160809SEAT BELTS
SEEMS TO BE A KNOWN PROBLEM - SEAT-BELT GUIDE HAS BROKEN AS IT IS WARPED PLASTIC AND STOPPING SHORT CAN BREAK IT. IN AN ACCIDENT SEAT BELT COULD SLIP UP, OR IMPACT NECK AS IT IS NOT HELD INTO PLACE NEAR THE SEAT. DEALER WANTS $400 TO FIX WHAT SEEMS TO BE A DEFECT
Mileage: 46,000
20151221STEERING
TWO TIMES WE HAVE BEEN UNABLE TO DISENGAGE THE STEERING WHEEL LOCKED. WE HAVE HAD TO GET THE CAR TOWED TO DEALER FOR SERVICE. WE THOUGHT THAT THE FIRST TIME WAS A MISTAKE, THEN IT HAPPENED A SECOND TIME. NO MATTER HOW HARD WE TRIED, WE COULD NOT GET THE STEERING WHEEL UNLOCKED TO DRIVE THE CAR, EVEN THOUGH WE HAD THE KEY. THE VEHICLE WAS IN THE PARKING POSITION AND WE COULD NOT GET THE STEERING WHEEL TO MOVE. WE HAVE A AUTOMATIC TRANSMISSION WITH A KEY LOCK. WE WOULD PARK THE CAR IN THE PARKING LOT AND WHEN WE RETURNED, WE WOULD PUT THE KEY IN THE IGNITION TO START THE CAR, BUT THE STEERING WHEEL WOULD NOT MOVE. IT WAS COMPLETELY LOCKED. THE STEERING WHEEL WOULD NOT TURN EITHER LEFT OR RIGHT. THE CAR WOULD BE IN PARK WITH EVERYTHING OFF, AND NOTHING WOULD MOVE.
Mileage: 102,000
20081007AIR BAGS
PASSENGER AIR BAG FAILURE. PRESSURE SWITCH IN PASSENGER SEAT FAILED. HAS NOT BEEN REPAIRED. *TR
Mileage: 20,000
Compare 2002BMWZ3 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2002 BMW Z3 have?▼
The 2002 BMW Z3 has 9 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2002 BMW Z3?▼
Yes, the 2002 BMW Z3 has 1 recall(s). The most common affected component is EXTERIOR LIGHTING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2002 BMW Z3?▼
The most-complained component for the 2002 BMW Z3 is AIR BAGS with 2 complaints. Other frequently reported areas include STEERING and SEAT BELTS.
Is the 2002 BMW Z3 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.