2007 BMW R1200 GS ADVENTURE

EXTERIOR LIGHTING:TURN SIGNAL

BMW of North America, LLC (BMW) is recalling certain accessory turn signals manufactured for 2006-2017 R1200GS, 2007-2008 and 2010-2017 R1200GS Adventure, 2017 F700GS and F800GS, 2013-2017 F800GT, 2015-2016 F800R, 2014-2017 F800GS Adventure, 2014-2016 S1000R, 2015-2017 R1200R, 2016-2017 R1200RS, and

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-6

DESPITE A COMPLETED RECALL FOR THE FUEL PUMP FLANGE, CRACKS IN THE FUEL PUMP DEVELOPED AND LED TO THE FLANGE SNAPPING COMPLETELY INTO TWO PIECES WHILE UNDER PRESSURE. ON A TRIP FROM MEMPHIS TENNESSEE TO RICHMOND VIRGINIA, THE FLANGE BROKE INTO TWO PIECES AND SUBSEQUENTLY COVERED THE RIDER IN GASOLINE AND MADE CONTINUED TRAVEL AN IMPOSSIBILITY. IN ADDITION TO COVERING THE RIDER IN GASOLINE AND RISKING INJURY TO SKIN AND EYES, THE GASOLINE ALSO MADE ITS WAY ONTO THE FRONT TIRE, REDUCING TRACTION, AND ONTO THE FRONT EXHAUST HEADERS, RISKING A FIRE AND/OR EXPLOSION. THIS OCCURRED WHILE THE MOTORCYCLE WAS IN MOTION AT ROUGHLY 55 MPH AND PREDOMINATELY IN A STRAIGHT UP/DOWN POSITION. THE INCIDENT OCCURRED ON A STATE ROUTE OFF OF INTERSTATE 40 NEAR NASHVILLE TENNESSEE.

Mileage: 92,000

PRIOR RECALL CAMPAIGN 13V-617 FOR FAULTY FUEL PUMPS WAS PERFORMED IN 2014. FUEL PUMP HAS STARTED LEAKING IN THE EXACT SAME MANNER THAT TRIGGERED THE INITIAL RECALL. VEHICLE IS LEAKING FUEL FROM THE SAME PART.

Mileage: 100,000

THE FUEL PUMP FLANGE CRACKED AND FUEL SPRAYED ALL OVER ME COVERING THE MOTORCYCLE AND MYSELF WITH GASOLINE. THE MOTORCYCLE WAS IN MOTION AND I WAS NOT ABLE TO STOP IMMEDIATELY. I WAS DRIVING TO WORK ON A HIGHWAY AND A SIDE STREET. THE PART THAT CASUED THE ISSUE WAS A FUEL PUMP FLANGE. THIS PART WAS REPAIRED UNDER RECALL 13V-617 IN JULY OF 2015. THE RECALL FIX FAILED AND IS A SAFETY ISSUE.

Mileage: 15

PREMATURE ABS PUMP FAILURE, WHILE DIAGNOSING INOPERATIVE SPEEDOMETER TECHNICIAN FOUND THAT WHEEL SPEED SENSORS ARE GOOD AS ARE VEHICLE CONTROL UNITS CONNECTED TO ABS MODULATOR BUT THERE IS NO COMMUNICATION FROM THE ABS MODULATOR PUMP TO THE CONTROL UNITS, ABS UNIT TEST AS FAILED, TECHNICIAN RECOMMENDS REPLACE ABS PUMP/MODULATOR TO REGAIN ABS AND SPEEDOMETER FUNCTIONALITY AS WELL AS BRAKE LIGHT. BMW PART# 34517715109 ($1,911.99)

Mileage: 18,339

FIRST FINAL DRIVE FAILURE AT 51K, SECOND AT 71K, FINAL DRIVE SEAL AT 79K, THIRD FINAL DRIVE AT 85K, FOURTH FINAL DRIVE AT 93K. I HAVE PAID FOR THREE OF THEM, WITH THE LATEST COSTING $2600.00 DUE TO THE HOUSING BEING DAMAGED AND NONE AVAILABLE FROM BMW. ONLY OPTION WAS BUYING BRAND NEW FINAL DRIVE. COMPLAINED TO BMW SAN JOSE DEALER WHO CONTACTED REGIONAL GUY. THEIR SOLUTION WAS TO REFUND ME A THIRD OF THEIR COST OF THE FINAL DRIVE ONLY, A WHOPPING $462.19. CONTACTED BMW NA CUSTOMER SERVICE, WAS TOLD THAT THIS IS FINAL DECISION AND THEY WILL NOT BE DOING ANY MORE. *TR

Mileage: 93,000

"BRAKE FAILURE" WARNING LIGHT ILLUMINATED. DIAGNOSED BY DEALER AS FAILED ABS PUMP. ABS NOT FUNCTIONING UNTIL PUMP GETS REPLACED. *TR

Mileage: 30,000

FUEL PUMPS WERE FOUND CRACKED WITH BROKEN SEALS AND LEAKING DURING NORMAL SERVICE. *TR

Mileage: 89,000

ON TOP OF THE FUEL TANK OF A BMW R1200 GS ADVENTURE IS A PUMP WHERE THE FITTINGS CRACK FROM THE FACTORY SPRAYING GAS OVER THE RIDER AS YOU RIDE. ONE YOU STOP THE FUEL PUDDLES IN THE FUEL PUMP AREA AND DRIPS DOWN THE MOTORCYCLE TANK ONTO THE ENGINE AND A HOT EXHAUST. *JS

Mileage: 25,087

VIBRATION FELT WHICH WORSENED UNDER POWER AND DIMINISHED WHEN POWER WAS REDUCED. PULLED OFF THE ROAD AND NOTED SMOKE AND ODOR FROM FRONT DRIVE SHAFT U-JOINT AREA. *TR

Mileage: 38,400

GAS TANK CRACKING AT FUEL SENSOR ELECTRONICS. FUEL LEAK CAUSING FUEL TO POOL AT THE TOP OF THE TANK AND RUN DOWN THE TANK ONTO THE EXHAUST. *TR

Mileage: 29,253

AT THE SUGGESTION OF A FELLOW BMW MOTORCYCLE CLUB MEMBER, I INSPECTED THE FUEL LINE FITTINGS WHERE THEY ATTACHED TO THE FUEL PUMP. THERE WERE NUMEROUS CRACKS IN THE PLASTIC AROUND ONE OF THE FITTINGS. I WAS PREPARING FOR A SUMMER TRIP WITH A FRIEND WHO ALSO OWNS A R1200 GSA, SO I BOUGHT TWO CLAMPS (SAME KIND AS SOLD BY BEEMER BONEYARD) SO WE COULD AVOID A POTENTIAL FAILURE DURING THE TRIP. I AM DISAPPOINTED THAT BMW DID NOT TAKE RESPONSIBILITY FOR THIS OBVIOUS SAFETY HAZARD. I HAVE SEEN RECALLS FOR OTHER MOTORCYCLES FOR POTENTIALLY DEFECTIVE FUEL LINES, SO WHY IS THIS NOT ANY DIFFERENT? *TR

Mileage: 23,000

THE FUEL TANK FLANGES HAVE DEVELOPED CRACKS AND NOW GASOLINE LEAKS ONTO THE MOTOR WHILE DRIVING. THE MOTORCYCLE HAS FLANGES ON BOTH THE LEFT AND RIGHT SIDE, BOTH SIDES HAVE THE CRACKS AND THEY ARE IN THE SAME LOCATION. THE CRACKS EXTEND FROM WHERE THE GAS FITTINGS ARE ATTACHED.

Mileage: 21,000

NEW BMW MOTORCYCLE, 2007 GS ADV. FUEL GAUGE FAILED WITH IN WEEKS. REPAIRED TWICE. 3 MONTHS OUT OF WARRANTY, FAILED AGAIN. DISCOVERED BY RUNNING OUT OF GAS AWAY FROM HOME. REPORTED TO DEALER AND HE INDICATED BMW WOULD NOT FIX. HOWEVER, THIS ISSUE IS SO PROBLEMATIC THAT BMW HAS PUT A DIFFERENT SEND UNIT ON THE NEW BIKES. NOW THE MILEAGE AND MILES LEFT DO NOT WORK. *TR

Mileage: 20,100

TL*THE CONTACT OWNS SHINKO E705 TIRES, DOT# H67VKJE, SIZE 110/90/19 ON A 2007 BMW R1200GS ADVENTURE MOTORCYCLE. YOKOHAMA IS THE TIRE MANUFACTURER. THE DRIVER SIDE REAR TIRE HAS DEVELOPED CRACKS IN BETWEEN THE TIRE TREAD. THE TIRES HAVE NOT BEEN INSPECTED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 4300.

Mileage: 44,100

ON OCTOBER 3, 2009, WHILE RIDING MY 2007 BMW R1200GS ADVENTURE, THE ENGINE STOPPED WHILE I WAS DRIVING IN TRAFFIC ON A STATE HIGHWAY HEAR MY HOME FORCING ME TO PULL OFF ONTO A VERY NARROW SHOULDER (WESTERN NC, MOUNTAIN ROADS) AND STOP WITH TRAFFIC PASSING ME BY AT HIGHWAY SPEEDS APPROXIMATELY ONE FOOT FROM MY LEFT SIDE. THE MOTORCYCLE WOULD NOT RESTART FOR SEVERAL MINUTES. EVENTUALLY IT DID RESTART AND I WAS ABLE TO DRIVE APPROXIMATELY FIFTY YARDS BEFORE THE ENGINE AGAIN STOPPED. THIS ALLOWED ME TO GET TO A WIDER SECTION OF SHOULDER WHERE I WAS NOT AT SUCH GREAT RISK FROM TRAFFIC. THE SYMPTOMS INDICATED A LACK OF FUEL. I CHECKED THE QUANTITY OF FUEL IN THE TANK VISUALLY AND FOUND AMPLE FUEL (I HAD DRIVEN LESS THAN ONE HUNDRED MILES SINCE FILLING THE TANK, WELL WITHIN THE FUEL RANGE OF THE VEHICLE). AGAIN, AFTER APPROXIMATELY FIVE MINUTES I WAS ABLE TO RESTART THE ENGINE AND DRIVE APPROXIMATELY 50 YARDS. AFTER ANOTHER FEW MINUTES I WAS ABLE TO RESTART THE ENGINE AND DRIVE ABOUT

Mileage: 22,063

ON OCTOBER 3, 2009, WHILE RIDING MY 2007 BMW R1200GS ADVENTURE, THE ENGINE STOPPED WHILE I WAS DRIVING IN TRAFFIC ON A STATE HIGHWAY HEAR MY HOME FORCING ME TO PULL OFF ONTO A VERY NARROW SHOULDER (WESTERN NC, MOUNTAIN ROADS) AND STOP WITH TRAFFIC PASSING ME BY AT HIGHWAY SPEEDS APPROXIMATELY ONE FOOT FROM MY LEFT SIDE. THE MOTORCYCLE WOULD NOT RESTART FOR SEVERAL MINUTES. EVENTUALLY IT DID RESTART AND I WAS ABLE TO DRIVE APPROXIMATELY FIFTY YARDS BEFORE THE ENGINE AGAIN STOPPED. THIS ALLOWED ME TO GET TO A WIDER SECTION OF SHOULDER WHERE I WAS NOT AT SUCH GREAT RISK FROM TRAFFIC. THE SYMPTOMS INDICATED A LACK OF FUEL. I CHECKED THE QUANTITY OF FUEL IN THE TANK VISUALLY AND FOUND AMPLE FUEL (I HAD DRIVEN LESS THAN ONE HUNDRED MILES SINCE FILLING THE TANK, WELL WITHIN THE FUEL RANGE OF THE VEHICLE). AGAIN, AFTER APPROXIMATELY FIVE MINUTES I WAS ABLE TO RESTART THE ENGINE AND DRIVE APPROXIMATELY 50 YARDS. AFTER ANOTHER FEW MINUTES I WAS ABLE TO RESTART THE ENGINE AND DRIVE ABOUT

Mileage: 22,063

FUEL INDICATOR BAD FOR THE SECOND TIME IN 6 MONTHS. RAN OUT OF FUEL THE FIRST TIME WHEN IT SAID I HAD PLENTY. NOW IT SAYS ITS EMPTY WHEN ITS FULL. *TR

Mileage: 3,200