2016 BMW M4

POWER TRAIN:DRIVELINE:DRIVESHAFT

BMW of North America, LLC (BMW) is recalling certain model year 2015-2016 M3 Sedan vehicles manufactured May 30, 2015, to September 2, 2015, 2016 M4 Coupe vehicles manufactured July 3, 2015, to September 11, 2015, and 2015-2016 M4 Convertible vehicles manufactured May 29, 2015, to August 4, 2015. Th

POWER TRAIN:DRIVELINE:DRIVESHAFT

BMW of North America, LLC (BMW) is recalling certain 2016-2017 BMW M3 Sedans, 2016-2017 BMW M4 and M4 GTS Coupes and 2017 BMW M4 Convertible vehicles. The connection between the driveshaft and the flange may fail resulting in a loss of propulsion.

STRUCTURE:FRAME AND MEMBERS

BMW North America, LLC (BMW) is recalling certain model year 2016 BMW M2 Coupe vehicles, 2015-2017 M3 Sedan vehicles and 2015-2016 M4 Coupe and M4 Convertible vehicles. During servicing of the rear differential for a prior service action, the rear sub-frame bolts may have been reused instead of bei

The contact owns a 2016 BMW M4. The contact stated that under previous ownership, the vehicle was previously repaired under NHTSA Campaign: 15V782000 (Power Train) at a local dealer. The contact stated that two years later, the contact was unsure if the vehicle was included or repaired under NHTSA Campaign: 18V713000 (Power Train). The contact stated that while driving at 45 MPH, the vehicle shuddered abnormally. The vehicle was taken to an independent dealer, where it was diagnosed with an imbalanced drive shaft. The local dealer was not contacted. The vehicle was not repaired due to the costs. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.

Mileage: 97,000

Filled car with gas and drove home , came out 10 minutes later to a puddle of fuel under car , from the fuel tank on the rear driver side

Both front steering bearing carriers (knuckles) cracked... this is a well documented defect on the M4 GTS model that BMW has not addressed.

The car only has 500 miles. It is a show car not taken out of the garage. Went to change oil and inspection sticker. Found to have a bad front knuckle. It is cracked. Many forums on this. This car is limited and has very low miles by owners. This should not be occurring

THE BILLET ALUMINUM STEERING KNUCKLES/STEERING CARRIERS ARE CRACKED AT ONE OF TWO BOLT POINTS CAUSING A SIGNIFICANT SAFETY CONCERN. THIS IS A KNOWN MANUFACTURER DEFECT AND BMW SUBSEQUENTLY CHANGED THE DESIGN OF THE REPLACEMENT PART. THIS BILLET ALUMINUM PART IS SPECIFIC TO THE 2016 BMW M4 GTS, A LIMITED EDITION BMW M4. APPROXIMATELY 800 M4 GTS'S WERE EVER BUILT AND THESE PARTS ARE FAILING AT ALL MILEAGE VALUES. THIS ISSUE IS WELL DOCUMENTED ON BIMMERPOST.COM FROM SEVERAL OWNERS. BMW WILL NOT COVER THE COST TO REPLACE IF THE VEHICLE IS OUTSIDE OF THE WARRANTY, REGARDLESS OF THE MILEAGE; MINE HAS 6,500 MILES. IF THE SECOND BOLT FAILS, THE COMPONENT WILL NO LONGER BE ATTACHED TO THE STRUT AND CAUSE CATASTROPHIC DAMAGE TO THE VEHICLE, PERSONAL INJURY AND POTENTIALLY DEATH. I NOTIFIED BMW AND THEY DENIED THE CLAIM AFTER 4 WEEKS OF REVIEW WITHOUT ANY REASON.

Mileage: 6,500

THE BILLET ALUMINUM STEERING KNUCKLES/STEERING CARRIERS ARE CRACKED AT ONE OF TWO BOLT POINTS CAUSING A SIGNIFICANT SAFETY CONCERN. THIS IS A KNOWN MANUFACTURER DEFECT AND BMW SUBSEQUENTLY CHANGED THE DESIGN OF THE REPLACEMENT PART. THIS BILLET ALUMINUM PART IS SPECIFIC TO THE 2016 BMW M4 GTS, A LIMITED EDITION BMW M4. APPROXIMATELY 800 M4 GTS'S WERE EVER BUILT AND THESE PARTS ARE FAILING AT ALL MILEAGE VALUES. THIS ISSUE IS WELL DOCUMENTED ON BIMMERPOST.COM FROM SEVERAL OWNERS. BMW WILL NOT COVER THE COST TO REPLACE IF THE VEHICLE IS OUTSIDE OF THE WARRANTY, REGARDLESS OF THE MILEAGE; MINE HAS 6,500 MILES. IF THE SECOND BOLT FAILS, THE COMPONENT WILL NO LONGER BE ATTACHED TO THE STRUT AND CAUSE CATASTROPHIC DAMAGE TO THE VEHICLE, PERSONAL INJURY AND POTENTIALLY DEATH. I NOTIFIED BMW AND THEY DENIED THE CLAIM AFTER 4 WEEKS OF REVIEW WITHOUT ANY REASON.

Mileage: 6,500

DIAGNOSED WITH COOLING SYSTEM ISSUE, 2ND COOLING SYSTEM DRY/LOW OR LEAKING, TRANSMISSION ISSUE, CODE 537, POWER TRAIN ISSUE, CAR IS QUICK SHIFTING AND SKIPPING FROM 5TH TO 7TH GEAR WITH A BUZZING SOUND, AND WITHOUT A DROP IN POWER. THE CAR ONLY HAS 48,000 MILES. WE BOUGHT THIS CAR 5 MONTHS AGO FROM A MERCEDES BENZ DEALERSHIP IN TYLER, TEXAS. IT SHOWS ON THIS SIGHT THAT THERE'S 3 RECALLS.

Mileage: 48,000

DIAGNOSED WITH COOLING SYSTEM ISSUE, 2ND COOLING SYSTEM DRY/LOW OR LEAKING, TRANSMISSION ISSUE, CODE 537, POWER TRAIN ISSUE, CAR IS QUICK SHIFTING AND SKIPPING FROM 5TH TO 7TH GEAR WITH A BUZZING SOUND, AND WITHOUT A DROP IN POWER. THE CAR ONLY HAS 48,000 MILES. WE BOUGHT THIS CAR 5 MONTHS AGO FROM A MERCEDES BENZ DEALERSHIP IN TYLER, TEXAS. IT SHOWS ON THIS SIGHT THAT THERE'S 3 RECALLS.

Mileage: 48,000

DIAGNOSED WITH COOLING SYSTEM ISSUE, 2ND COOLING SYSTEM DRY/LOW OR LEAKING, TRANSMISSION ISSUE, CODE 537, POWER TRAIN ISSUE, CAR IS QUICK SHIFTING AND SKIPPING FROM 5TH TO 7TH GEAR WITH A BUZZING SOUND, AND WITHOUT A DROP IN POWER. THE CAR ONLY HAS 48,000 MILES. WE BOUGHT THIS CAR 5 MONTHS AGO FROM A MERCEDES BENZ DEALERSHIP IN TYLER, TEXAS. IT SHOWS ON THIS SIGHT THAT THERE'S 3 RECALLS.

Mileage: 48,000

THE CRANK HUB ON THIS VEHICLE CAN SPUN AND BRAKE INSIDE THE ENGINE WITHOUT ANY WARNING, IF THAT HAPPENS ON A HWY FOR EXAMPLE THE VEHICLE WILL COMPLETELY LOOSE POWER AND I CAN BE INVOLVED IN A ACCIDENT WHICH MAYBE FATAL.

Mileage: 33,000

CRANK HUB SPINS, ITS SOMETHING THAT BMW MANUFACTURE SHOULD RECALL AND FIX BECAUSE IT CAN DAMAGE YOUR WHOLE ENGINE.

BMW IS AWARE OF A CRACK DEVELOPING IN A FRONT SUSPENSION CARRIER (ONE EACH LOCATED ON BOTH THE DRIVER'S SIDE AND PASSENGER'S SIDE - TWO TOTAL). BMW HAD TO REPLACE MY PASSENGER SIDE CARRIER UNDER WARRANTY. WHEN I TOOK MY CAR IN FOR AN OIL CHANGE, THE SERVICE TECHNICIAN DETECTED A HAIRLINE CRACK AND ORDERED THE REPLACEMENT PART FROM GERMANY. I DID NOT ASK FOR THE PART TO BE INSPECTED; IT SEEMS THAT BMW HAS INSTRUCTED ITS SERVICE CENTERS TO INSPECT VEHICLES FOR THIS PARTICULAR FAILURE. I ASKED THE SERVICE CENTER TO PROACTIVELY REPLACE THE DRIVER'S SIDE CARRIER, TOO. THEY REFUSED TO DO SO. THE ISSUE WITH CRACKS DEVELOPING IN THE FRONT TWO CARRIERS IS WELL DOCUMENTED (SEE, FOR EXAMPLE: HTTPS://F80.BIMMERPOST.COM/FORUMS/SHOWTHREAD.PHP?T=1550724). I HAVE ATTACHED A COPY OF THE SERVICE RECORD SHOWING REPLACEMENT OF MY PASSENGER SIDE CARRIER. I HAVE ALSO ATTACHED TWO IMAGES SHOWING CRACKS ON THE PART FROM THE LINK PROVIDED ABOVE. I BELIEVE THAT BMW SHOULD BE REQUIRED TO REPLACE THE CARRIERS ON

Mileage: 1,837

CRANK HUB SPINS

CRANK HUB SPINS

MULTIPLE OWNERS WITH THE SAME PLATFORM ARE REPORTING HAVING ISSUES WITH THE HUB SPINNING AND BREAKING WE ALL FEEL LIKE THIS IS A MANUFACTURER DEFECT THAT NEEDS TO BE RECALLED

SPONTANEOUS CAR FIRE - JULY 16, 2018; 10:30PM - 2016 BMW M4 CONVERTIBLE THE CAR HAD ABOUT 22K MILES AT THE TIME OF THE FIRE AND WAS STILL UNDER MANUFACTURER'S CERTIFIED PRE-OWNED WARRANTY. IT HAD LAST BEEN SERVICED SIX MONTHS AGO AT 18,806 MILES FOR A REGULARLY SCHEDULED OIL CHANGE. THERE HAD NOT BEEN ANY ISSUES IN THE 10 MONTHS OF OWNERSHIP. WE WERE DRIVING FROM DENVER TOWARDS SALINA, KS ON I-70 ON OUR WAY TO OK TRAVELING 75-80MPH. THE CAR WAS DRIVING NORMALLY WITH NO WARNING LIGHTS. THE CRUISE CONTROL WAS ON, THE AC WAS ON HALF AND THE WINDOWS AND TOP WERE UP. IT WAS DARK AND THE HEADLIGHTS WERE ON. WITH NO WARNING, DARK NOXIOUS SMOKE STARTING POURING INTO THE CABIN, POSSIBLY THROUGH THE AC VENTS. THE SMOKE BURNED OUR EYES AND CAUSED US TO START COUGHING AND MADE IT DIFFICULT TO SEE AND BREATHE. BECAUSE IT WAS DARK OUT, WE COULDN'T IMMEDIATELY TELL WHERE THE SMOKE WAS COMING FROM. WE ROLLED THE WINDOWS DOWN, BUT THAT INCREASED THE AMOUNT OF SMOKE COMING INTO THE CABIN, SO WE

Mileage: 22,000

SPONTANEOUS CAR FIRE - JULY 16, 2018; 10:30PM - 2016 BMW M4 CONVERTIBLE THE CAR HAD ABOUT 22K MILES AT THE TIME OF THE FIRE AND WAS STILL UNDER MANUFACTURER'S CERTIFIED PRE-OWNED WARRANTY. IT HAD LAST BEEN SERVICED SIX MONTHS AGO AT 18,806 MILES FOR A REGULARLY SCHEDULED OIL CHANGE. THERE HAD NOT BEEN ANY ISSUES IN THE 10 MONTHS OF OWNERSHIP. WE WERE DRIVING FROM DENVER TOWARDS SALINA, KS ON I-70 ON OUR WAY TO OK TRAVELING 75-80MPH. THE CAR WAS DRIVING NORMALLY WITH NO WARNING LIGHTS. THE CRUISE CONTROL WAS ON, THE AC WAS ON HALF AND THE WINDOWS AND TOP WERE UP. IT WAS DARK AND THE HEADLIGHTS WERE ON. WITH NO WARNING, DARK NOXIOUS SMOKE STARTING POURING INTO THE CABIN, POSSIBLY THROUGH THE AC VENTS. THE SMOKE BURNED OUR EYES AND CAUSED US TO START COUGHING AND MADE IT DIFFICULT TO SEE AND BREATHE. BECAUSE IT WAS DARK OUT, WE COULDN'T IMMEDIATELY TELL WHERE THE SMOKE WAS COMING FROM. WE ROLLED THE WINDOWS DOWN, BUT THAT INCREASED THE AMOUNT OF SMOKE COMING INTO THE CABIN, SO WE

Mileage: 22,000

SPONTANEOUS CAR FIRE - JULY 16, 2018; 10:30PM - 2016 BMW M4 CONVERTIBLE THE CAR HAD ABOUT 22K MILES AT THE TIME OF THE FIRE AND WAS STILL UNDER MANUFACTURER'S CERTIFIED PRE-OWNED WARRANTY. IT HAD LAST BEEN SERVICED SIX MONTHS AGO AT 18,806 MILES FOR A REGULARLY SCHEDULED OIL CHANGE. THERE HAD NOT BEEN ANY ISSUES IN THE 10 MONTHS OF OWNERSHIP. WE WERE DRIVING FROM DENVER TOWARDS SALINA, KS ON I-70 ON OUR WAY TO OK TRAVELING 75-80MPH. THE CAR WAS DRIVING NORMALLY WITH NO WARNING LIGHTS. THE CRUISE CONTROL WAS ON, THE AC WAS ON HALF AND THE WINDOWS AND TOP WERE UP. IT WAS DARK AND THE HEADLIGHTS WERE ON. WITH NO WARNING, DARK NOXIOUS SMOKE STARTING POURING INTO THE CABIN, POSSIBLY THROUGH THE AC VENTS. THE SMOKE BURNED OUR EYES AND CAUSED US TO START COUGHING AND MADE IT DIFFICULT TO SEE AND BREATHE. BECAUSE IT WAS DARK OUT, WE COULDN'T IMMEDIATELY TELL WHERE THE SMOKE WAS COMING FROM. WE ROLLED THE WINDOWS DOWN, BUT THAT INCREASED THE AMOUNT OF SMOKE COMING INTO THE CABIN, SO WE

Mileage: 22,000

TL* THE CONTACT OWNS A 2016 BMW M4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V713000 (POWER TRAIN). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED BMW OF EL CAJON (720 EL CAJON BLVD, EL CAJON, CA 92020, (619) 442-8888) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2016 BMW M4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V713000 (POWER TRAIN). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NICK ALEXANDER BMW (6333 S ALAMEDA ST, LOS ANGELES, CA 90001, (323) 583-1901) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *DT*JB