2007 BMW K1200 GT

STEERING

BMW IS RECALLING 428 MY 2007 F800 S, F800 ST, R1200 R, K1200 S, K1200 R, K1200 R SPORT, AND K1200 GT MOTORCYCLES. IT IS POSSIBLE FOR THE COATING TO SEPARATE FROM THE INSIDE FACE OF THE STEERING DAMPER HOUSING. IF THIS HAPPENED, THE COATING COULD PARTIALLY CLOG THE OIL BORES WITHIN THE DAMPER.

ENGINE AND ENGINE COOLING

ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR B

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-6

SUSPENSION:REAR

BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.

I HAVE A 2007 K1200GT MOTORCYCLE, AN EARLY PRODUCTION MODEL, THAT HAS DEVELOPED A PROBLEM WITH THE ENGINE SPEED CONTROL - THE ENGINE EXPECTEDLY REVS UP AND DOWN (HUNTS). I DID AN INTERNET SEARCH AND FOUND BMW NORTH AMERICA SERVICE BULLETIN 13 003 07 (058), WHICH DESCRIBES THE EXACT PROBLEM WITH THE BIKE. THE SERVICE BULLETIN WAS INTENDED FOR THESE EARLY PRODUCTION BIKES. HOWEVER, THE ISSUE ONLY SURFACED RELATIVELY RECENT ON MY BIKE, WHICH IS NOW OUT OF WARRANTY EVEN THOUGH THERE WAS ONLY 12,000 MILES ON THE BIKE AT THE TIME. I TOOK THE BIKE INTO THE SAN FRANCISCO BMW DEALER AND THEY REFUSED TO COVER THE RECOMMENDED REPAIRS. THEN CONTACTED BMW NORTH AMERICA AND THEY HAVE ALSO REFUSED TO FIX THE ISSUE. THE ISSUE IS PARTICULARLY HAZARDOUS, AS THE BIKE WILL CUT OUT UNEXPECTEDLY AND/OR ACCELERATE DESPITE CLOSING THE THROTTLE, AS IS NECESSARY WHEN APPROACHING A CORNER. AS A SENIOR PRODUCT SAFETY ENGINEER WITH OVER 20 YEARS EXPERIENCE, I FIND THIS A SIGNIFICANT SAFETY ISSUE, AND AM SHOCKED

FUEL STRIP FAILURE FOR SECOND TIME AFTER BMW EXTENDED WARRANTY TO 12 YEARS AFTER ORIGINAL DATE OF PURCHASE. THIS IS A SAFETY ISSUE BECAUSE THE LOW FUEL LIGHT REMAINS ON CONSTANTLY. COULD CAUSE A CRASH IF THE MOTORCYCLE WERE TO RUN OUT OF FUEL.

Mileage: 42,000

FOR THE SECOND TIME THE ENING SHUT OFF COMPLETELY UNDER ACCELARATION. THE ELECTRONICS AND ENGINE WENT TOTALLY DEAD. HAD TO PULL OVER TO RESTART. THE BIKE WAS BEING SHIFTED FROM 1ST GEAR INTO SECOND WHEN IT DIED.

Mileage: 29,365

BRAKE LIGHT CAME ON AFTER ONLY 8000 MILES. MOTORCYCLE IS ADULT DRIVEN, LIGHTLY USED, REGULARLY MAINTAINED AND GARAGED. BMW CAN DO BETTER THAN THIS.

Mileage: 8,000

TL* THE CONTACT OWNS A 2007 BMW K1200 GT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH ATTEMPTING TO ENGAGE THE BRAKES IN ORDER TO AVOID A CRASH, THE BRAKE WARNING LIGHT ILLUMINATED AND THE ABS PUMP FAILED AND THE WHEELS LOCKED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. UPDATED 01/20/15*LJ UPDATED 06/9/2015 *JS

Mileage: 35,000

BRAKE LIGHT FAILURE LIGHT ON, OUT OF NOWHERE. HAPPENS TO TOO MANY BMW MOTORCYCLES. YOU LOOSE BRAKE SENSITIVITY AND ABS. *TR

Mileage: 25,000

TL* THE CONTACT OWNS A 2007 BMW K1200 GT MOTORCYCLE. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED, HE WAS ALERTED THAT THE ABS MODULE WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 18,176.

Mileage: 18,176

AFTER ABOUT AN HOUR OF RIDING THROTTLE WILL NOT SHUT OFF WHEN RETURNED. DEAD SPOTS AT LOW RPM AND ROUGH IDLE. THERE ARE THOUSANDS OF POOR BUYERS WITH THIS EXACT PROBLEM BUT STILL NO SERVICE BULLETIN? WILL SOMEONE GET KILLED FIRST? *TR

Mileage: 3,500

TL* THE CONTACT OWNS A 2007 BMW K1200GT MOTORCYCLE. THE CONTACT STATED THAT ALTHOUGH THERE WAS NOT A VISIBLE FUEL LEAK, HE DETECTED A FUEL LEAK AND TOOK THE VEHICLE TO A LOCAL MECHANIC. THE MECHANIC ADVISED THAT THE FAILURE WAS CONTRIBUTED TO THE FUEL PUMP ASSEMBLY. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000.

Mileage: 16,000

THE ABS MODULE FAILED ON THIS VEHICLE THE LOCAL DEALER HAS INDICATED SEVERAL OF THE SAME MODEL AND YEAR HAVE HAD THE MODULE FAIL SEVERAL INTERNET FORUMS INDICATE THIS IS A COMMON FAILURE AND THE QUANTITY OF FAILURES EXCEEDS 10% OF THE MODEL AND YEAR OF VEHICLE FAILURE. *TR

Mileage: 310,010

THE ABS MODULE FAILED ON THIS VEHICLE THE LOCAL DEALER HAS INDICATED SEVERAL OF THE SAME MODEL AND YEAR HAVE HAD THE MODULE FAIL SEVERAL INTERNET FORUMS INDICATE THIS IS A COMMON FAILURE AND THE QUANTITY OF FAILURES EXCEEDS 10% OF THE MODEL AND YEAR OF VEHICLE FAILURE. *TR

Mileage: 310,010

FUEL LINE CONNECTION FAILED CAUSING GAS TO SPILL ALL OVER THE INSIDE OF THE MOTORCYCLE AND ON THE GROUND. IN MY OPINION THIS COULD HAVE EASILY CAUSED A SERIOUS SAFETY ISSUE DUE TO A POSSIBLE GASOLINE FIRE. *KB

Mileage: 34,600

(NOTE: 2000 CHARACTERS IS TOO SHORT!) 2007 BMW K1200GT MOTORCYCLE 15,433 MILES EVENT DATE/PLACE: AUGUST 4, 2011; RIDING HOME FROM WORK (24 MILES). PRIMARY DEFECT: COMPLETE AND SUDDEN DRIVE DIFFERENTIAL OIL LOSS! (THIS ENDANGERED MY LIFE THROUGH POSSIBLE SUDDEN GEAR FAILURE--HENCE, LOST POWER TO DRIVE WHEEL; OIL COATED REAR TIRE, OIL SATURATED REAR BRAKE PADS.) SECONDARY DEFECT: MANUFACTURER PROVIDES NO WARNING OF THIS DESIGN FLAW--NEITHER AT POINT OF SALE OR IN MEAGER MAINTENANCE DATA. EXPECTATION IS THIS UNIT WILL EXCEED 100,000 MILES WITH OIL CHANGES EVERY 6,000 MILES. THIS IS A RELATIVELY NEW, $21,000 BIKE; 11 MONTHS BEYOND WARRANTY. I CHANGED OIL EVERY 3,000 JUST TO BE SAFE. (EVEN MY OLD TRUCK DIFFERENTIAL WITH 140,000 DOESN'T LEAK OIL--MUCH LESS SUFFERING A TOTAL LOSS OF LUBRICANT! NEVER MIND DRIVING A TRUCK IS A SIGNIFICANTLY LESS CHALLENGING TASK!) SOLUTION: RECALL THESE BIKES AND HAVE THE MANUFACTURER PROVIDE APPROPRIATE ENGINEERING REDESIGN--SUCH THAT ONLY 1 DI

Mileage: 15,433

THROTTLE STICKS ON MY BMW K1200GT MOTORCYCLE. VERY WELL KNOWN ISSUE. IN MY OPINION IT SHOULD BE A SAFETY RECALL FOR ALL OF THESE MOTORCYCLES. DOESN'T APPEAR THAT BMW HAS A FIX FOR IT. MINE HAS BEEN WORKED ON THREE TIMES UNDER WARRANTY AND STILL HAS THE SAME SYMPTOM. *TR

Mileage: 14,000

2007 BMW1200GT WITH 15,000 MILES RUNS GOOD HOWEVER ENGINE HAS STALLED FOUR TIMES IN ONE WEEK WHEN COMING TO STOP ' OCCURS WHILE GEARING DOWN FOR STOP AND WHEN SHIFTING UP. ONCE WHILE TURNING AND DOWNSHIFTING BETWEEN 3RD TO 2ND CUT OUT AND NEARLY LOST THE BIKE. SEARCHED WEB AND PROBLEM IS PERVASIVE -- WHEN WILL YOU ACT AND I WILL CONTACT CONGRESSMAN, SENATOR AND CALIFORNIA CONSUMER BUREAU. *TR

Mileage: 15,211

2007 BMW1200GT WITH 15,000 MILES RUNS GOOD HOWEVER ENGINE HAS STALLED FOUR TIMES IN ONE WEEK WHEN COMING TO STOP ' OCCURS WHILE GEARING DOWN FOR STOP AND WHEN SHIFTING UP. ONCE WHILE TURNING AND DOWNSHIFTING BETWEEN 3RD TO 2ND CUT OUT AND NEARLY LOST THE BIKE. SEARCHED WEB AND PROBLEM IS PERVASIVE -- WHEN WILL YOU ACT AND I WILL CONTACT CONGRESSMAN, SENATOR AND CALIFORNIA CONSUMER BUREAU. *TR

Mileage: 15,211

2007 BMW1200GT WITH 15,000 MILES RUNS GOOD HOWEVER ENGINE HAS STALLED FOUR TIMES IN ONE WEEK WHEN COMING TO STOP ' OCCURS WHILE GEARING DOWN FOR STOP AND WHEN SHIFTING UP. ONCE WHILE TURNING AND DOWNSHIFTING BETWEEN 3RD TO 2ND CUT OUT AND NEARLY LOST THE BIKE. SEARCHED WEB AND PROBLEM IS PERVASIVE -- WHEN WILL YOU ACT AND I WILL CONTACT CONGRESSMAN, SENATOR AND CALIFORNIA CONSUMER BUREAU. *TR

Mileage: 15,211

TL*THE CONTACT OWNS A 2007 BMW K1200 GT MOTORCYCLE. THE DRIVER STATED THAT HE WAS DRIVING 55 MPH WHEN HE BEGAN TO APPLY THE BRAKES AND HIS MOTORCYCLE STALLED. HE WAS ALMOST REAR ENDED BY ANOTHER VEHICLE. THE DRIVER ALSO STATED THAT THE FAILURE HAS OCCURRED A FEW TIMES SINCE HE PURCHASED THE MOTORCYCLE IN 2007. THE DEALER WAS CONTACTED. THE FAILURE MILEAGE WAS 15,000. THE CURRENT MILEAGE WAS 18,000. UPDATED 11/16/10. *LJ UPDATED 12/08/10. *LJ THE CONSUMER STATED AS OF NOVEMBER 20,2010 THE FAILURE CONTINUED TO OCCUR A FEW TIMES WHEN DECELERATING AND BRAKING. UPDATED 12/08/10

Mileage: 15,000

I OWN A 2007 K1200GT AND LIVE IN IL. TOOK MY BIKE FOR A LONG RIDE AND IN SANTA FE ON 9/7/09 BIKE STARTED TO GIVE ME PROBLEMS. WHEN PULLING TO STOP BIKE WENT DEAD, PRESS START WOULD NOT START, DID IT NUMBER OF TIMES. FINALLY GOT THE BIKE STARTED IT WOULD HESITATE. WHENEVER RPM'S WENT BELOW 2000 BIKE WOULD DIE. TOOK TO SANTA FE BMW, THEY RESET COMPUTER WENT ON MY WAY. RIDING HOME TO IL BIKE PROBLEM RECURRED. WHENEVER STOPPING BIKE WOULD DIE, IF SLOWING DOWN BIKE WOULD TURN OFF. WAS EXTREMELY TENSE AND DANGEROUS RIDE. TOOK BIKE INTO CYCLE WERKS OF BARRINGTON ON 9/12/09. TOLD THEM OF PROBLEM. THEY SAID THEY NEVER HEARD OF THAT. DID RESEARCH AND SAW ON 2 DIFFERENT FORUMS THAT THIS IS A HUGE PROBLEM WITH ALL BMW K BIKES AND THERE IS NO FIX. I GAVE THEM PAGES AND PAGES OF BACKUP WITH SCORES OF OTHER PEOPLE WHO HAVE THE SAME PROBLEM. THEY REPLACED AIRBOX AND HOSES, REPLACED COMPUTER, AND DID THE "FIX" BMW TOLD THEM TO DO. TOLD ME I COULD PICK UP THE BIKE BUT IT DOESN'T RUN THE SAME. TOLD TH

Mileage: 25,881

TL*THE CONTACT OWNS A 2007 BMW K1200 GT. THE CONTACT STATED THAT THE VEHICLE IDLES HIGHLY. THE RPM'S WILL REMAIN IN A HIGH POSITION FOR A LONG TIME WITHOUT ANY THROTTLE INPUT. THE ENGINE HAS ALSO STALLED AND COMPLETELY SHUT OFF WHILE TRAVELING BETWEEN 45-65 MPH. THE VEHICLE ALSO ACCELERATES AND DECELERATES VERY RAPIDLY, WHICH CAUSES AN UNSTABLE REAR OR FRONT RIDE, DEPENDING ON THE SPEED AT THE TIME. THE VEHICLE HAS BEEN INSPECTED NUMEROUS TIMES BY DIFFERENT DEALERS AND THEY RESET THE CPU; HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE IS STILL PRESENT AND THE VEHICLE IS NOT BEING USED. THE CONTACT BELIEVES THAT THE FAILURE IS DUE TO A MANUFACTURER DEFECT BECAUSE OTHERS WITH THE SAME VEHICLE ARE COMPLAINING ABOUT THE SAME DEFECT. THE FAILURE MILEAGE WAS 4,000 AND CURRENT MILEAGE WAS 14,000. UPDATED 2/5/09 *CN THE MOTORCYCLE DROPPED ON RIGHT SIDE FROM THE ENGINE STALLING AT SLOW SPEED TURN. THROTTLE BOGGED ON RIGHT TURN AND THEN STALLED. UPDATED 02/10/09. *JB

Mileage: 4,000