Total Complaints
32 filings
BMW 540I · model year
32 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2017BMW540I carries 32 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2017 540I is air bags with 5 filings, followed by electrical system (4) and seats (4). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 34 investigation files overlapping the 2017 540I. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
Total Complaints
32 filings
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
At or below the fleet median complaint volume.
| Component | Count |
|---|---|
| AIR BAGS | 5 |
| ELECTRICAL SYSTEM | 4 |
| SEATS | 4 |
| SEAT BELTS | 3 |
| SERVICE BRAKES | 2 |
| UNKNOWN OR OTHER | 2 |
| EXTERIOR LIGHTING | 2 |
| ENGINE | 2 |
| POWER TRAIN | 1 |
| AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER | 1 |
| AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION | 1 |
| STEERING | 1 |
| TIRES:SIDEWALL | 1 |
| BACK OVER PREVENTION: WARNINGS | 1 |
| FORWARD COLLISION AVOIDANCE: WARNINGS | 1 |
AIR BAGS
BMW of North America, LLC (BMW) is recalling certain 2017 530i, 530i xDrive, 540i and 540i xDrive and 2017-2018 530e xDrive vehicles. Prior exposure to excessive levels of humidity within the driver and passenger head air bag inflators may affect the proper deployment of the head air bags.
as per [XXX] RE: Recall 22V-xxx: Positive Crankcase Ventilation (PCV) Valve Heater â B11 01 22 This should be covered by BMW but they charges us and not refunding review charges below [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
as per [XXX] RE: Recall 22V-xxx: Positive Crankcase Ventilation (PCV) Valve Heater â B11 01 22 This should be covered by BMW but they charges us and not refunding review charges below [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving on highways when there is no car in front of me, my car suddenly warns me of collision and applies brakes automatically! This almost caused an accident with the cars behind me. They were about to collide with me from behind because my car was applying brakes automatically without my control. Please help me urgently.
While driving on highways when there is no car in front of me, my car suddenly warns me of collision and applies brakes automatically! This almost caused an accident with the cars behind me. They were about to collide with me from behind because my car was applying brakes automatically without my control. Please help me urgently.
While driving on highways when there is no car in front of me, my car suddenly warns me of collision and applies brakes automatically! This almost caused an accident with the cars behind me. They were about to collide with me from behind because my car was applying brakes automatically without my control. Please help me urgently.
Driver seat restraint module system malfunction.
Vehicle has severely poor quality coolant hoses made from poor quality material that cannot withstand the flow of pressure within the coolant system process. Leading to the hoses deteriorating from internal pressure thus causing the coolant hoses to leak. The coolant sensors only indicate low coolant levels when there is, 1 and 3/4 inches of coolant liquid left which is 70% lower than the minimum coolant line within the main coolant reservoir which can then lead to engine failure that could result into a vehicle accident or wreck causing injury or even death. This problem has been commonly known and reported throughout the BMW community for BMWâs with the Generation 1 & 2 B58 engine models. I have taken my vehicle to two local BMW Dealerships in my surrounding area and have been notified by those dealerships that the hoses have been tested and tried under extreme conditions and that the quality should not be pertaining to the coolant leak issue rather that the coolant leak issue is e
On G models of the bmw 5 series. Ac coil leaks r1234yf freon which causes safety issue due to the gas being exposed into the cabin of the car and to the atmosphere. Dealerships wants $5000-7000 for this repair as the whole dash needs to come out. This is almost a guaranteed failure and BMW has failed to recall for this fix. This issue arises usually at 50k-70k miles. There are no lights that come out everything will work but AC will not.
Daytime running lights are dim or discolored. SIB 63 04 was issued acknowledging the problem, however repairs are only covered under the new vehicle warranty. In most cases, the issue occurs after the new vehicle warranty has expired.
1. Airbag Light - Repaired on 9/18/23 ( cause : pass. front seat occupancy detection ) a. no explanation needed b. replaced by dealer c. warning chime and message on dash d. Labor and part cost $2380.93 2. Instrument Cluster - Repaired on 9/18/23 ( Blackout , loss of speedometer , fuel level , engine temp. directional indicator , etc. a. Cluster would blink ( on - off ) than total blackout. b. Labor and part cost $1905.28
1. Airbag Light - Repaired on 9/18/23 ( cause : pass. front seat occupancy detection ) a. no explanation needed b. replaced by dealer c. warning chime and message on dash d. Labor and part cost $2380.93 2. Instrument Cluster - Repaired on 9/18/23 ( Blackout , loss of speedometer , fuel level , engine temp. directional indicator , etc. a. Cluster would blink ( on - off ) than total blackout. b. Labor and part cost $1905.28
2017 BMW 540I. CONSUMER WRITES IN REGARD TO SIDEWALL ISSUES WITH PIRELLI RUN FLAT TIRES.
The steering wheel will not go to its set position. BMW Dealer Service ran tests and found that the steering column hall effect sensor is faulty and is integral to the steering column. They have mentioned that the steering wheel adjustment will stop functioning in the future. If the steering wheel column cant be adjusted, it seems to create risky driving conditions for the driver. The dealer has reproduced and confirmed the issue. There were no other symptoms or warning messages.
Daytime Running Lights on the driver's side are malfunctioning. Connection between headlight housing and the daytime running lights are melted. Dealer found faults stored for headlight malfunction. They recommended replacing headlighthousing and LED module. The dealer has reproduced and confirmed the issue.
Daytime Running Lights on the driver's side are malfunctioning. Connection between headlight housing and the daytime running lights are melted. Dealer found faults stored for headlight malfunction. They recommended replacing headlighthousing and LED module. The dealer has reproduced and confirmed the issue.
Passenger Restraint System error in BMW seems to be a common problem. This should be looked over for a recall issue.
Passenger Restraint System error in BMW seems to be a common problem. This should be looked over for a recall issue.
The passanger seat on this carâs seatbelt and airbags have malfioned numerous times. 3/2021 seat belt warning, seat matpad replaced 9/2022 air bag malfunction while driving with a passenger on highway. Once again seat matpad replaced. Car no longer in warranty $2500. It is extremely dangerous that this passanger seat keeps failing. What if I got into an accident on highway and malfunction happened right before accident? Many people on bmw post complaining about seat belt warning and air bag malfunction. You can contact BMW, from 2017 until now, the car has neen in shop 4 times with passenger seatbelt and now airbag malfunction warnings. All services done at bmw of bayshore. I have included invoices I kept on this malfunctioned passenger seat
The passanger seat on this carâs seatbelt and airbags have malfioned numerous times. 3/2021 seat belt warning, seat matpad replaced 9/2022 air bag malfunction while driving with a passenger on highway. Once again seat matpad replaced. Car no longer in warranty $2500. It is extremely dangerous that this passanger seat keeps failing. What if I got into an accident on highway and malfunction happened right before accident? Many people on bmw post complaining about seat belt warning and air bag malfunction. You can contact BMW, from 2017 until now, the car has neen in shop 4 times with passenger seatbelt and now airbag malfunction warnings. All services done at bmw of bayshore. I have included invoices I kept on this malfunctioned passenger seat
The passanger seat on this carâs seatbelt and airbags have malfioned numerous times. 3/2021 seat belt warning, seat matpad replaced 9/2022 air bag malfunction while driving with a passenger on highway. Once again seat matpad replaced. Car no longer in warranty $2500. It is extremely dangerous that this passanger seat keeps failing. What if I got into an accident on highway and malfunction happened right before accident? Many people on bmw post complaining about seat belt warning and air bag malfunction. You can contact BMW, from 2017 until now, the car has neen in shop 4 times with passenger seatbelt and now airbag malfunction warnings. All services done at bmw of bayshore. I have included invoices I kept on this malfunctioned passenger seat
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.