BMW 535I · model year

2012 BMW 535I

86 NHTSA complaints, and 1 active recall for this specific cohort.

NHTSA overall rating

5 / 5 ★

New Car Assessment Program

The 2012BMW535I carries 86 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 3 fires, 0 injuries, and 0 fatalities. For crash performance, NHTSA's New Car Assessment Program gave this cohort an overall 5/5 rating, with 4/5 front crash, 5/5 side crash, and 5/5 rollover scores derived from standardized barrier and dynamic tests.

Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2012 535I is fuel/propulsion system with 12 filings, followed by engine (11) and power train (10). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.

NHTSA currently has 34 investigation files overlapping the 2012 535I. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.

86
Complaints
0
Crashes
3
Fires
0
Injuries
0
Deaths
2012 BMW 535I — NHTSA crash-test profile NHTSA NCAP crash-test star ratings for the 2012 BMW 535I. Overall composite: 5.0 of 5 stars across 3 safety dimensions. Front CrashSide CrashRollover 5.0 NHTSA NCAP of 5 stars
  • Front Crash 4.0 ★
  • Side Crash 5.0 ★
  • Rollover 5.0 ★
NHTSA overall 5.0/5 stars, with front-crash, side-crash and rollover ratings from standardized NCAP barrier and dynamic tests.

Total Complaints

86 filings

Crashes Reported

0 reports

Source

NHTSA ODI

Federal complaints database

Complaints vs. fleet median (215)

At or below the fleet median complaint volume.

NHTSA NCAP overall: 5/5 — Top NCAP rating · Front: 4/5 · Side: 5/5 · Rollover: 5/5

Complaints by Component

ComponentCount
FUEL/PROPULSION SYSTEM12
ENGINE11
POWER TRAIN10
ELECTRICAL SYSTEM9
AIR BAGS5
STEERING4
EXTERIOR LIGHTING4
TIRES3
WHEELS3
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION3
SEATS3
SEAT BELTS3
FUEL SYSTEM, GASOLINE3
SUSPENSION2
SERVICE BRAKES2

Recalls (1)

16V74600017/10/2016

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran T

Recent Complaints

20251028ENGINE

BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malf

20251028POWER TRAIN

BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malf

20251028FUEL/PROPULSION SYSTEM

BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malf

20250322FireELECTRICAL SYSTEM

The car was parked overnight. In the morning around dusk , it spontaneously caught fire.

20250121AIR BAGS

UNKNOWN passenger restraint system malfunction message started coming.

20241023ENGINE AND ENGINE COOLING

The contact owns a 2012 BMW 535I. The contact stated while driving at approximately 65 MPH, the engine temperature and "Pull Over - Stop Vehicle" warning lights were illuminated. The contact pulled over and let the vehicle cool down and drove to an independent mechanic. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The mechanic advised the contact that there was an active recall, NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 127,000.

Mileage: 127,000

20241023ELECTRICAL SYSTEM

The contact owns a 2012 BMW 535I. The contact stated while driving at approximately 65 MPH, the engine temperature and "Pull Over - Stop Vehicle" warning lights were illuminated. The contact pulled over and let the vehicle cool down and drove to an independent mechanic. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The mechanic advised the contact that there was an active recall, NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 127,000.

Mileage: 127,000

20240821FUEL SYSTEM, GASOLINE

The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.

Mileage: 119,000

20240821ENGINE AND ENGINE COOLING

The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.

Mileage: 119,000

20240130ENGINE

Confirmed by a Certified BMW repair center. Failure of Vanos Camshaft Gear Bolts. Recall has been issued for all 5 series models (and beyond) up to 2011, but does not include 2012 (5 series,) as it should. The Recall needs to be extended to include 2012 - 5 series models as failure of these bolts will cause immediate engine failure and could result in catastrophic crash, especially if driving at high speeds. I have contacted BMW of North America and they will not extend the recall until formal complaints, such as this, are received. My Issue with the Vanos Camshaft Bolts is currently being repaired (out of pocket) and I will share my invoice once received.

20230213EXTERIOR LIGHTING

The headlights on the BMW 535 collect excessive amounts of condensation. If the condensation builds up, then the light does not function properly. The main safety concern is the malfunction of the turn signal. It will function in the rear of the vehicle but does not light up on the front in the affected headlight housing. Review of this problem on-line shows that this has occurred in many BMW vehicles and BMW also has issued a service bulletin for this problem (SI B63 05 16). As widespread as this problem is, I would think there would be a required recall for this service.

20220709EXTERIOR LIGHTING

The front lights - water gets in impact visibility. The only repair is to replace the entire unit which is $2k per light. There is not other options. The adaptive warning sign does not go away due to this water.

20220522ENGINE

While driving heard a loud noise and oil start pouring out the bottom of the car.. After getting my Vehicle looked at BMW dealership informed me that the drive shaft had broken and fell in the engine and caused a hole in the engine and damaging the oil pan also

20220522POWER TRAIN

While driving heard a loud noise and oil start pouring out the bottom of the car.. After getting my Vehicle looked at BMW dealership informed me that the drive shaft had broken and fell in the engine and caused a hole in the engine and damaging the oil pan also

20220421SEAT BELTS

Driver seatbelt fails to engage with latch. Latch does not positively lock when inserted. Safety risk is obvious and has rendered the car undrivable. This just happened and has not been inspected by dealer. I personally looked at it and compared with other belt points. to me, it looks like the small metal clip failed.

20211206POWER TRAIN

The contact owns a 2012 BMW 535I. The contact stated that while driving at 20 MPH, the vehicle stalled as the drivetrain malfunction warning message flashed on the instrument panel. The contact stated that the vehicle failed to start up after multiple attempts. The contact had a friend replace the battery; however, the failure persisted. The contact then had the vehicle towed to a dealer where they diagnosed the vehicle with a defective fuel pump. Upon investigation, the contact discovered NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline) which she linked to the failure. The manufacturer was notified and informed her that there were no recalls on the vehicle. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 90,000.

Mileage: 90,000

20211206FUEL SYSTEM, GASOLINE

The contact owns a 2012 BMW 535I. The contact stated that while driving at 20 MPH, the vehicle stalled as the drivetrain malfunction warning message flashed on the instrument panel. The contact stated that the vehicle failed to start up after multiple attempts. The contact had a friend replace the battery; however, the failure persisted. The contact then had the vehicle towed to a dealer where they diagnosed the vehicle with a defective fuel pump. Upon investigation, the contact discovered NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline) which she linked to the failure. The manufacturer was notified and informed her that there were no recalls on the vehicle. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 90,000.

Mileage: 90,000

20211101SEATS

Based on research it appears BMW has a long history of issues and even a recall on select years around the passenger seat sensor detector becoming faulty and impacting the ability of the air bags to deploy in a collision. This seems to a critical issue since it could result in serious injury to the passenger in the event of a collision.

20211101AIR BAGS

Based on research it appears BMW has a long history of issues and even a recall on select years around the passenger seat sensor detector becoming faulty and impacting the ability of the air bags to deploy in a collision. This seems to a critical issue since it could result in serious injury to the passenger in the event of a collision.

20210911ENGINE

While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500

Compare 2012BMW535I to Similar Vehicles

NHTSA Investigations

View all investigations

Frequently Asked Questions

How many complaints does the 2012 BMW 535I have?
The 2012 BMW 535I has 86 NHTSA complaints, 0 crashes, 3 fires, 0 injuries, and 0 deaths reported.
What is the safety rating for the 2012 BMW 535I?
The 2012 BMW 535I received an overall NHTSA safety rating of 5/5, front crash rating of 4/5, side crash rating of 5/5, and rollover rating of 5/5.
Are there any recalls for the 2012 BMW 535I?
Yes, the 2012 BMW 535I has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2012 BMW 535I?
The most-complained component for the 2012 BMW 535I is FUEL/PROPULSION SYSTEM with 12 complaints. Other frequently reported areas include ENGINE and POWER TRAIN.
Is the 2012 BMW 535I safe to buy?
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. The 2012 BMW 535I has an NHTSA safety rating of 5/5. Compare with other model years using the links above.
Where does this data come from?
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.

Vehicle Safety Guides

Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.