BMW 528I · model year

2016 BMW 528I

102 NHTSA complaints, 2 crash reports, and 4 active recalls for this specific cohort.

NHTSA overall rating

Not crash-tested

New Car Assessment Program

The 2016BMW528I carries 102 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 2 crashes, 8 fires, 4 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.

Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2016 528I is electrical system with 33 filings, followed by engine and engine cooling (26) and engine (16). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 4 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.

NHTSA currently has 34 investigation files overlapping the 2016 528I. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.

102
Complaints
2
Crashes
8
Fires
4
Injuries
0
Deaths

Total Complaints

102 filings

Crashes Reported

2 reports

Source

NHTSA ODI

Federal complaints database

Complaints vs. fleet median (215)

At or below the fleet median complaint volume.

Complaints by Component

ComponentCount
ELECTRICAL SYSTEM33
ENGINE AND ENGINE COOLING26
ENGINE16
AIR BAGS5
UNKNOWN OR OTHER5
SUSPENSION3
FUEL/PROPULSION SYSTEM3
POWER TRAIN3
VEHICLE SPEED CONTROL2
EXTERIOR LIGHTING2
SERVICE BRAKES1
STEERING1
WHEELS1
STRUCTURE:BODY1

Recalls (4)

15V71800030/10/2015

CHILD SEAT

BMW of North America, LLC (BMW) is recalling certain model year 2016 528i, 528i xDrive, 535i, 535i xDrive, 535d xDrive, M5, 550i, 550i xDrive, and 535d sedans. The affected vehicles have an inboard lower anchor for child restraints on the left rear seat that may have been bent downwards, preventing

16V91400020/12/2016

AIR BAGS

BMW of North America, LLC (BMW) is recalling certain model year 2017 BMW 640i, 640i xDrive, 650i, 650i xDrive, M6, 535i, 535i xDrive, 430i, 430i xDrive, 440i, 440i xDrive, M4, X1 sDrive28i, X1 xDrive28i, i3, i8, Rolls-Royce Dawn, Mini Clubman Cooper, Clubman Cooper S, Cooper All4, Cooper S All4, Min

16V74700017/10/2016

SEAT BELTS:FRONT:RETRACTOR

BMW of North America, LLC (BMW) is recalling certain model year 2016-2017 X1 sDrive28i, X1 xDrive28i, MINI Hardtop 4 Door Cooper, Mini Hardtop 4 Door Cooper S, MINI Cooper Clubman, and Cooper S Clubman, 2017 Rolls-Royce Ghost, and 2016 528i vehicles. The vehicle-sensitive locking mechanism of the s

24V60800013/08/2024

ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP

BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 201

Recent Complaints

20260209EXTERIOR LIGHTING

I have 2016 BMW 5 series car, for past two to three years headlights are getting condensation inside on colder months. Dealer is not able to fix the condensation, they are advising to replace the headlights. Some of my friends replaced OEM headlights, but after few years they are started condensation, it’s looked like defect from manufacturer, I had few Honda vehicles older than my BMW car, they never had any condensation complaints. It’s look like manufacturer used cheap materials causing condensation, it is causing low light at night times may lead to accidents. Please look at this issue and consider it as a safety issue and please recall these headlights. Dealer is asking $2500 + $500 labor to fix each headlight. All of my friends are having same problem, I bet other BMW car owners too. Please issue a recall on this safety issue.

20260127FireENGINE

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

20260127FireSTRUCTURE:BODY

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

20260127FireELECTRICAL SYSTEM

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

20251102FireELECTRICAL SYSTEM

My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.

20251102FireENGINE

My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.

20250912ENGINE

During initial cold starts there is blue smoke billowing from the exhaust for approx 20 seconds. The odor is horrible.

20250827ELECTRICAL SYSTEM

A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbu

20250827VEHICLE SPEED CONTROL

A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbu

20250827POWER TRAIN

A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbu

20250822EXTERIOR LIGHTING

My driver headlight is constantly getting moisture trapped in it. It’s been replaced twice and the seals were checked, but it keeps happening and shorting out my headlight. It’s $4000 to fix. Just had it replaced 1.5 weeks ago and it’s broken already. I took it to bmw the moment I noticed the moisture was back and they told me it was fine. This is a widespread problem and they are not fixing their product

20250821ENGINE

Multiple critical BMW engine components are manufactured from plastic, including the oil pan, coolant expansion tank, valve cover, and turbo inlet pipe. These parts are prone to premature failure from normal heat & stress, as confirmed by independent mechanics. Failures can cause sudden loss of oil or coolant, persistent oil leaks, overheating, loss of power, and roadside breakdowns. The use of plastic for an oil pan is concerning. Plastic cannot withstand impacts with common road hazards such as tire fragments, etc. Striking a retread at highway speed could easily crack the pan, dump all engine oil, and lead to catastrophic engine seizure, endangering people. In my case (2016 BMW 528i), several plastic components have already failed, including the oil pan, turbo inlet pipe, coolant expansion tank, valve cover, and multiple coil packs. While BMW considers coil pack replacement a normal maintenance item, there are widespread complaints of premature failures. Most of the heat-related pl

20250816ELECTRICAL SYSTEM

Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.

20250816ENGINE

Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.

20250816VEHICLE SPEED CONTROL

Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.

20250726ENGINE

Very often, when I change the gear to 'Drive' or 'Reverse' I get a message on the dashboard screen - "secure Vehicle against rolling" and the car DOES NOT move unless I shift the auto gear lever several times or sometimes shut off the engine to get back to normal driving. Once when I was in such a situation, no matter what I do, the error message would not go away and I had to call the tow truck to get home. And when tow truck person brought the car home, the problem fixed itself!! I only have 81000 miles on this car. It is a very serious safety issue as far as I am concerned. PLEASE HELP.

20250726POWER TRAIN

Very often, when I change the gear to 'Drive' or 'Reverse' I get a message on the dashboard screen - "secure Vehicle against rolling" and the car DOES NOT move unless I shift the auto gear lever several times or sometimes shut off the engine to get back to normal driving. Once when I was in such a situation, no matter what I do, the error message would not go away and I had to call the tow truck to get home. And when tow truck person brought the car home, the problem fixed itself!! I only have 81000 miles on this car. It is a very serious safety issue as far as I am concerned. PLEASE HELP.

20250723ENGINE AND ENGINE COOLING

The contact owns a 2016 BMW 528I. The contact stated that while the vehicle was parked and running, the contact became aware of an abnormal burning odor. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000. VIN tool confirms parts not available.

20250723ELECTRICAL SYSTEM

The contact owns a 2016 BMW 528I. The contact stated that while the vehicle was parked and running, the contact became aware of an abnormal burning odor. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000. VIN tool confirms parts not available.

20250721ENGINE AND ENGINE COOLING

The contact owns a 2016 BMW 528I. The contact stated that while her son was driving at undisclosed speeds, there was an abnormally loud knocking sound coming from the vehicle. The contact stated that there was coolant leaking from the vehicle. The contact was adding coolant to the coolant reservoir every other day. The contact stated that the vehicle was smoking and there was an abnormal rattling sound coming from the vehicle and the engine was overheating. The vehicle was inoperable. The coolant message was displayed. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not availa

Compare 2016BMW528I to Similar Vehicles

NHTSA Investigations

View all investigations

Frequently Asked Questions

How many complaints does the 2016 BMW 528I have?
The 2016 BMW 528I has 102 NHTSA complaints, 2 crashes, 8 fires, 4 injuries, and 0 deaths reported.
Are there any recalls for the 2016 BMW 528I?
Yes, the 2016 BMW 528I has 4 recall(s). The most common affected component is CHILD SEAT. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2016 BMW 528I?
The most-complained component for the 2016 BMW 528I is ELECTRICAL SYSTEM with 33 complaints. Other frequently reported areas include ENGINE AND ENGINE COOLING and ENGINE.
Is the 2016 BMW 528I safe to buy?
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.

Vehicle Safety Guides

Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.