Total Complaints
17 filings
BMW 528 · model year
1997 BMW 528
17 NHTSA complaints, 2 crash reports for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 1997BMW528 carries 17 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 2 crashes, 1 fire, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 1997 528 is engine and engine cooling:cooling system with 2 filings, followed by engine and engine cooling:cooling system:radiator assembly (2) and service brakes, hydraulic:antilock/traction control/electronic limited slip (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 34 investigation files overlapping the 1997 528. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
17
Complaints
2
Crashes
1
Fires
0
Injuries
0
Deaths
Crashes Reported
2 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 2 |
| ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY | 2 |
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 1 |
| AIR BAGS:FRONTAL | 1 |
| STEERING:HYDRAULIC POWER ASSIST SYSTEM | 1 |
| STRUCTURE:BODY:BUMPERS | 1 |
| SEAT BELTS:FRONT:ANCHORAGE | 1 |
| TIRES | 1 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC | 1 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | 1 |
| EXTERIOR LIGHTING:BACK UP LIGHTS | 1 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 1 |
| STEERING | 1 |
| ENGINE | 1 |
| ELECTRONIC STABILITY CONTROL (ESC) | 1 |
Recent Complaints
20150802STEERING
I BOUGHT THE 1997 BMW 528I OFF LEASE. IT WAS MY SECOND BMW. THE PRIOR BMW HAD VIRTUALLY NO PROBLEMS. I GUESS THE SECOND ONE HAD TO MAKE UP FOR THE FIRST ONE. IF I ONLY HAD A NICKLE FOR EVERY TIME I WISHED I HADN'T TRADED FOR THE SECOND ONE. 1. THE FIRST PROBLEM OCCURRED IMMEDIATELY, THE ENGINE OVERHEATED AND I HAD TO HAVE IT TOWED TO A BMW DEALERSHIP. THIS WAS TO HAPPEN SEVERAL TIMES OVER THE NEXT YEAR AND A HALF. WHENEVER I DROVE THE CAR I HAD TO KEEP ONE EYE ON THE ENGINE TEMPERATURE AT ALL TIMES (IT WOULD HEAT UP VERY FAST). THE BMW DEALERSHIP MECHANICS COULDN'T SOLVE THE PROBLEM EVEN THOUGH THEY CHARGED ME OVER $2,000. WELL, THAT AND A COUPLE OF BOLDFACE LIES ENDED MY RELATIONSHIP WITH THAT DEALERSHIP. 2. THE SECOND PROBLEM OCCURRED IN ROUGHLY THE SAME TIME FRAME. AS I WAS DRIVING ALONG ONE DAY THE STEERING WHEEL STARTED MOVING IN AND OUT REPETITIVELY AND WOULDN'T STOP ALONG WITH MY SEAT (IT HAD NOTHING TO DO WITH THE MEMORY SWITCHES IN THE DOOR). THIS OCCURRED SEVERAL TIMES ALSO
Mileage: 48,000
20150802ENGINE
I BOUGHT THE 1997 BMW 528I OFF LEASE. IT WAS MY SECOND BMW. THE PRIOR BMW HAD VIRTUALLY NO PROBLEMS. I GUESS THE SECOND ONE HAD TO MAKE UP FOR THE FIRST ONE. IF I ONLY HAD A NICKLE FOR EVERY TIME I WISHED I HADN'T TRADED FOR THE SECOND ONE. 1. THE FIRST PROBLEM OCCURRED IMMEDIATELY, THE ENGINE OVERHEATED AND I HAD TO HAVE IT TOWED TO A BMW DEALERSHIP. THIS WAS TO HAPPEN SEVERAL TIMES OVER THE NEXT YEAR AND A HALF. WHENEVER I DROVE THE CAR I HAD TO KEEP ONE EYE ON THE ENGINE TEMPERATURE AT ALL TIMES (IT WOULD HEAT UP VERY FAST). THE BMW DEALERSHIP MECHANICS COULDN'T SOLVE THE PROBLEM EVEN THOUGH THEY CHARGED ME OVER $2,000. WELL, THAT AND A COUPLE OF BOLDFACE LIES ENDED MY RELATIONSHIP WITH THAT DEALERSHIP. 2. THE SECOND PROBLEM OCCURRED IN ROUGHLY THE SAME TIME FRAME. AS I WAS DRIVING ALONG ONE DAY THE STEERING WHEEL STARTED MOVING IN AND OUT REPETITIVELY AND WOULDN'T STOP ALONG WITH MY SEAT (IT HAD NOTHING TO DO WITH THE MEMORY SWITCHES IN THE DOOR). THIS OCCURRED SEVERAL TIMES ALSO
Mileage: 48,000
20150802ELECTRONIC STABILITY CONTROL (ESC)
I BOUGHT THE 1997 BMW 528I OFF LEASE. IT WAS MY SECOND BMW. THE PRIOR BMW HAD VIRTUALLY NO PROBLEMS. I GUESS THE SECOND ONE HAD TO MAKE UP FOR THE FIRST ONE. IF I ONLY HAD A NICKLE FOR EVERY TIME I WISHED I HADN'T TRADED FOR THE SECOND ONE. 1. THE FIRST PROBLEM OCCURRED IMMEDIATELY, THE ENGINE OVERHEATED AND I HAD TO HAVE IT TOWED TO A BMW DEALERSHIP. THIS WAS TO HAPPEN SEVERAL TIMES OVER THE NEXT YEAR AND A HALF. WHENEVER I DROVE THE CAR I HAD TO KEEP ONE EYE ON THE ENGINE TEMPERATURE AT ALL TIMES (IT WOULD HEAT UP VERY FAST). THE BMW DEALERSHIP MECHANICS COULDN'T SOLVE THE PROBLEM EVEN THOUGH THEY CHARGED ME OVER $2,000. WELL, THAT AND A COUPLE OF BOLDFACE LIES ENDED MY RELATIONSHIP WITH THAT DEALERSHIP. 2. THE SECOND PROBLEM OCCURRED IN ROUGHLY THE SAME TIME FRAME. AS I WAS DRIVING ALONG ONE DAY THE STEERING WHEEL STARTED MOVING IN AND OUT REPETITIVELY AND WOULDN'T STOP ALONG WITH MY SEAT (IT HAD NOTHING TO DO WITH THE MEMORY SWITCHES IN THE DOOR). THIS OCCURRED SEVERAL TIMES ALSO
Mileage: 48,000
20060328POWER TRAIN:AUTOMATIC TRANSMISSION
DT*: THE CONTACT STATED WHILE DRIVING AT NO PARTICULAR SPEED, THE GEAR SHIFT INDICATOR DOWN SHIFTED INTO NEUTRAL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION ONLY. UPDATED 4/11/2006 - *NM
Mileage: 72,500
20020222ENGINE AND ENGINE COOLING:COOLING SYSTEM
ENGINE KEEPS OVERHEATING DUE TO A FAULTY WATER PUMP. DEALER HAS REPLACED WATER PUMP TWICE. *AK
20010718ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
ENGINE OVERHEATED SUDDENLY AT EXPRESSWAY SPEED. SUSPECT THERMASTAT OR WATER PUMP. CAUSED MAJOR ENGINE FAILURE, "MELTDOWN" OF RADIATOR ASSY. *AK
20010618FireEXTERIOR LIGHTING:BACK UP LIGHTS
THE THIRD/MIDDLE REAR BRAKE LIGHT HOUSING HAS MELTED DUE TO EXCESSIVE HEAT BUILD UP WHEN USING BRAKES FOR EXTENDED TIME PERIODS (E.G., WHEN STUCK IN VERY SLOW MOVING TRAFFIC). THIS HAS CAUSED THE RED LENSE TO MELT OVER THE BULB, THEREBY POSING A RISK OF FIRE AND PREVENTING THE CAR FROM BEING INSPECTED. I AM CONCERNED ABOUT USING THE CAR IN THIS CONDITION DUE TO THE RISK OF FIRE (I HAVE SMELLED THE BURNING PLASTIC). THE HOUSING AND LIGHTING ASSEMBLY ARE ALL ORIGINAL EQUIPMENT. THE DEALER HAS INDICATED THAT IT WILL NOT FIX THE SAFETY HAZARD EVEN THOUGH IT IS UNDER WARRANTY AND ALL ORIGINAL EQUIPMENT (AND IT WILL COST $550 FOR ME TO REPAIR IT). THIS DEFECT ALSO PERMITS WHITE LIGHT TO SHINE FROM THE BRAKE LIGHT ASSEMBLY, THEREBY POSING AN ADDITIONAL SAFETY ISSUE.*AK
20010118ENGINE AND ENGINE COOLING:COOLING SYSTEM
WHILE GETTING ROUTINE SERVICE CHECK THE SEVICE REPRESENTATIVE REPORTED THE CAR HAD RUN HOT. I HAD NOTICED NO PREVIOUS PROBLEMS, HOWEVER THEY SUGGESTED A WATER PUMP REPLACEMENT. I TEST DROVE THE CAR AND IT BEGAN TO OVERHEAT. I RETURNED TO THE DEALERSHIP AND SUGGESTED THE THERMOSTAT BE REPLACED FIRST. IT HAS BEEN ONE MONTH AND I HAVE NOT HAD ANY TEMPATURE PROBLEMS.
20010118ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
WHILE GETTING ROUTINE SERVICE CHECK THE SEVICE REPRESENTATIVE REPORTED THE CAR HAD RUN HOT. I HAD NOTICED NO PREVIOUS PROBLEMS, HOWEVER THEY SUGGESTED A WATER PUMP REPLACEMENT. I TEST DROVE THE CAR AND IT BEGAN TO OVERHEAT. I RETURNED TO THE DEALERSHIP AND SUGGESTED THE THERMOSTAT BE REPLACED FIRST. IT HAS BEEN ONE MONTH AND I HAVE NOT HAD ANY TEMPATURE PROBLEMS.
20000122SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
WHILE DRIVING BRAKE LIGHTS CAME ON. TOOK VEHICLE INTO THE DEALER, AND THEY ADVISED THE CONSUMER THAT FRONT AND BACK BRAKES AND ROTORS WERE BAD. VEHICLE ALSO DIDN'T PASS THE INSPECTION. DEALER WILL ONLY TAKE $200.00 OFF FOR SERVICE. CINSUMER SAID THAT THERE WAS ONLY 10,000 MILES ON THE CAR WHEN TAKEN IT INTO THE DEALER. *AK
19990805SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
ABS BRAKE LIGHT INDICATOR WENT ON, AND WAS TOLD BY DEALER THAT CONSUMER COULD DRIVE ANOTHER 200 MILES, ONLY DROVE ANOTHER 50 MILES AND NEEDED NEW FRONT AND BACK ROTORS.CONSUMER CONTACTED DEALER. *AK
19990509TIRES
IN JUST 32,000 MILES WE ARE NOW HAVING TO REPLACE ANOTHER SET OF TIRES. THE FIRST 2 WENT AT JUST 11.000 MILES AND EVERY 11,000 MILES LATER. IS THIS STANDARD? BMW SAYS YES! *AK( DOT NUMBER: TIRE SIZE: 2256015 )
19990217SEAT BELTS:FRONT:ANCHORAGE
WHILE DRIVING THE SEAT BELTS ARE NOT ADJUSTABLE, AND THE SEAT BELT COVERS ACROSS THE CONSUMER'S NECK. IN CAS OF AN ACCIDENT, THE SEAT BELTS MIGHT CAUSE SERIOUS INJURIES. *AK
19980610STRUCTURE:BODY:BUMPERS
BUMPER DEFECTIVE.
19970721STEERING:HYDRAULIC POWER ASSIST SYSTEM
WHILE PARKING HEARD A POPPING NOISE FROM LEFT FRONT AND STEERING WAS LOST. AFTER VEHICLE STAYED PARKED FOR A WHILE STEERING CAME BACK. DEALER NOT ABLE TO LOCATE PROBLEM. *AK
19961217CrashSERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
THE ABS BRAKES FAILED TO OPERATE WHEN APPLIED UPON SLOWING DOWN TO MAKE A TURN, CAUSING THE VEHICLE TO GO DOWN A 6 TO 8 FOOT HILL, HITTING A TREE AND THE AIR BAGS DID NOT DEPLOY. PLEASE DESCRIBE DETAILS.
19961217CrashAIR BAGS:FRONTAL
THE ABS BRAKES FAILED TO OPERATE WHEN APPLIED UPON SLOWING DOWN TO MAKE A TURN, CAUSING THE VEHICLE TO GO DOWN A 6 TO 8 FOOT HILL, HITTING A TREE AND THE AIR BAGS DID NOT DEPLOY. PLEASE DESCRIBE DETAILS.
Compare 1997BMW528 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 1997 BMW 528 have?▼
The 1997 BMW 528 has 17 NHTSA complaints, 2 crashes, 1 fires, 0 injuries, and 0 deaths reported.
What are the most common problems with the 1997 BMW 528?▼
The most-complained component for the 1997 BMW 528 is ENGINE AND ENGINE COOLING:COOLING SYSTEM with 2 complaints. Other frequently reported areas include ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY and SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP.
Is the 1997 BMW 528 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.