2002 BMW 325XI

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons,

EXTERIOR LIGHTING:TAIL LIGHTS

BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICL

SERVICE BRAKES, AIR:DISC:ROTOR

ON CERTAIN PASSENGER VEHICLES, A PROBLEM IN THE MANUFACTURING PROCESS OF THE REAR BRAKE ROTORS MAY HAVE RESULTED IN THE CREATION OF A CRACK WHERE THE BRAKE DISC AND THE PARKING BRAKE DRUM MEET. FURTHER CRACKING OF THE ROTOR COULD OCCUR DUE TO BRAKING TORQUE WHEN THE VEHICLE IS DRIVEN AND THE BRAKES

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PS

AIR BAGS

BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-200

AIR BAGS

BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causin

The contact owns a 2002 BMW 325XI. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 20V018000 (Air Bags). The contact stated that approximately 7-months after the repair, the air bag warning light illuminated. The contact took the vehicle back to the dealer where a diagnostic test showed that a wire from the A-pillar connector to side air bags had high resistance. The dealer stated that the repair was not covered under the recall. The contact was provided an estimate for the repair. The contact stated that several days later the air bag warning light disappeared without the repair being performed. The manufacturer was notified of the failure and referred her to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was 44,743.

Mileage: 44,743

IGNITION SELANIOD ISN'T WORKING. WHEN I TURN THE KEY TO START THE CAR, THE IGNITION THINKS THE CAR HAS STARTED, BUT THE ENGINE DOESN'T TURN OVER. IT TAKES MULTIPLE TRIES TO GET THE CAR TO START.

Mileage: 172,400

IGNITION SELANIOD ISN'T WORKING. WHEN I TURN THE KEY TO START THE CAR, THE IGNITION THINKS THE CAR HAS STARTED, BUT THE ENGINE DOESN'T TURN OVER. IT TAKES MULTIPLE TRIES TO GET THE CAR TO START.

Mileage: 172,400

IGNITION SELANIOD ISN'T WORKING. WHEN I TURN THE KEY TO START THE CAR, THE IGNITION THINKS THE CAR HAS STARTED, BUT THE ENGINE DOESN'T TURN OVER. IT TAKES MULTIPLE TRIES TO GET THE CAR TO START.

Mileage: 172,400

WHILE DRIVING OUR CAR THE DASH LIGHTS WILL COME ON AND THE CAR WILL LOOSE ALL POWER. WE HAVE TO PULL OVER AND TURN CAR OFF WAIT A MINUTE WITH KEY COMPLETELY OUT OF THE IGNITION AND RESTART THE CAR THEN ALL LIGHTS ARE OFF AND CAR IS COMPLETELY DRIVABLE. THIS HAPPENS MULTIPLE TIMES A DAY NO MATTER WHAT SPEED IS BEING DRIVEN. ALSO WITHIN THE SAME MONTH THE LOCKS WILL NOT UNLOCK WHEN CAR IS STOPPED AND SHUT OFF OR BY THE POWER BUTTON INSIDE THE CAR. AS WELL AS OUR 4 WAY INDICATOR WHICH IS ON SAME SWITCH AS THE POWER LOCK BUTTON NO LONGER WORKS.

Mileage: 160,000

WHILE DRIVING OUR CAR THE DASH LIGHTS WILL COME ON AND THE CAR WILL LOOSE ALL POWER. WE HAVE TO PULL OVER AND TURN CAR OFF WAIT A MINUTE WITH KEY COMPLETELY OUT OF THE IGNITION AND RESTART THE CAR THEN ALL LIGHTS ARE OFF AND CAR IS COMPLETELY DRIVABLE. THIS HAPPENS MULTIPLE TIMES A DAY NO MATTER WHAT SPEED IS BEING DRIVEN. ALSO WITHIN THE SAME MONTH THE LOCKS WILL NOT UNLOCK WHEN CAR IS STOPPED AND SHUT OFF OR BY THE POWER BUTTON INSIDE THE CAR. AS WELL AS OUR 4 WAY INDICATOR WHICH IS ON SAME SWITCH AS THE POWER LOCK BUTTON NO LONGER WORKS.

Mileage: 160,000

CAR WAS PARKED IN PRIVATE DRIVEWAY, 200 FEET FROM STREET, AND HAD NOT BEEN DRIVEN OR STARTED FOR 4 DAYS. AWOKE TO CAR COMPLETELY ENGULFED IN FLAMES. FIRE TRUCK NEEDED TO PUT OUT FIRE, AND TO PROTECT NEARBY HOUSE. FIRE INSPECTOR COULD NOT DETERMINE CAUSE OF FIRE, DUE TO EXTEND OF DAMAGE, THOUGH NO EVIDENCE OF VANDALISM. NO COMPREHENSIVE INSURANCE, SO CAR A COMPLETE WRITE OFF. SALVAGE YARD SAID THEY HAD NEVER SEEN A CAR SO COMPLETELY DESTROYED BY FIRE. BMW CONTACTED, AND COMPLETELY UNINTERESTED AND UNHELPFUL. HEARD ABOUT NHTSA COMPLAINT REPORTING IN ARTICLE ABOUT UNEXPLAINED BMW FIRES.

THE CAMSHAFT POSITIONING SENSOR A CIRCUIT INTERMITTENT CAN GO BAD LEADING THE ENGINE TO STOP WORKING ALL TOGETHER THIS COULD CAUSE A VERY SERIOUS ACCIDENT IF DRIVING ON THE ROAD

Mileage: 166,983

LOCKS OCCUPANTS IN CAR AND CANNOT ELECTRICALLY OR MECHANICALLY UNLOCK. MANY BMW OPERATORS HAVE REPORTED THIS PROBLEM ON INTERNET BUT NO RECALL EXISTS FOR DEALERSHIPS TO REPAIR/REPLACE. HAPPENS WHEN VEHICLE IS IN MOTION OR STATIONARY, ON A CITY STREET OR HIGHWAY, TURNING OR ANYTIME THE SYSTEM LOCKS THE DOORS TRAPPING OCCUPANTS

Mileage: 89,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR WITH THE DEALER. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE DEALER ONLY INDICATED THAT THE PARTS WERE ON A NATIONAL BACK ORDER, WHICH HAD BEEN LONGER THAN A YEAR. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 11/29/16*LJ THE CONSUMER STATED THE PART FINALLY ARRIVED AND THE VEHICLE WAS REPAIRED IN NOVEMBER 2016. UPDATED 12/14/16.*JB

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. WHILE DRIVING APPROXIMATELY 60 MPH, THE DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THE CONTACT SUSTAINED BURNS AND BRUISES ON THE LEFT ARM FROM THE AIR BAG. THE CONTACT DID NOT SEEK MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. PARTS DISTRIBUTION DISCONNECT.

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. THE VIN WAS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT.

PASSENGER SEAT AIR BAG MATT SENSOR FOR PASSENGER WEIGHT AND AIRBAG INFLATION RATE IS INOPERATIVE AND BROKEN.

FINAL STAGE UNIT (AKA BLOWER MOTOR RESISTOR) KEEPS FAILING AND SHORTING OUT INTERNALLY CAUSING ENGINE MALFUNCTIONS AND RELATED OBD2 WARNINGS AS WELL AS BATTERY DRAIN. I HAVE REPLACED THIS PART 5 TIMES AND 2 TIMES IN THE LAST 6 MONTHS.

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V3178000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PARTS WERE UNAVAILABLE TO PERFORM THE REPAIRS. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMED PARTS NOT AVAILABLE.

TAKATA RECALL. THE DRIVER SIDE AIR BAG MODULE HAS BEEN ON RECALL FOR OVER 5 MONTHS. THIS IS MY DAUGHTERS CAN AND SHE IS UNSAFE. IS THERE AN ESTIMATE WHEN THIS REPLACEMENT MODULES WILL BE AVAILABLE

TL* THE CONTACT OWNS A 2002 BMW 325XI. THE CONTACT STATED THAT WHILE SHIFTING FROM REVERSE TO DRIVE, THERE WAS A THREE SECOND DELAYED RESPONSE. THE VEHICLE ACCELERATED INDEPENDENTLY AND THE RPMS BEGAN TO INCREASE. THE FAILURE RECURRED ON FOUR SEPARATE OCCASIONS ONLY AFTER THE VEHICLE WAS STATIONARY FOR A SHORT PERIOD OF TIME. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Mileage: 160,000