2023 TOYOTA SIENNA HYBRID

SEATS:MID/REAR ASSEMBLY:RECLINER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Sienna Hybrid vehicles. The bolts for the seatbacks on the third-row seat assemblies may not be tightened properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard

The vehicle experienced water intrusion into the interior cabin shortly after delivery in 2023. The water intrusion affected electrical components related to the airbag and Supplemental Restraint System (SRS). The vehicle remains in my possession and is available for inspection upon request. Moisture exposure to airbag and SRS components presents a serious safety risk because these federally regulated systems may fail to deploy, deploy improperly, or deploy unexpectedly in the event of a collision, increasing the risk of injury or death. The issue was reported multiple times to authorized Toyota dealerships while the vehicle was under factory warranty, and repair attempts were made; however, the water intrusion and related safety concerns were not resolved. The manufacturer and its authorized dealers were made aware of the defect through repeated service visits and customer complaints. Warning indicators related to the airbag/SRS system appeared after the water intrusion occurred, and

While turning right at approximately 5–10 mph, the vehicle was struck on the front passenger side. The impact caused moderate intrusion of the passenger door, severe damage to the front-right corner of the vehicle, and damage to the dashboard. Despite the structural damage and intrusion into the occupant compartment, none of the airbags deployed, including driver frontal, passenger frontal, side torso, or curtain airbags. Both occupants were wearing seatbelts, which activated normally. The driver sustained a right-side rib fracture caused by seatbelt force, required ambulance transport to the emergency room, and continues to experience ongoing symptoms. A child passenger seated in the front passenger seat struck her head against the window, resulting in a brain concussion with symptoms including headache and dizziness, requiring emergency medical evaluation. No airbag warning lights were present before or after the crash. The vehicle is preserved in post-crash condition and is av

While turning right at approximately 5–10 mph, the vehicle was struck on the front passenger side. The impact caused moderate intrusion of the passenger door, severe damage to the front-right corner of the vehicle, and damage to the dashboard. Despite the structural damage and intrusion into the occupant compartment, none of the airbags deployed, including driver frontal, passenger frontal, side torso, or curtain airbags. Both occupants were wearing seatbelts, which activated normally. The driver sustained a right-side rib fracture caused by seatbelt force, required ambulance transport to the emergency room, and continues to experience ongoing symptoms. A child passenger seated in the front passenger seat struck her head against the window, resulting in a brain concussion with symptoms including headache and dizziness, requiring emergency medical evaluation. No airbag warning lights were present before or after the crash. The vehicle is preserved in post-crash condition and is av

While turning right at approximately 5–10 mph, the vehicle was struck on the front passenger side. The impact caused moderate intrusion of the passenger door, severe damage to the front-right corner of the vehicle, and damage to the dashboard. Despite the structural damage and intrusion into the occupant compartment, none of the airbags deployed, including driver frontal, passenger frontal, side torso, or curtain airbags. Both occupants were wearing seatbelts, which activated normally. The driver sustained a right-side rib fracture caused by seatbelt force, required ambulance transport to the emergency room, and continues to experience ongoing symptoms. A child passenger seated in the front passenger seat struck her head against the window, resulting in a brain concussion with symptoms including headache and dizziness, requiring emergency medical evaluation. No airbag warning lights were present before or after the crash. The vehicle is preserved in post-crash condition and is av

Brakes will intermittently lurch when coming to a stop with normal braking pressure. The lurch feels like the brakes have stopped working and the driver has to press harder on the brake to avoid rear ending the vehicle in front. Brake pedal feels normal the entire time. Dealership is unable to duplicate on a test drive since the issue is intermittent.

The contact owns a 2023 Toyota Sienna. The contact stated that while driving 65 MPH, there was a popping sound coming from the sunroof, and the contact discovered that the sunroof had shattered. Neither the dealer nor an independent mechanic was contacted. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 70,000.

Mileage: 70,000

The contact owns a 2023 Toyota Sienna. The contact stated that while driving, the fuel gauge indicated there was 121 miles of fuel available. The contact stated that within twenty miles, the fuel gauge indicated that the fuel tank was empty. The contact stated that when the gauge indicated 170 miles available, the fuel usage decreased quickly. In addition, the contact stated that the failure had occurred several times. The contact stated that the vehicle was purchased and modified for transporting the contact’s disabled son. The Freedom Motor company provided the modification requests. The contact stated that the vehicle was taken to the modification company several times, however no assistance was provided. The contact was advised to always keep the fuel tank full. The contact stated that it was very hot and dangerous to be driving a vehicle and running out of fuel while transporting her disabled son. The manufacturer was not made aware of the failure. The failure mileage was unknow

When I go to brake the brakes seem to malfunction and skip engagement. I’ve had acceleration happen in the vehicle when I brake. At one time this caused my speed to jump while braking, I went from 5 to 10 MPH. This now happens several times a week.

The contact owns a 2023 Toyota Sienna Hybrid. The contact stated while driving and depressing the brake pedal to come to a stop, the vehicle jolted. The vehicle was taken to the dealer, where the contact was informed that the vehicle was operating as designed. Additionally, the contact stated that upon starting the vehicle, the messages "Parking Brake Malfunction", "Parking Brake Unavailable" and "Door Ajar" were displayed. The gear shift indicator light and the parking brake warning light were illuminated. The vehicle was taken back to the dealer, where it was diagnosed that the main wiring harness underneath the gear shifter was corroded. The dealer informed the contact the wiring harness would be replaced at the contact's expense. The contact stated that the failure occurred because there was no protective shielding around the wiring harness. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for

Mileage: 44,242

The contact owns a 2023 Toyota Sienna Hybrid. The contact stated while driving and depressing the brake pedal to come to a stop, the vehicle jolted. The vehicle was taken to the dealer, where the contact was informed that the vehicle was operating as designed. Additionally, the contact stated that upon starting the vehicle, the messages "Parking Brake Malfunction", "Parking Brake Unavailable" and "Door Ajar" were displayed. The gear shift indicator light and the parking brake warning light were illuminated. The vehicle was taken back to the dealer, where it was diagnosed that the main wiring harness underneath the gear shifter was corroded. The dealer informed the contact the wiring harness would be replaced at the contact's expense. The contact stated that the failure occurred because there was no protective shielding around the wiring harness. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for

Mileage: 44,242

The contact owns a 2023 Toyota Sienna Hybrid. The contact stated while driving and depressing the brake pedal to come to a stop, the vehicle jolted. The vehicle was taken to the dealer, where the contact was informed that the vehicle was operating as designed. Additionally, the contact stated that upon starting the vehicle, the messages "Parking Brake Malfunction", "Parking Brake Unavailable" and "Door Ajar" were displayed. The gear shift indicator light and the parking brake warning light were illuminated. The vehicle was taken back to the dealer, where it was diagnosed that the main wiring harness underneath the gear shifter was corroded. The dealer informed the contact the wiring harness would be replaced at the contact's expense. The contact stated that the failure occurred because there was no protective shielding around the wiring harness. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for

Mileage: 44,242

The contact owns a 2023 Toyota Sienna Hybrid. The contact stated while driving at an undisclosed speed and turning the steering wheel there was an abnormal knocking sound coming from the vehicle. The contact stated that the sound came from the front and the rear of the vehicle. The vehicle was taken to the dealer twice; however, the contact was informed that the sound was due to normal wear and tear. In addition, the contact was informed that the vehicle was safe to drive. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to take the vehicle to another dealer for a second opinion. The failure mileage was approximately 52,200.

Mileage: 52,200

multiple times this has been an issue. I stepped on the break and the car essentially leaps forward typically when going up down or straight. In November 2024 it happened while going up a hill slowly and I bumped into the vehicle ahead of me. My vehicle had no damage, but the car in front of me had to get a new skid plate and my insurance doubled because of it. Since the incident in November 2024, my car has unintentionally accelerated intermittently. finally, April 2025 this happened my car started shaking jolted forward, engine revving, and then my check engine light came on then immediately contacted my local dealership and scheduled an appointment to get my car in. They have had my vehicle since then and have said it is not safe to give it back to me so I am currently driving a loaner vehicle.

multiple times this has been an issue. I stepped on the break and the car essentially leaps forward typically when going up down or straight. In November 2024 it happened while going up a hill slowly and I bumped into the vehicle ahead of me. My vehicle had no damage, but the car in front of me had to get a new skid plate and my insurance doubled because of it. Since the incident in November 2024, my car has unintentionally accelerated intermittently. finally, April 2025 this happened my car started shaking jolted forward, engine revving, and then my check engine light came on then immediately contacted my local dealership and scheduled an appointment to get my car in. They have had my vehicle since then and have said it is not safe to give it back to me so I am currently driving a loaner vehicle.

multiple times this has been an issue. I stepped on the break and the car essentially leaps forward typically when going up down or straight. In November 2024 it happened while going up a hill slowly and I bumped into the vehicle ahead of me. My vehicle had no damage, but the car in front of me had to get a new skid plate and my insurance doubled because of it. Since the incident in November 2024, my car has unintentionally accelerated intermittently. finally, April 2025 this happened my car started shaking jolted forward, engine revving, and then my check engine light came on then immediately contacted my local dealership and scheduled an appointment to get my car in. They have had my vehicle since then and have said it is not safe to give it back to me so I am currently driving a loaner vehicle.

The (PCS) Precollision System has been already set to LOW sensitivity, but every once in awhile when pulling in to oncoming traffic the vehicle would think there's still a car and just stalls for a few seconds (nonresponsive to acceleration pedal) leading to a dangerous occurrence where I could be hit by a vehicle because I've basically stopped in an active intersection. My vehicle is clean, so no dirt blocking the sensors, and I also own a 5th gen RAV4 without this issue.

The (PCS) Precollision System has been already set to LOW sensitivity, but every once in awhile when pulling in to oncoming traffic the vehicle would think there's still a car and just stalls for a few seconds (nonresponsive to acceleration pedal) leading to a dangerous occurrence where I could be hit by a vehicle because I've basically stopped in an active intersection. My vehicle is clean, so no dirt blocking the sensors, and I also own a 5th gen RAV4 without this issue.

The sunroof spontaneously exploded while in a closed position, not in use in any way, while driving in the rain on the highway. While driving at highway speed, a sudden “shotgun blast sound” occurred. The interior cover was closed. Wind noise became immediately apparent. Upon stopping to inspect, the exterior sunroof glass had shattered with the appearance it blew out from the inside, as the middle section was protruding upward. The sunroof has been used very minimally since purchasing the vehicle right at a year ago. There have been no issues with the sunroof. The vehicle is going to the dealership body shop in the next few days.

The brakes on my '23' Hybrid Toyota Sienna seem to have a sudden acceleration when braking at times. Typically, it happens when braking going down a hill or around a curve (at slower speeds) and sometimes when trying to come to a full stop. This has caused me to almost rear-end other vehicles on several occasions and has also caused me to go slightly beyond the stop sign, putting the nose of my car in the street. It is not reproducible at the dealership. It has happened since I drove it off the lot in July of 2023 and happens randomly and without warning. This is scary when you seem to be braking in plenty of time to keep safe distances and then you suddenly get propelled forward! It happens weekly and has happened weekly since purchase. In speaking with other owners, this sounds like a common issue.

intermittent brake issues, primarily characterized by a "brake release" sensation where the brakes momentarily disengage while slowing down, causing the vehicle to lurch forward unexpectedly, sometimes happening during turns or on uneven roads and downhills and even while stopping at any light or a normal road sometimes