2022 TOYOTA RAV4 PRIME

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Rav4, Rav4 Hybrid, and Rav4 Prime vehicles. The front passenger seat may have been assembled with interference between internal parts that may cause the Occupant Classification System (OCS) sensor to incorrectly detect the

ELECTRONIC STABILITY CONTROL (ESC):CONTROL MODULE:SOFTWARE

Toyota Engineering & Manufacturing (Toyota) is recalling certain 2022 Lexus LX 600, Lexus NX 350h, Lexus NX 450h+, Toytoa RAV4 Hybrid, 2021-2022 Lexus LS 500h, Toyota Mirai, RAV4 PRIME, Sienna, Venza, and 2020-2022 Toyota Highlander Hybrid vehicles. The Skid Control ECU software may not turn on the

ELECTRICAL SYSTEM:PROPULSION SYSTEM:DC/DC CONVERTER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2022 RAV4 Prime and 2022 Lexus NX450h+ plug-in hybrid electric (PHEV) vehicles. The electric current rectifying module contained within the DC-DC converter may have been damaged during production, which can result in an ele

The mechanized power liftgate— the rear door, the primary way to access the back of vehicle—fails to open & close as intended. A continuous beeping noise sounds due to the liftgate’s failure to fully open and close. We reported this issue to the dealer multiple times during 2025. The dealer refused to acknowledge or fix the problem.

The contact owns a 2022 Toyota Rav4 Prime. The contact stated that while driving approximately 50 MPH, there was a loud bang like a gunshot heard, and the sunroof shattered. The vehicle was pulled over to the side of the road, and the contact inspected the vehicle, but the contact was unable to determine the cause of the shattering of the sunroof glass. The vehicle was then taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 49,500.

Mileage: 49,500

The 12v battery keeps dying. The dealer has checked it multiple times and finally replaced it with a new one which has now died twice. The weather has not been freezing, car is garage, i don't leave anything on that would drain battery and I drive it several times a week. I have over 23,000 miles. It dies at worst time when I really need to go somewhere.

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground

I was slowly pulling (front end forward) into a parking space at a local retail store. Parking spots are perpendicular to building. There is a space about the width of a sidewalk that runs along the front of the building. As I was coming to a complete stop, the car suddenly accelerated on its own, crashed into the building and then stopped. The airbag did not deploy. The car is available for inspection. Both Toyota and Farmers Insurance have said they will pull data from the event logs. The unintended acceleration malfunction put me and others at severe risk. The storefront has a concrete and glass front which was damaged from the impact. If an employee or shopper had been in the area of the crash, they could have been severely injured. I suffered a contusion of the sternum and stiff neck and shoulders. The vehicle's event data has not yet been pulled and evaluated. There were no advance warning signals.

Driving at highway speed on US101 N with no other vehicles in sight (5:50 AM), moonroof exploded outward with the sound of a gunshot. Moonroof glass and interior cover were closed. Inside temperature was 72 ºF, exterior temperature was 63 ºF and clear, and the sun had not yet crested the mountains (not a large temperature differential). No warning lamps or other problems prior to event. Remaining glass is domed outward.

On Friday 4/26/24 at about 8 PM, I pulled vehicle into garage and suddenly was aware that vehicle was crashing into shelving against the garage wall in front of its usual stopping place. I recall application of brakes and believe that I put into reverse in order to stop progression/acceleration. After it stopped, I was able to get out of the vehicle and describe the incident to my husband who came out from the house, having heard the crash. The hood and front parts of the car were damaged and it is currently in the collision shop. The shelving unit was destroyed. I am concerned that an unintended acceleration took place and do not know the mechanism.

The contact owns a 2022 Toyota Rav4 Prime. The contact received notification of NHTSA Campaign Number: 23V478000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2022 Toyota Rav4 Prime. The contact received notification of NHTSA Campaign Number: 23V478000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle does not stop if one tire is going over a man hole cover, divit in the road, bump etc. It also skids forward when this happens and almost like jumps (as if anti-lock brakes where let loose and then pressed again) even if I am braking. This has been happening since the day I bought the car brand new off the lot. The traction control light also goes off. If I am going down a hill while this happens the car can jump forward multiple feet. This is a safety concern even if it is part of the hybrid system. Ive read that braking control is still available when this happens with a hybrid however, I lose braking power for a a second or two. Aka don't try to stop in Boston if there is any type of not-flat area of the road.. like a small bump or the car might JUMP forward and not stop while braking.

Remote Start Option, has been disabled by Dealer, reportedly in January of 2023. Car was purchased 3/10/23 from dealer and feature was working via a Remote Subscription App which was not Renewed on 9/23. As this App requires Internet Service and Cell Phone Coverage to Function, it was not reliable as Service is not available in rural areas. Also, the Owner Manuals do not describe that a Cell Phone App is required to Remote Start a car that is covered in Ice. During winter operation this feature may be required to warm the car to allow the doors and Electric Locks to operate during Ice Storms. Dealer requested to reinstate original Remote option and advised that a separate Remote costing $800.00 would be necessary. Dealer could not replicate the function as they have Wi-Fi, other than to confirm that the "App annual fee" is not current. No warning lights, or messages indicate that the Remote Start Function in not functioning. The car also dose not contain a Mechanical Lock oper

The contact owns a 2022 Toyota Rav4 Prime. The contact received notification of NHTSA Campaign Number: 23V478000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2022 Toyota Rav4 Prime. The contact received notification of NHTSA Campaign Number: 23V478000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Car was t-boned a intersection and passenger side airbags didn't deploy

I was driving on a highway going around 45 mph. The sun/moon roof exploded. I wasn't under anything that could have fallen, no cars were around and I did not see anything in the air. It was sunny, 67 degrees with a breeze. This happened on Sunday so no confirmation or inspection has occurred. No warning lamps or messages appeared either before or after it exploded. I do know that Rav4 Prime's will display messages when things break including windows as I was rear-ended and the car was telling me the windows were broken. I called state patrol and they said they didn't need to come out, insurance was emailed but again, Sunday. I took photos and a video of the broken sunroof.

I was driving on a highway going around 45 mph. The sun/moon roof exploded. I wasn't under anything that could have fallen, no cars were around and I did not see anything in the air. It was sunny, 67 degrees with a breeze. This happened on Sunday so no confirmation or inspection has occurred. No warning lamps or messages appeared either before or after it exploded. I do know that Rav4 Prime's will display messages when things break including windows as I was rear-ended and the car was telling me the windows were broken. I called state patrol and they said they didn't need to come out, insurance was emailed but again, Sunday. I took photos and a video of the broken sunroof.

The contact owns a 2022 Toyota RAV4 Prime. The contact stated while driving 55 MPH and exiting the highway, the vehicle would not slow down. The contact desperately pressed the brake pedal, but the vehicle would not slow down or come to a complete stop. The contact lost control of the vehicle and drove off the road into a pile of dirt where the vehicle come to a complete stop. The contact was unsure If any warning light illuminated, but the air bags did deploy. The contact injured his leg and sought medical attention. A police report was filed. The vehicle was towed to the dealer. The vehicle was not diagnosed. The manufacturer was not notified of the failure. The failure mileage was 8,000.

Mileage: 8,000

This happened to me today but I have also recently heard about another report of the same (facebook rav4 prime web page) I started the car, it had sufficient battery so was in ‘EV’ mode. I placed it in reverse with my foot on the brake pedal. I waited a couple seconds for one reason or another and with my foot still firmly on the brake pedal it started moving in reverse. I pushed the brake pedal extraordinarily hard and the car stopped after a few feet. No incident precipitated from this but I’m keenly aware of the potential. At the moment I can’t reproduce it.