2016 Toyota Rav4

TIRES

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015,

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for r

I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for r

I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for r

Air bags malfunction. There is a warning ⚠️ pop up message on my dashboard that says, Air bags malfunction contact manufacturer dealer. This is clearly a safety issue and it should be part of a recall or a recall needs to be started with this issue.

Odometer Fraud. The contact purchased a 2016 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was purchased from a private seller. At the time of the purchase, the mileage was 98,000. The vehicle was taken to an independent mechanic, and a Carfax report indicated that in November 2025, the mileage was reported at 170,000.

Mileage: 170,000

The contact owned a 2016 Toyota Rav4. The contact stated while driving 30-40 MPH and attempting to change lanes, the contact looked through the sideview mirrors and then looked forward. The contact noticed that the vehicle in front of the vehicle had stopped. The contact depressed the brake pedal, but the vehicle did not stop in time and rear-ended the other vehicle. The contact's dog was occupying the front passenger's side seat and was not wearing a seat belt. The contact stated that it was a fender-bender; however, the driver's side and passenger's side curtain air bags deployed in addition to the front air bags, causing the vehicle to be totaled. The contact stated that the front driver's side air bag deployed and hit the contact's face, and the contact's eyeglasses caused a bruise on the contact's eyebrow. The contact also sustained a bloody nose and soreness on the forehead. The contact sustained bruises from the shoulder to the elbow after being hit by the driver's side curtain

Mileage: 170,000

The contact owns a 2016 Toyota Rav4. The contact stated that the liftgate failed to properly close while pressing the electrical buttons on both the key fob and the two liftgate buttons located inside or outside the vehicle. The contact stated that the liftgate had to be closed manually to securely close the liftgate. The contact stated that after her daughter had loaded groceries inside vehicle, the liftgate failed to latch properly but was closed after several attempts. The vehicle was taken to the dealer, and the contact's daughter was informed that the hinges and liftgate needed to be replaced. The contact was provided with an estimate for the repair. The manufacturer was notified of the failure and provided the contact with a case number. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 108,000.

Mileage: 108,000

Rear seat belt passenger side would not unlatch, trapping the passenger. This was and is the only time we have ever used this seat belt.It took two people to help get her thru the upper part of seat belt,had to exit over the top of back seat passenger. This life saving mechanism was and is unsafe and could of caused death if in the event of accident with fire. We have Owned two other Toyota's. Never any other dangerous life threatening events. Our request is the right thing to do. Replace this inoperative major defective part at an authorized Toyota Dealership here in. Dayton Ohio? Do we need to report this to the Highway Safety Dept.? [XXX] & [XXX] . Please respond. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact leased a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) and requested to be removed from the recall distribution list because the contact no longer had the vehicle. The dealer and the manufacturer were contacted.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

UNKNOWN - UNABLE TO COMPLETE REPAIR IN VEHICLE’S CURRENT LOCATION. This car is currently being stored in England and requires shipment back to the United States per my lienholder and military orders. Because of the recall that is currently open, the government’s provided shipment service (Mildenhall VPC) refuses to ship the vehicle unless I can get this repair performed locally. I’ve contacted numerous Toyota dealerships regarding this recall, and none of them have been able to address the repair due to the car not being made within the country, lack of OEM parts, etc. I’ve been back in the United States for over a month now, and the car is being stored with my friend/power of attorney until I’m able to get some resolution to this situation. I’ve tried to ship it numerous times now and they are refusing to do so unless the repair can be performed (which isn’t possible) or it is cleared from the VIN’s recall notice.

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

The contact owns a 2016 Toyota Rav4. The contact received a notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owned a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list. The local dealer was not contacted; however, the manufacturer was contacted.

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the battery charge was reduced, and the vehicle would not immediately start and the vehicle occasionally stalled. The contact also stated that the battery was replaced on four occasions. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The failure mileage was 91,475. Parts distribution disconnect.

Mileage: 91,475

The contact owns a 2016 Toyota Rav4. The contact stated that the battery warning light was illuminated, and the battery was replaced at the local independent mechanic. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.

Mileage: 70,000

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Headlights and taillights are fogging/hazing up to where they dimmed out the lights when turned on making is somewhat difficult to see or others behind me to see me.