2006 TOYOTA RAV4

SUSPENSION:REAR

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develo

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vib

SEAT BELTS:REAR/OTHER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the

EQUIPMENT:OTHER:LABELS

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE S

SUSPENSION:REAR

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear t

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module

EQUIPMENT:OTHER:LABELS

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPA

SUSPENSION:REAR

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develo

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Priu

My 2006 Toyota RAV4 was supposedly repaired under the rear suspension arm recall (C0J / G0V), but the rear tie rod ends still have yellow stickers reading “this is a recalled part” and no epoxy on the bolts. A Toyota dealer refused to inspect the vehicle and relied solely on the VIN record. The car now rides roughly, and I believe additional suspension components have been damaged due to the unresolved recall. I am concerned for my safety and request NHTSA investigation.

For several months the 2006 Rav4 with only 118k miles had been experiencing intermittent failure of power steering while driving at speeds between 5-20mph. These failures resulted in the steering wheel to become extremely difficult if not impossible to turn while the car is driving. In each incident, this resulted in stopping the car and putting on emergency lights until we can safely turn off the car and hopefully the issue goes away several minutes later. This issue has proven to be very dangerous when in traffic with no place to pull over and with the steering tightening up, it is not even possible to pull over in most cases. Four different mechanical shops tried to replicate the issue and none were able to determine the root cause nor replicate it consistently. This issue has been happening more frequently now and the car cannot be taken out safely. As [XXX] drivers, this is not safe by any means and Toyota should consider this a critical safety recall and cover towing costs to mov

Rear subframe rusted out. I took it in because my car started sounding like the Titanic after it hit an iceberg. The mechanic described it as “a giant hole in the bottom of the car.” I read there were recalls on frames for other Toyotas, but we kept up with every recall on this vehicle and the subframe was never listed as an issue. I get a regular multipoint inspection at the Toyota dealership about every six months, and no one caught this. I was told it is not safe to drive, and will snap at any time. I am lucky I did not crash.

The vehicle is owned and operated in Costa Rica. I submitted the vehicle for the 4 incomplete recall items associated with its VIN. I was told by Grupo Purdy Toyota of Costa Rica that Manufacturer Recall Number G0V NHTSA Recall Number16V596 does not apply in Costa Rica and they declined to complete the recall remedy. Is this correct or should they be completing the recall remedy?

I notified Toyota of an issue with my car a couple years ago. One day I came out to find my car missing big portions of paint (it had been a windy night); all of the paint in the attached photos came off in a single night and day, which is not normal paint performance. I came to find out that other years for the same make and model had a recall program for "pearl white paint". The issue seemed to be affecting my vehicle too. With large portions of paint peeling freely of the body of my vehicle, it began to rust. Rust eroding the structure of a vehicle can make the car unsafe for drivers and passengers. In an accident situation, the structure of the vehicle may be compromised by the rust, leading to more severe harm to occupants. Additionally, if the roof of the car is compromised, moisture could leak into the interior systems and cabin space, leading to other hazards, with potentially severely harmful outcomes. Toyotas response to the photos, report from the dealership, and BBB co

The contact owned a 2006 Toyota Rav4. The contact stated that while his wife was driving at an undisclosed speed, she heard a scraping and shuddering sound at the hood of the vehicle. The contact then stated that another vehicle noticed a spark underneath the vehicle and notified his wife. The contact’s wife was able to veer the vehicle off the road and exit the vehicle when the hood of the vehicle started to inflame. No warning lights were illuminated. No injuries were sustained. No medical attention was required. The fire department was notified and extinguished the fire. A police report was filed. The vehicle was towed to a tow lot and deemed a total loss by the insurance company. The vehicle was not diagnosed or repaired. The dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 180,000.

Mileage: 180,000

Two days ago my car was driving perfectly on the highway. The oil pressure light turned on I turned off the highway immediately and put more oil in the car. At this point my car is consuming over a quart every week and I don't drive more than a couple of hundred miles every week. I've taken several longer trips with this car. I started the car back up after checking the oil level, started driving and the light didn't come back on. About 10 more miles down the road on the highway the oil pressure light the check engine light vsc light the four-wheel drive light appear. I go to an AutoZone and I get a code p0012. I've done lots of research and I've learned that this is all related to Toyota's well-known defective design and manufacturing of their engines. I have a 2az Fe engine. I bought this car with 125,000 miles on it in 2020. It now has about 154,000 mi on it. I didn't know that the oil consumption was extreme until this point of research. Now my car is making a rattling sound most

2006 Toyota Rav4 with 2.4 liter engine burning oil rapidly. Burning approximately 4 quarts of oil in 3,000 miles. Vehicle currently has 100,000 miles. Issue persists even though I maintain routine maintenance on the vehicle. Luckily no safety hazards have occurred yet, but there is a high risk for potential safety hazard. Vehicle has been inspected by 3 different mechanics. I have been told by 3 different mechanics that this is a common issue for cars with this year/engine. About 2,800 miles after high synthetic oil change the vehicle begins to sound like it is struggling to accelerate at low speeds and the check engine oil light will briefly turn on at random then go away. Light does not stay lit or continuously flicker.

The contact owns a 2006 Toyota Rav4. The contact stated that while making a right or left turn, there was a loud popping sound coming from the steering wheel. There was no warning light illuminated. Additionally, the contact stated that the popping noise was progressively louder while steering to make a turn. The vehicle was taken to a local dealer where it was diagnosed that the steering linkage needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 86,000.

Mileage: 86,000

While my son was driving me the vehicles steering wheel locked and he was unable to steer the vehicle. It caused us to go off the road down a steep hill and wreck. I’ve never had any problems with this vehicle so it was completely unexpected. If there had been anyone in our path we wouldn’t of been able to stop from hitting them. It has not been inspected but there are witnesses to the accident

Clunking noise when turning steering wheel right or left. Numerous complaints from 006 RAV 4 owners. Fear that my steering will fail and cause an accident or Death. The issue is a defective intermediate steering shaft. Toyota will not issue a recall and will only repair if vehicle is still under warranty. How many complaints, accidents, or deaths will it take for this manufacturer to do the right thing???

My Toyota RAV4 started smoking by the headlights last night while I was driving on the highway. I pulled over and opened the hood to see what was happening and it burst into flames. The car completely burned. Nothing left! I see on the internet that other people have had this happen. Please investigate.

excessive oil consumption 1 1/2 quart oil every 600 miles

The rear subframe in my '06 Toyota RAV4 has rusted through. This is a key structural part of the vehicle, all of the rear suspension components attach to this subframe, so it's concerning to see the integrity of the subframe completely compromised. The component has not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps or symptoms of the failure. I happened to be under the car checking out an issue with a heat shield when I happened to notice the frame condition.

This 2006 Rav4 engine is known for its massive oil consumption due to the faulty piston rings. Always kept oil in it and had regular changes because of this issue. Checked the oil 2 days prior to the engine failure, and all was well. Driving down the hwy going around 70mph, the engine started to lose power and sound funny (high rpm sounds with no power), so I took my foot off the gas and coasted for a few seconds. Down to 50mph, I hit the gas pedal, and then a loud BOOM happened and car shook. Smoke from the engine, and then all the dash lights came on. Lost all power. Looked under the engine and a piston had blown a hole through the bottom of it. Needs new engine now. Mechanic inspected it and they documented with a picture. Thankfully I was not injured as that could have caused a serious wreck, especially if there was someone behind me. I've read about these engines being blown regularly online. Even some before 100k miles. No warnings before this happened.

THIS COMPLAINT IS RELATED TO DISCOVERY SRX P215/70R16 COOPER TIRES WHICH WERE BOUGHT ON OCTOBER 23 2018. THESE TIRES ARE IDENTICAL TO RECALL 'NHTSA RECALL NO. - 19T-005 AFFECTING COOPER DISCOVERER' AND COOPER EVOLUTION' TIRES' ONLY THEY ARE THE 16 INCH TIRES. WE BELIEVE THAT THE 16 INCH TIRES SHOULD ALSO BE INCLUDED IN THIS RECALL. HERE ARE THE ISSUES THAT WE HAVE HAD WITH THESE TIRES: 1.10-23-18 PURCHASED DISCOVERY SRX P215/70R16 COOPER TIRES WITH ROAD HAZARD FROM BLAINS FARM & FLEET IN VERONA WI VEHICLE MILES 106292 2.10-28-18 REAR PASSENGER TIRE BLEW FOR NO REASON, CHANGED AND RETURNED TO BLAINS FOR REPLACEMENT (NO RECEIPT WAS GIVEN) 3.11-25-18 WHILE DRIVING HOME AND ROUNDING A CORNER, THE CAR VEERED INTO A CURVE AND DESTROYED THE FRONT PASSENGER TIRE, RIM, AND WHEEL COVERS ON BOTH WHEELS. REAR TIRE WAS ALSO REPLACED BECAUSE OF BULGE ON TIRE. WE PAID THE $770.46 BECAUSE WE THOUGHT IT WAS OUR FAULT BUT NOW ARE WONDERING IF THIS WAS A TIRE ISSUE TOO. MILEAGE 107274 4. 02/21/20

Mileage: 107,254

FOR SOME TIME THERE HAS BEEN AN INTERMITTENT PROBLEM WITH THE DASHBOARD LIGHTS COMING ON AND LOSS OF POWER STEERING. THE CAR HAS BEEN CHECKED BY MECHANICS, INCLUDING ONE AT A TOYOTA DEALERSHIP, BUT THE PROBLEM WAS NOT FOUND. I HAVE EXPERIENCED THE PROBLEM WITH THE CAR STATIONARY, BUT I BELIEVE MY SON SAID IT HAS HAPPENED TO HIM WHILE IN MOTION.

Mileage: 180,000

FOR SOME TIME THERE HAS BEEN AN INTERMITTENT PROBLEM WITH THE DASHBOARD LIGHTS COMING ON AND LOSS OF POWER STEERING. THE CAR HAS BEEN CHECKED BY MECHANICS, INCLUDING ONE AT A TOYOTA DEALERSHIP, BUT THE PROBLEM WAS NOT FOUND. I HAVE EXPERIENCED THE PROBLEM WITH THE CAR STATIONARY, BUT I BELIEVE MY SON SAID IT HAS HAPPENED TO HIM WHILE IN MOTION.

Mileage: 180,000

FOR SOME TIME THERE HAS BEEN AN INTERMITTENT PROBLEM WITH THE DASHBOARD LIGHTS COMING ON AND LOSS OF POWER STEERING. THE CAR HAS BEEN CHECKED BY MECHANICS, INCLUDING ONE AT A TOYOTA DEALERSHIP, BUT THE PROBLEM WAS NOT FOUND. I HAVE EXPERIENCED THE PROBLEM WITH THE CAR STATIONARY, BUT I BELIEVE MY SON SAID IT HAS HAPPENED TO HIM WHILE IN MOTION.

Mileage: 180,000

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS CONSUMING OIL AT AN EXCESSIVE RATE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT THE OIL WAS LEAKING AND EXCESSIVELY BURNING TO THE EXTENT THAT IT COULD CAUSE A POSSIBLE ENGINE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT A WARRANTY RELATED CAMPAIGN REGARDING THE ENGINE HAD BEEN ISSUED HOWEVER, THE TIME-FRAME WAS EXCEEDED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

Mileage: 82,000