2020 TOYOTA HIGHLANDER

STRUCTURE:BODY:BUMPERS

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2023 Highlander & Highlander Hybrid vehicles. During normal vehicle operation, minor impact to the front lower bumper cover may result in the cover coming loose or detaching.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short cir

FUEL SYSTEM, GASOLINE:DELIVERY

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Highlander vehicles equipped with a 3.5 L, V6 (2GR-FKS) gasoline engine. Due to an Engine Control Unit (ECU) programming error, fuel may not be correctly supplied to the engine while using the stop and restart feature.

AIR BAGS

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Highlander and Highlander hybrid vehicles. Incorrect seat trim covers on one or both of the front seats can prevent the seat-mounted side air bag from deploying properly.

Taken vehicle at least 6 times to dealer (Corwin Toyota), to enquire about the 23v-865 recall, and each time have been told the repair is not available. Most recently asked December 2025.

THE TRANSMISSION FAILED SUDDENLY.

Premature transmission failure. Vehicle had less than 100K miles. Took the vehicle in for an oil change before a long trip. Mentioned a "whine" during acceleration. Told us that the entire transmission would need to be replaced immediately at a cost of over $10,000. Made an appeal to Toyota to help with the cost of replacement and we were denied.

Our 2020 Highlander with 45,000 miles started making a whining noise when accelerating. After the Toyota garage looked at it we were told that we needed a full transmission replacement. No warning lights came on alerting of us of problem. We were also told by the service depart that they are not surprised there hasn’t been a recall due to how many transmissions they have replaced on these vehicles and especially this type of transmission. Upon researching this particular issue, It is a wide known issue with class action lawsuits. New transmissions are also only carrying a 1 year warranty. That is hardly a warranty on a costly repair. It will cost us out of pocket $8,000 for a vehicle that is meticulously maintained and with only 44,000 miles. These vehicles are still being sold putting myself, my family and many more Americans as risk.

I have experienced ongoing transmission problems, including but not limited to rough shifting, delayed acceleration, jerking while driving, and abnormal noises. These issues have significantly affected the safety, reliability, and drivability of my vehicle. This transmission failure significantly undermines Toyota’s long-standing reputation for reliability and has substantially reduced the value of my vehicle.

The contact owns a 2020 Toyota Highlander. The contact stated that while reversing, the rear-view camera screen displayed a black screen. The contact stated that the failure was persistent. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure. The contact referenced an unknown recall with a similar failure; however, the VIN was not associated. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 153,000.

Mileage: 153,000

Whine noise when you accelerate coming from the automatic transmission. Car is hesitant in shifting gears when needing to accelerate causing safety issues/concerns while driving due to the inconsistency. Toyota dealer as inspected the vehicle and recommended a transmission replacement. Dealer has filed a claim with Toyota to see if it will be covered or not. Total price of repair quoted from dealer was $8700.00. I am also being told there is a back order on parts related to the repair of the vehicle and that the amount of vehicles with this issue are increasing in numbers each day. I purchased this vehicle new in 2020 and have been the sole owner.

Transmission is presenting a high-pitched whining noise.

The sunroof suddenly exploded while stopped at a stoplight. Luckily I had the interior slide shut otherwise we would have been covered in glass.

While driving on the highway, our sunroof spontaneously exploded. We heard what sounded like a gunshot and found a giant hole in our sunroof glass.

The contact's wife owns a 2020 Toyota Highlander. The contact stated that soon after purchasing a new set of tires, the vehicle made an abnormal rattling sound upon acceleration. The vehicle was taken to a dealer for an oil change and tire rotation, and the contact was informed that no defect was found on the vehicle. As the failure persisted, the vehicle was taken back to the shop, where the tires were purchased. The contact was informed that there was no defect in the tires, and the failure might be related to the differentials of the vehicle. The vehicle was taken back to the dealer, where it was diagnosed with transmission failure. The manufacturer was then notified of the failure, and the contact was offered partial financial assistance towards the purchase of a new engine. The vehicle was not repaired. The failure mileage was approximately 55,000.

Mileage: 55,000

My 2020 Toyota Highlander Hybrid has a braking issue identified in Toyota Service Bulletin T-SB-0059-23, Hybrid Regenerative Brake Transition Feeling Improvement. When going downhill and applying the brake, the vehicle lurches forward temporarily as the braking system transitions from regenerative to hydraulic braking. The first time my vehicle did this, it was very alarming and I had to take additional measures to slow my vehicle as I was driving downhill. My vehicle frequently demonstrates this problem, however, I did not report it to my local Toyota dealer because I read in an online chat group that it was a characteristic of this vehicle. Although the TSB recommends a Reprogram of the Brake Actuator Assembly Control Module, the repair is only covered under the Toyota Basic Warranty which is in effect for 36 months or 36k miles, whichever occurs first. My vehicle is past the warranty limit, and because I did not report it to my dealer previously, this repair is not covered under the

My 2020 Highlander developed a whining or grinding noise consistent with the Technical Service Bulletin. I took it to a Toyota Dealership for diagnostic and they confirmed the whining and hissing sound. They said it would cost $9,000 to repair. I called Toyota to request a goodwill repair and they denied me. Toyota case number: 251229000423. The car does not feel safe to drive. We worry that at any moment the car could break down with our children inside. The problem was reproduced at a dealer and inspected. There were no warning lamps or messages, just the obvious sound coming from the transmission.

Shortly after the powertrain warranty expired, the automatic transmission in my 2020 Toyota Highlander began producing a loud whining/howling noise during normal driving. The noise appears to come from the transmission area and increases with vehicle speed. The issue was not present during the warranty period and began unexpectedly soon after expiration. The abnormal noise raises concerns about internal transmission failure and potential loss of drivability. This condition could pose a safety risk if the transmission were to fail while driving, especially at highway speeds or when merging into traffic. No warning lights or messages were displayed prior to or during the issue. The vehicle was inspected by a Toyota dealer, and the problem was confirmed to be related to the transmission.

Transmission stutters. Only has 32000 miles.

Transmission whines in low gear.

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V72000 (Structure). The vehicle was taken to the dealer; however, the contact was informed that the recall could not be performed due to a damaged bumper clip. In addition, the contact stated that the vehicle was taken to the dealer several times, however the recall repair was not performed. The manufacturer was made aware of the failure and a case was filed. The manufacturer denied performing the recall repair.

The rear hatch door will not close or open and just sit there.And dings, you have to manually close it and open it most times and it never fully sucks up and latches fully and it doesnt notify you on the hood display of the car , so when we were driving down the road, we heard loud hissing and road noise coming from the rear and come to find out the rear hatch had never fully closed or latched itself fully.And it hangs up constantly.

The rear hatch door will not close or open and just sit there.And dings, you have to manually close it and open it most times and it never fully sucks up and latches fully and it doesnt notify you on the hood display of the car , so when we were driving down the road, we heard loud hissing and road noise coming from the rear and come to find out the rear hatch had never fully closed or latched itself fully.And it hangs up constantly.

The rear hatch door will not close or open and just sit there.And dings, you have to manually close it and open it most times and it never fully sucks up and latches fully and it doesnt notify you on the hood display of the car , so when we were driving down the road, we heard loud hissing and road noise coming from the rear and come to find out the rear hatch had never fully closed or latched itself fully.And it hangs up constantly.