Total Complaints
4 filings
TOYOTA GR86 · model year
2024 TOYOTA GR86
4 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2024TOYOTAGR86 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. For crash performance, NHTSA's New Car Assessment Program gave this cohort an overall Not Rated/5 rating, with Not Rated/5 front crash, Not Rated/5 side crash, and Not Rated/5 rollover scores derived from standardized barrier and dynamic tests.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2024 GR86 is fuel/propulsion system with 3 filings, followed by engine (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 51 investigation files overlapping the 2024 GR86, and 1 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
NHTSA NCAP overall: Not Rated/5 — Not rated
· Front: Not Rated/5
· Side: Not Rated/5
· Rollover: Not Rated/5
Complaints by Component
| Component | Count |
|---|---|
| FUEL/PROPULSION SYSTEM | 3 |
| ENGINE | 1 |
Recalls (1)
24V54800023/07/2024
EQUIPMENT:OTHER:LABELS
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia
Recent Complaints
20250622FUEL/PROPULSION SYSTEM
There seems to be wear in the fuel lines under the hood. Possibly caused from rubbing against something.
20250616ENGINE
Myself and others online have noticed unusual wear on fuel lines located in the engine bay. There are 3 fuel lines on the right side of the engine bay to the right of the intake manifold that can become chafed. Because these are fuel lines I find the fact that they have wear to be very concerning and a potential fire hazard
20250616FUEL/PROPULSION SYSTEM
Myself and others online have noticed unusual wear on fuel lines located in the engine bay. There are 3 fuel lines on the right side of the engine bay to the right of the intake manifold that can become chafed. Because these are fuel lines I find the fact that they have wear to be very concerning and a potential fire hazard
20250615FUEL/PROPULSION SYSTEM
I discovered what appears to be severe rubbing on one of the fuel lines in my 2024 Toyota GR86. The car has just over 6,000 miles on it, and the rubbing is so severe that it has removed the printed writing on the line and smoothed out the hose to the point where it is flat. From what I can tell, the hose is rubbing against another fuel line, which must occur while the engine is running. Considering the car was manufactured in September 2024, I find this to be not only unacceptable but dangerous. If I had not caught this, it would have easily rubbed through and resulted in an engine fire, which could have resulted in the total loss of the vehicle. While reviewing my vehicle, I also noticed that a friend with a 2023 Subaru BRZ had the same issue. While his rubbing was not as severe, it is clear this is not an isolated incident and affects others. I am in the process of gathering photographic evidence from others who are impacted and so far know of at least two more cases beyond the abov
Compare 2024TOYOTAGR86 to Similar Vehicles
NHTSA Investigations 1 Open
Frequently Asked Questions
How many complaints does the 2024 TOYOTA GR86 have?▼
The 2024 TOYOTA GR86 has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What is the safety rating for the 2024 TOYOTA GR86?▼
The 2024 TOYOTA GR86 received an overall NHTSA safety rating of Not Rated/5, front crash rating of Not Rated/5, side crash rating of Not Rated/5, and rollover rating of Not Rated/5.
Are there any recalls for the 2024 TOYOTA GR86?▼
Yes, the 2024 TOYOTA GR86 has 1 recall(s). The most common affected component is EQUIPMENT:OTHER:LABELS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2024 TOYOTA GR86?▼
The most-complained component for the 2024 TOYOTA GR86 is FUEL/PROPULSION SYSTEM with 3 complaints. Other frequently reported areas include ENGINE.
Is the 2024 TOYOTA GR86 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. The 2024 TOYOTA GR86 has an NHTSA safety rating of Not Rated/5. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.