Total Complaints
1 filings
SUZUKI DL1000 · model year
2004 SUZUKI DL1000
1 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004SUZUKIDL1000 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2004 DL1000 is power train:axle hubs with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 14 investigation files overlapping the 2004 DL1000. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN:AXLE HUBS | 1 |
Recalls (1)
08E05200015/08/2008
EQUIPMENT
MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE
Recent Complaints
20060908POWER TRAIN:AXLE HUBS
SPROCKET ON REAR WHEEL HUB WOBBLES UNDER LOAD. THIS CAUSES CLUNKING WHEN SHIFTING AND VERY POOR POWER TRANSMISSION. IN ADDITION THIS CAUSES PREMATURE BEARING, CHAIN AND SPROCKET WEAR. THE CAUSE IS THAT THE REAR SPROCKET CARRIER DOES NOT FULLY ENGAGE THE HUB DAMPER. UNDER LOAD THE SPROCKET BEARING HAS LATERAL FORCE APPLIED TO IT. THE REAR SPROCKET WILL ACTUALLY MOVE WITH ONLY HAND FORCE! THIS IS A DESIGN DEFECT AFFECTING ALL DL1000 VSTROMS. MANY OWNERS (MYSELF INCLUDED) ARE FIXING THIS DEFECT THEMSELVES AS SUZUKI WILL NOT ACKNOWLEDGE THE DEFECT EVEN EXISTS. THE KAWASAKI VERSION OF THIS MOTORCYCLE LIKELY HAS THE SAME DESIGN DEFECT. *NM
Compare 2004SUZUKIDL1000 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 SUZUKI DL1000 have?▼
The 2004 SUZUKI DL1000 has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2004 SUZUKI DL1000?▼
Yes, the 2004 SUZUKI DL1000 has 1 recall(s). The most common affected component is EQUIPMENT. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2004 SUZUKI DL1000?▼
The most-complained component for the 2004 SUZUKI DL1000 is POWER TRAIN:AXLE HUBS with 1 complaints. Other frequently reported areas include various components.
Is the 2004 SUZUKI DL1000 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2004 SUZUKI DL1000; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.