2003 SAAB 9-5

ELECTRICAL SYSTEM:IGNITION:MODULE

CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.

WHEELS:HUB

ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATI

SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.

I HAD TO REPLACE FUEL PUMP 3 TIMES IN 4 YEARS. IT SMELLED LIKE FUEL IN MY CAR.

Mileage: 2

TL* THE CONTACT OWNS A 1993 BUICK REGAL. THE CONTACT STATED THAT ALL DOOR LOCKS WOULD BECOME STUCK WHEN ACTIVATED BY THE ELECTRONIC DOOR LOCK SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000.

Mileage: 41,000

AFTER DRIVING MY CAR TO MY DESTINATION, I PUT THE CAR IN PARK BUT THE CAR WON'T STAY IN PARK. THE CAR POPS OUT OF PARK INTO REVERSE, THEN IT WON'T START WHEN I GET BACK INTO MY CAR. *TR

Mileage: 131,000

AFTER DRIVING MY CAR TO MY DESTINATION, I PUT THE CAR IN PARK BUT THE CAR WON'T STAY IN PARK. THE CAR POPS OUT OF PARK INTO REVERSE, THEN IT WON'T START WHEN I GET BACK INTO MY CAR. *TR

Mileage: 131,000

TL* THE CONTACTS OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE DIRECT IGNITION CASSETTE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 125,000.

I WAS DRIVING THE CAR WHEN SUDDENLY THE CAR WHEN DEAD WHILE I WAS DRIVING IT.I WAS LUCKY THAT I WAS ABLE TO RESTART IT AND THERE WAS A GAS STATION RIGHT NEAR BY. IT DID NOT START UP NORMALLY AND WAS VERY SLUGGISH. I WAS IN THE MIDDLE OF TRAFFIC WHEN THIS HAPPENED BUT FORTUNATELY NOT HEAVY TRAFFIC AND IN THE RIGHT LANE. IT WAS VERY SCARY. THEY TOWED MY SAAB TO A SAAB DEALER FOR ME WHO HAD TO INSTALL A NEW IGNITION. THIS HAPPENED ABOUT 4-5 YEARS AGO ON MY SAAB 2003 9-5 STATION WAGON WHICH WAS BUILT BY GM. I BELIEVE IT WAS BUILT ON THE SAME PLATFORM OF ONE OF THE CADILLACS THAT IS UNDER RECALL. *TR

Mileage: 50,030

I WAS DRIVING THE CAR WHEN SUDDENLY THE CAR WHEN DEAD WHILE I WAS DRIVING IT.I WAS LUCKY THAT I WAS ABLE TO RESTART IT AND THERE WAS A GAS STATION RIGHT NEAR BY. IT DID NOT START UP NORMALLY AND WAS VERY SLUGGISH. I WAS IN THE MIDDLE OF TRAFFIC WHEN THIS HAPPENED BUT FORTUNATELY NOT HEAVY TRAFFIC AND IN THE RIGHT LANE. IT WAS VERY SCARY. THEY TOWED MY SAAB TO A SAAB DEALER FOR ME WHO HAD TO INSTALL A NEW IGNITION. THIS HAPPENED ABOUT 4-5 YEARS AGO ON MY SAAB 2003 9-5 STATION WAGON WHICH WAS BUILT BY GM. I BELIEVE IT WAS BUILT ON THE SAME PLATFORM OF ONE OF THE CADILLACS THAT IS UNDER RECALL. *TR

Mileage: 50,030

TL* THE CONTACT OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE STEERING WHEEL AND THE BRAKES SEIZED AS THE ENGINE STALLED. THE CONTACT WAS ABLE TO STOP THE VEHICLE WITH THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO PERFORMED A DIAGNOSTIC TEST AND DISCOVERED THAT THE IGNITION DISCHARGE MODULE WAS DEFECTIVE. THE CONTACT REFERENCED NHTSA CAMPAIGN I.D. NUMBER: 06V410000 (ELECTRICAL SYSTEM) AND CALLED THE MANUFACTURER, WHO ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

THE HORN OFTEN FAILS TO WORK WHEN THE STEERING WHEEL MOUNTED AIRBAG COVER IS PRESSED. THIS IS AN ONGOING, UNRESOLVED PROBLEM. A DEALER REPLACED A PART UNDER WARRANTY BUT THAT DID NOT FIX THE PROBLEM. I HAVE SEEN SEVERAL OTHER 2002+ 9-5S WITH THE SAME HORN FAILURE ISSUE. *TR

THE HORN OFTEN FAILS TO WORK WHEN THE STEERING WHEEL MOUNTED AIRBAG COVER IS PRESSED. THIS IS AN ONGOING, UNRESOLVED PROBLEM. A DEALER REPLACED A PART UNDER WARRANTY BUT THAT DID NOT FIX THE PROBLEM. I HAVE SEEN SEVERAL OTHER 2002+ 9-5S WITH THE SAME HORN FAILURE ISSUE. *TR

THE FRONT SEATBELTS FRAY NEAR WHERE THE BUCKLE SECURES THE BELT WHEN IN USE. THE SEATBELT WAS REPLACED WITH OEM PARTS FOR THIS REASON. THE NEW BELT HAS FRAYED AGAIN OVER A SHORT PERIOD OF TIME. OTHERS REPORT SIMILAR PROBLEMS, PERHAPS DUE TO SOMETHING ROUGH ABRADING THE BELT SOMEWHERE ALONG THE BELT PATH. *TR

THE FRONT SEATBELTS FRAY NEAR WHERE THE BUCKLE SECURES THE BELT WHEN IN USE. THE SEATBELT WAS REPLACED WITH OEM PARTS FOR THIS REASON. THE NEW BELT HAS FRAYED AGAIN OVER A SHORT PERIOD OF TIME. OTHERS REPORT SIMILAR PROBLEMS, PERHAPS DUE TO SOMETHING ROUGH ABRADING THE BELT SOMEWHERE ALONG THE BELT PATH. *TR

I WAS DRIVING APPROXIMATELY 30-35 MPH DOWN A FOUR LANE ROAD WHEN THE CAR STALLED LEAVING ME WITH NO POWER AT THE ACCELERATOR. IT BECAME VERY DIFFICULT TO STEER THE CAR AND THE BRAKE PEDAL BECAME VERY HARD TO DEPRESS. LUCKILY I WAS ABLE TO COAST OFF THE ROAD WHERE THE CAR CAME TO A COMPLETE STOP BLOCKING THE ENTRANCE/EXIT OF A GAS STATION. I WAS LESS THEN 200 FEET FROM WHERE I WAS TURNING ONTO THE ENTRANCE RAMP OF A HIGHWAY. THE GAS STATION ATTENDANT WAS VERY UPSET TELLING ME I CAN NOT LEAVE MY CAR THERE. THE CAR WOULD NOT START AFTER SEVERAL ATTEMPTS. THE CAR WAS TOWED TO THE MECHANIC. THE CAR HAS BEEN AT THE SERVICE STATION FOR OVER 2 WEEKS NOW. THE TECHNICIAN IS UNABLE TO FIND THE REASON THE CAR STALLED. HOWEVER HE EXPLAINED THAT THE FUEL PUMP AND THE FUEL PUMP RELAY ARE OPERATIONAL. HE ALSO EXPLAINED THAT THERE IS NO ELECTRICITY GETTING TO THE FUEL PUMP. HE HAS ALREADY REPLACED THE CRANKSHAFT POSITION SENSOR AND IS IN THE PROCESS OF CHECKING ALL SENSORS AND RELAYS. DURIN

Mileage: 112,000

I WAS DRIVING APPROXIMATELY 30-35 MPH DOWN A FOUR LANE ROAD WHEN THE CAR STALLED LEAVING ME WITH NO POWER AT THE ACCELERATOR. IT BECAME VERY DIFFICULT TO STEER THE CAR AND THE BRAKE PEDAL BECAME VERY HARD TO DEPRESS. LUCKILY I WAS ABLE TO COAST OFF THE ROAD WHERE THE CAR CAME TO A COMPLETE STOP BLOCKING THE ENTRANCE/EXIT OF A GAS STATION. I WAS LESS THEN 200 FEET FROM WHERE I WAS TURNING ONTO THE ENTRANCE RAMP OF A HIGHWAY. THE GAS STATION ATTENDANT WAS VERY UPSET TELLING ME I CAN NOT LEAVE MY CAR THERE. THE CAR WOULD NOT START AFTER SEVERAL ATTEMPTS. THE CAR WAS TOWED TO THE MECHANIC. THE CAR HAS BEEN AT THE SERVICE STATION FOR OVER 2 WEEKS NOW. THE TECHNICIAN IS UNABLE TO FIND THE REASON THE CAR STALLED. HOWEVER HE EXPLAINED THAT THE FUEL PUMP AND THE FUEL PUMP RELAY ARE OPERATIONAL. HE ALSO EXPLAINED THAT THERE IS NO ELECTRICITY GETTING TO THE FUEL PUMP. HE HAS ALREADY REPLACED THE CRANKSHAFT POSITION SENSOR AND IS IN THE PROCESS OF CHECKING ALL SENSORS AND RELAYS. DURIN

Mileage: 112,000

I WAS DRIVING APPROXIMATELY 30-35 MPH DOWN A FOUR LANE ROAD WHEN THE CAR STALLED LEAVING ME WITH NO POWER AT THE ACCELERATOR. IT BECAME VERY DIFFICULT TO STEER THE CAR AND THE BRAKE PEDAL BECAME VERY HARD TO DEPRESS. LUCKILY I WAS ABLE TO COAST OFF THE ROAD WHERE THE CAR CAME TO A COMPLETE STOP BLOCKING THE ENTRANCE/EXIT OF A GAS STATION. I WAS LESS THEN 200 FEET FROM WHERE I WAS TURNING ONTO THE ENTRANCE RAMP OF A HIGHWAY. THE GAS STATION ATTENDANT WAS VERY UPSET TELLING ME I CAN NOT LEAVE MY CAR THERE. THE CAR WOULD NOT START AFTER SEVERAL ATTEMPTS. THE CAR WAS TOWED TO THE MECHANIC. THE CAR HAS BEEN AT THE SERVICE STATION FOR OVER 2 WEEKS NOW. THE TECHNICIAN IS UNABLE TO FIND THE REASON THE CAR STALLED. HOWEVER HE EXPLAINED THAT THE FUEL PUMP AND THE FUEL PUMP RELAY ARE OPERATIONAL. HE ALSO EXPLAINED THAT THERE IS NO ELECTRICITY GETTING TO THE FUEL PUMP. HE HAS ALREADY REPLACED THE CRANKSHAFT POSITION SENSOR AND IS IN THE PROCESS OF CHECKING ALL SENSORS AND RELAYS. DURIN

Mileage: 112,000

TL* THE CONTACT OWNS A 2003 SAAB 9-5 EQUIPPED WITH HANKOOK TIRES HKH405, SIZE 225-45-17. THE DOT AND SERIAL NUMBERS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR ROUTINE MAINTENANCE WHEN THE TECHNICIAN ADVISED THAT THE FRONT TIRES TREAD WAS WORN PREMATURELY. THE TIRES WERE REPLACED. THE FAILURE MILEAGE WAS 12,000 UPDATED 08-24-12 *BF

Mileage: 12,000

MY CAR WAS BUILT IN 2002 AS WELL AS OTHERS REPORTED, I PURCHASED IT USED 3 YEARS AGO WITH 64K MILES. MY DIRECT IGNITION CONTROL IN 2003 9-5 LINEAR SEDAN 2.3T CEASED. UPON RESEARCH, MY DIC IS THE ORIGINAL PART 9197559 TK3.6 2000-2002 ARE RECALLED AND 'SOME' 2003 VIN'S. WITH THE OVER ABUNDANCE OF DIC FAILURES WITH THE EXACT SAME PART NUMBER, THESE NEED TO BE RECALLED AS A WHOLE. UPON REMOVAL OF THE DIC, THE ENGINE IS LEAKING AT THE SEAMS OF THE HEAD FROM WHERE THE BOLTS ARE LOCATED, INSIDE THE DIC AND ENGINE SECTION IS PERFECTLY CLEAN. BOLTS IN THE HEAD OF THE ENGINE LOOSE, 1 WAS LIFTED OUT ENOUGH TO JUST REMOVE STRAIGHT OUT. CAR BLOWS BLUEISH SMOKE WHEN IT WAS STARTING, SWITCHES ARE DEFECTIVE (GM KNOWN ISSUE), OIL / ENGINE / HEAD KNOWN ISSUES, SUSPENSION KNOWN ISSUES (AMONG OTHER SERIOUS SAAB FAILURES). I HAVE SPENT THOUSANDS OF DOLLARS ON THIS VEHICLE SINCE PURCHASE. THE KNOWN RECALLS MUST BE EXPANDED TO INCLUDE THE PARTS, NOT JUST 'YEAR' OR 'SPECIFIC VIN'. THIS WAS SUPPOSED T

Mileage: 84,000

MY CAR WAS BUILT IN 2002 AS WELL AS OTHERS REPORTED, I PURCHASED IT USED 3 YEARS AGO WITH 64K MILES. MY DIRECT IGNITION CONTROL IN 2003 9-5 LINEAR SEDAN 2.3T CEASED. UPON RESEARCH, MY DIC IS THE ORIGINAL PART 9197559 TK3.6 2000-2002 ARE RECALLED AND 'SOME' 2003 VIN'S. WITH THE OVER ABUNDANCE OF DIC FAILURES WITH THE EXACT SAME PART NUMBER, THESE NEED TO BE RECALLED AS A WHOLE. UPON REMOVAL OF THE DIC, THE ENGINE IS LEAKING AT THE SEAMS OF THE HEAD FROM WHERE THE BOLTS ARE LOCATED, INSIDE THE DIC AND ENGINE SECTION IS PERFECTLY CLEAN. BOLTS IN THE HEAD OF THE ENGINE LOOSE, 1 WAS LIFTED OUT ENOUGH TO JUST REMOVE STRAIGHT OUT. CAR BLOWS BLUEISH SMOKE WHEN IT WAS STARTING, SWITCHES ARE DEFECTIVE (GM KNOWN ISSUE), OIL / ENGINE / HEAD KNOWN ISSUES, SUSPENSION KNOWN ISSUES (AMONG OTHER SERIOUS SAAB FAILURES). I HAVE SPENT THOUSANDS OF DOLLARS ON THIS VEHICLE SINCE PURCHASE. THE KNOWN RECALLS MUST BE EXPANDED TO INCLUDE THE PARTS, NOT JUST 'YEAR' OR 'SPECIFIC VIN'. THIS WAS SUPPOSED T

Mileage: 84,000

MY CAR WAS BUILT IN 2002 AS WELL AS OTHERS REPORTED, I PURCHASED IT USED 3 YEARS AGO WITH 64K MILES. MY DIRECT IGNITION CONTROL IN 2003 9-5 LINEAR SEDAN 2.3T CEASED. UPON RESEARCH, MY DIC IS THE ORIGINAL PART 9197559 TK3.6 2000-2002 ARE RECALLED AND 'SOME' 2003 VIN'S. WITH THE OVER ABUNDANCE OF DIC FAILURES WITH THE EXACT SAME PART NUMBER, THESE NEED TO BE RECALLED AS A WHOLE. UPON REMOVAL OF THE DIC, THE ENGINE IS LEAKING AT THE SEAMS OF THE HEAD FROM WHERE THE BOLTS ARE LOCATED, INSIDE THE DIC AND ENGINE SECTION IS PERFECTLY CLEAN. BOLTS IN THE HEAD OF THE ENGINE LOOSE, 1 WAS LIFTED OUT ENOUGH TO JUST REMOVE STRAIGHT OUT. CAR BLOWS BLUEISH SMOKE WHEN IT WAS STARTING, SWITCHES ARE DEFECTIVE (GM KNOWN ISSUE), OIL / ENGINE / HEAD KNOWN ISSUES, SUSPENSION KNOWN ISSUES (AMONG OTHER SERIOUS SAAB FAILURES). I HAVE SPENT THOUSANDS OF DOLLARS ON THIS VEHICLE SINCE PURCHASE. THE KNOWN RECALLS MUST BE EXPANDED TO INCLUDE THE PARTS, NOT JUST 'YEAR' OR 'SPECIFIC VIN'. THIS WAS SUPPOSED T

Mileage: 84,000

CHECK ENGINE LIGHT KEPT GOING ON AND OFF AND CAR HAD MADE A LOUD POPPING NOISE FROM THE ELECTRICAL SYSTEM, WHEN TRYING TO START ONE DAY. I CHECKED ONLINE FOR RECALLS, WHICH STATED THERE WAS A RECALL FOR ELECTRICAL, IGNITION ISSUES. I TOOK MY CAR INTO A REPAIR SHOP TO CHECK ON CHECK ENGINE LIGHT. THERE IS A RECALL 06V410000, OCT 26 2006 FOR THIS VERY ISSUE BUT FOR 6 CYLINDER, AND MINE IS A 4 CYLINDER ENGINE. THE REPAIR SHOP REPLACED THE IGN CASSETTE. THIS WAS A VERY EXPENSIVE REPAIR, $582.45 AND SHOULD BE COVERED BY SAAB. MY CAR COULD HAVE CAUGHT ON FIRE. WHAT DO YOU HAVE TO SAY ABOUT THAT! *TR

Mileage: 130,000