Total Complaints
4 filings
PORSCHE BOXSTER · model year
2004 PORSCHE BOXSTER
4 NHTSA complaints, and 3 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004PORSCHEBOXSTER carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2004 BOXSTER is engine and engine cooling with 1 filings, followed by steering (1) and engine and engine cooling:engine (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 5 investigation files overlapping the 2004 BOXSTER. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING | 1 |
| STEERING | 1 |
| ENGINE AND ENGINE COOLING:ENGINE | 1 |
| ENGINE | 1 |
Recalls (3)
22V65600030/08/2022
EXTERIOR LIGHTING:HEADLIGHTS
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that
09E02500011/05/2009
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES
09E01200007/04/2009
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES
Recent Complaints
20120621ENGINE
THE INTERMEDIATE SHAFT BEARING WHEN OUT AND SPREAD METAL SHAVING THROUGHOUT THE ENGINE. THIS CAUSED A CATASTROPHIC ENGINE FAILURE. I HAVE TO HAVE THE CAR TOWED TO THE MECHANIC AND WILL HAVE TO HAVE AN ENGINE REBUILD. THE CAR HAS BEEN SERVICE ACCORDING TO THE COMPANY PROVIDED SERVICE MANUAL. I CALLED PORSCHE USA TO SEE IF THEY WOUDL DO ANYTHING ABOUT THE FAILURE, SINCE THIS HAS BEEN A DOCUMENTED PROBLEM WITH CERTAIN PORSCHES, BUT THE COMPANY WOULD NOT HELP. *TT
Mileage: 32,000
20110429ENGINE AND ENGINE COOLING:ENGINE
2004 PORSCHE BOXSTER, 58-60K MI, HAD CATASTROPHIC ENGINE FAILURE AT 10 MI/HR. ENGINE STALLED; WAS ABLE TO RESTART AND DRIVE A FEW FEET, BUT BADLY MISSING. LOUD CLANGING NOISE FROM ENGINE. NO SMOKE. OIL DRAINED FROM CAR WHEN TILTED ON TOWTRUCK. DEALER FOUND INTERMEDIATE SHAFT (IMS) FAILURE; REQUIRED ENGINE REPLACEMENT AT $18K. DEALER SAID THEY HAD SEEN A SIGNIFICANT NUMBER OF IMS FAILURES (BUT PORSCHE HAS NOT NOTIFIED OWNERS). NO INJURIES, BUT CERTAINLY ENGINE FAILURE LIKE THIS COULD HAVE SERIOUS CONSEQUENCES AT FREEWAY SPEEDS. PORSCHE FORUMS ON INTERNET SHOW FREQUENCY OF FAILURES FROM THIS DEFECT (POORLY DESIGNED BEARING ASSEMBLY ON IMS) IS VERY HIGH, AS MUCH AS 8-11% IN ONE FORUM POLL. DEFECT FOUND IN MY97-08. *TR
Mileage: 60,000
20090507ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2004 PORSCHE BOXSTER. WHEN ACCELERATING FROM A STOP LIGHT AT 2 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT THE IMS (INTERMEDIATE SHAFT) FAILED, WHICH CAUSED THE ENGINE TO FAIL. IT WOULD COST $16,000-$20,000 TO REPLACE. THE MANUFACTURER STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE BECAUSE THE VEHICLE EXCEEDED ITS WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 20468. UPDATED 05/27/09. *LJ THE INTERMEDIATE SHAFT BOLT BROKE WHICH CAUSED THE ENGINE TO FAIL. UPDATED 05/28/09.*JB
Mileage: 20,468
20090507STEERING
TL*THE CONTACT OWNS A 2004 PORSCHE BOXSTER. WHEN ACCELERATING FROM A STOP LIGHT AT 2 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT THE IMS (INTERMEDIATE SHAFT) FAILED, WHICH CAUSED THE ENGINE TO FAIL. IT WOULD COST $16,000-$20,000 TO REPLACE. THE MANUFACTURER STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE BECAUSE THE VEHICLE EXCEEDED ITS WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 20468. UPDATED 05/27/09. *LJ THE INTERMEDIATE SHAFT BOLT BROKE WHICH CAUSED THE ENGINE TO FAIL. UPDATED 05/28/09.*JB
Mileage: 20,468
Compare 2004PORSCHEBOXSTER to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 PORSCHE BOXSTER have?▼
The 2004 PORSCHE BOXSTER has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2004 PORSCHE BOXSTER?▼
Yes, the 2004 PORSCHE BOXSTER has 3 recall(s). The most common affected component is EXTERIOR LIGHTING:HEADLIGHTS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2004 PORSCHE BOXSTER?▼
The most-complained component for the 2004 PORSCHE BOXSTER is ENGINE AND ENGINE COOLING with 1 complaints. Other frequently reported areas include STEERING and ENGINE AND ENGINE COOLING:ENGINE.
Is the 2004 PORSCHE BOXSTER safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.