2000 PONTIAC SUNFIRE

ELECTRICAL SYSTEM:IGNITION:SWITCH

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

STEERING

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

MY CAR WAS DRIVING PERFECT UNTIL 3 WEEKS AGO, IT HAS SINCE THEN WONT START BACK UP. THOUGHT IT WAS SOMETHING TO DO WITH SPARK, THEN TRIED SPARK PLUG WIRES, NEW BATTERY, CHECKED ALTERNATOR AND FUSES, COILS ALL GOOD. THEN I WAS LEAD TO MAYBE THE GAS THAT WAS IN IT. DROPPED GAS TANK, PUT NEW FUEL FILTER, CHECKED FUEL PUMP, GAS LINES, IT DID STAY RUNNING ONE TIME SINCE BUT WAS SHAKING ROUGHLY WITH A FLASHING CHECK ENGINE LIGHT. WILL NOT RUN ANYMORE SINCE THEN. HAVE NOT BEEN ABLE TO DRIVE MY VEHICLE FOR 3 WEEKS NOW AND IT IS MY ONLY CAR.. ALSO BEFORE THE CAR STARTED HAVING THE ABOVE PROBLEMS MY BRAKES KEPT GETTING TONS OF AIR ALSO LOSING A TON OF BRAKE FLUID, ABS LIGHT STAYS ON AND ALL BRAKE LINES ARE GOOD. IT'S DANGEROUS. ALSO HAVE BLED THE BRAKES. NOT MUCH HELP OTHER THAN TEMPORARILY. *TR

Mileage: 160,000

MY CAR WAS DRIVING PERFECT UNTIL 3 WEEKS AGO, IT HAS SINCE THEN WONT START BACK UP. THOUGHT IT WAS SOMETHING TO DO WITH SPARK, THEN TRIED SPARK PLUG WIRES, NEW BATTERY, CHECKED ALTERNATOR AND FUSES, COILS ALL GOOD. THEN I WAS LEAD TO MAYBE THE GAS THAT WAS IN IT. DROPPED GAS TANK, PUT NEW FUEL FILTER, CHECKED FUEL PUMP, GAS LINES, IT DID STAY RUNNING ONE TIME SINCE BUT WAS SHAKING ROUGHLY WITH A FLASHING CHECK ENGINE LIGHT. WILL NOT RUN ANYMORE SINCE THEN. HAVE NOT BEEN ABLE TO DRIVE MY VEHICLE FOR 3 WEEKS NOW AND IT IS MY ONLY CAR.. ALSO BEFORE THE CAR STARTED HAVING THE ABOVE PROBLEMS MY BRAKES KEPT GETTING TONS OF AIR ALSO LOSING A TON OF BRAKE FLUID, ABS LIGHT STAYS ON AND ALL BRAKE LINES ARE GOOD. IT'S DANGEROUS. ALSO HAVE BLED THE BRAKES. NOT MUCH HELP OTHER THAN TEMPORARILY. *TR

Mileage: 160,000

"TAKATA RECALL" WHILE DRIVING AT NIGHT ON A COUNTY ROAD AND SWITCHING FROM LOW BEAMS TO HIGH BEAMS, THE HEADLIGHTS WENT COMPLETELY DARK AND DID NOT COME BACK ON UNTIL SWITCHING BACK TO LOW BEAMS. AFTER INSPECTION, NOTICED THE DAY RUNNERS ALSO WERE NOT WORKING. ALL FUSES WERE PLUGGED IN AND GOOD. REPLACING THE RELAY DID NOT FIX THE PROBLEM DESCRIBED HEREIN.

Mileage: 106,000

"TAKATA RECALL" WHILE DRIVING AT NIGHT ON A COUNTY ROAD AND SWITCHING FROM LOW BEAMS TO HIGH BEAMS, THE HEADLIGHTS WENT COMPLETELY DARK AND DID NOT COME BACK ON UNTIL SWITCHING BACK TO LOW BEAMS. AFTER INSPECTION, NOTICED THE DAY RUNNERS ALSO WERE NOT WORKING. ALL FUSES WERE PLUGGED IN AND GOOD. REPLACING THE RELAY DID NOT FIX THE PROBLEM DESCRIBED HEREIN.

Mileage: 106,000

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE VEHICLE'S TURN SIGNALS WOULD INTERMITTENTLY FAIL TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS A RECALL THAT INVOLVED A SIMILAR FAILURE (GMC RECALL NUMBER: 03043); HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 164,283.

Mileage: 164,283

DAUGHTER HYDROPLANED, WENT INTO DITCH ON RIGHT SIDE OF ROAD, TRAVELED ACROSS ROAD INTO LEFT DITCH AND HIT TREE, OPENING THE CONVERTIBLE TOP DURING CRASH AND TOTALED VEHICLE AIRBAGS DIDN'T DEPLOY DURING CRASH.

Mileage: 115,000

MY DAUGHTERS CAR WAS HAVING STARTING PROBLEMS (NOT ENOUGH GAS GETTING TO THE ENGINE TO START, HAD TO PUMP THE GAS). I TOOK IT FOR A TEST DRIVE IN A EMPTY PARKING LOT ONCE IT STARTED. I WAS GOING APPROX 10MPH THE FIRST TIME I PUSHED THE GAS PEDAL TO THE FLOOR. WHEN I RELEASED THE PEDAL IT STAYED IN PLACE AT FULL THROTTLE. I PUSHED THE BREAKS TO STOP THE CAR AND HAD TO THROW IT INTO NEUTRAL BEFORE THE THROTTLE RELEASED. SCARED THE HELL OUT OF ME!! THANK GOD MY TEENAGE DAUGHTER NEVER PUSHED THE THROTTLE ALL THE WAY DOWN!! I TRIED IT SEVERAL MORE TIMES WITH THE SAME RESULTS. SOMEHOW THE THROTTLE STICKING IS TIED TO THE TRANSMISSION BECAUSE, EVERYTIME, THE THROTTLE WOULD RELEASED AS SOON AS I PUT IT IN NEUTRAL. I DONOT HAVE THE VIN BECAUSE WE TOOK IT TO A SHOP TONIGHT. JUST THOUGHT I SHOULD WARN ANYONE ELSE WITH THIS VEHICLE. I HAD MY DAUGHTER MEET ME IN THE PARKING LOT AND TOLD HER TO FLOOR IT WITH THE SAME RESULTS, AND AS I THOUGHT WOULD HAPPENED SHE PANIC AND ONLY PUSHED THE BREAKS YELLI

Mileage: 150,000

MY DAUGHTERS CAR WAS HAVING STARTING PROBLEMS (NOT ENOUGH GAS GETTING TO THE ENGINE TO START, HAD TO PUMP THE GAS). I TOOK IT FOR A TEST DRIVE IN A EMPTY PARKING LOT ONCE IT STARTED. I WAS GOING APPROX 10MPH THE FIRST TIME I PUSHED THE GAS PEDAL TO THE FLOOR. WHEN I RELEASED THE PEDAL IT STAYED IN PLACE AT FULL THROTTLE. I PUSHED THE BREAKS TO STOP THE CAR AND HAD TO THROW IT INTO NEUTRAL BEFORE THE THROTTLE RELEASED. SCARED THE HELL OUT OF ME!! THANK GOD MY TEENAGE DAUGHTER NEVER PUSHED THE THROTTLE ALL THE WAY DOWN!! I TRIED IT SEVERAL MORE TIMES WITH THE SAME RESULTS. SOMEHOW THE THROTTLE STICKING IS TIED TO THE TRANSMISSION BECAUSE, EVERYTIME, THE THROTTLE WOULD RELEASED AS SOON AS I PUT IT IN NEUTRAL. I DONOT HAVE THE VIN BECAUSE WE TOOK IT TO A SHOP TONIGHT. JUST THOUGHT I SHOULD WARN ANYONE ELSE WITH THIS VEHICLE. I HAD MY DAUGHTER MEET ME IN THE PARKING LOT AND TOLD HER TO FLOOR IT WITH THE SAME RESULTS, AND AS I THOUGHT WOULD HAPPENED SHE PANIC AND ONLY PUSHED THE BREAKS YELLI

Mileage: 150,000

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, A SMALL FIRE OCCURRED IN THE STEERING COLUMN AND INSTRUMENT PANEL. IN ADDITION, THE FRONT DRIVER'S SIDE WINDSHIELD WAS CRACKED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT REPAIRED. IN 2005, THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO THE MOST RECENT FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 04V036000 (ELECTRICAL SYSTEM: IGNITION: SWITCH). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 08/07/12*LJ UPDATED 08/15/2012 *JS

Mileage: 150,000

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, A SMALL FIRE OCCURRED IN THE STEERING COLUMN AND INSTRUMENT PANEL. IN ADDITION, THE FRONT DRIVER'S SIDE WINDSHIELD WAS CRACKED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT REPAIRED. IN 2005, THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO THE MOST RECENT FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 04V036000 (ELECTRICAL SYSTEM: IGNITION: SWITCH). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 08/07/12*LJ UPDATED 08/15/2012 *JS

Mileage: 150,000

REAR PASSENGER SIDE TURN SIGNAL SOCKET IT IS GETTING VERY HOT AND IS MELTING BULBS AND SOCKET. HAVE REPLACED BULBS VARIOUS TIMES WITH AND WITHOUT PROPER GREASE AND NO CHANGE. *TR

REAR PASSENGER SIDE TURN SIGNAL SOCKET IT IS GETTING VERY HOT AND IS MELTING BULBS AND SOCKET. HAVE REPLACED BULBS VARIOUS TIMES WITH AND WITHOUT PROPER GREASE AND NO CHANGE. *TR

TL*THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. UPON STARTING THE ENGINE AT NIGHT, THE INSTRUMENT PANEL WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 130,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE IGNITION SWITCH HAS MELTED,WHICH DISABLED VEHICLE OPERATION. THE DEALER AND THE MANUFACTURER WERE CONTACTED. HE WAS REFERRED TO THE DEALER FOR DIAGNOSTIC TESTING. THE WARRANTY EXPIRED, AND THERE WERE NO RECALLS THAT ADDRESSED THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

Mileage: 125,000

TL*THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE VEHICLE HAS CATALYST V TIRES, MODEL 20555R16 (NA). THE CONTACT STATED THAT ALL FOUR TIRES FAILED ON HER VEHICLE. SHE STATED THAT THE TIRES WERE SUPPOSED TO BE ALL SEASON TIRES; HOWEVER, THEY DO NOT PERFORM PROPERLY. THE VEHICLE CANNOT BE DRIVEN IN THE SNOW BECAUSE THE TIRES SKID AND DO NOT ALLOW PROPER TURNING. THE CONTACT HAS BEEN UNABLE TO REACH THE MANUFACTURER TO NOTIFY THEM OF THE FAILURE. THE DOT NUMBER IS SLIGHTLY SHORTER THAN THE OTHER TIRES AND THE DEFECT OCCURS ON ALL FOUR TIRES. THE CURRENT AND FAILURE MILEAGES WERE 97,000.

Mileage: 97,000

PASSENGER TAIL LIGHT OR BRAKE LIGHT HAVE BEEN REPLACED SEVERAL TIMES. FUSES REPLACED SEVERAL TIMES. ONCE REPLACED BULBS DEFECT WITHIN AN HOUR OR SO. DOME LIGHT OR OVER HEAD LIGHT REPEATS SAME PROCESS. VEHICLE'S BATTERY AND TERMINALS REPLACED WITH NO CHANGE. $$$ *TR

PASSENGER TAIL LIGHT OR BRAKE LIGHT HAVE BEEN REPLACED SEVERAL TIMES. FUSES REPLACED SEVERAL TIMES. ONCE REPLACED BULBS DEFECT WITHIN AN HOUR OR SO. DOME LIGHT OR OVER HEAD LIGHT REPEATS SAME PROCESS. VEHICLE'S BATTERY AND TERMINALS REPLACED WITH NO CHANGE. $$$ *TR

NO MEMORY OF THE NIGHT OF THE ACCIDENT I SUSTAINED LIFE THREATENING INJURIES AND MY BOYFRIEND DIED. MY SPECIALISTS OUT OF STATE BELIEVES IT WAS SOMETHING KNOWN AS SUDDEN ACCELERATION. THIS IS A PROBLEM WHY DOES NHTSA KEEP IGNORING THAT THERE IS A MORE SERIOUS PROBLEM HERE INSTEAD OF BLAMING THE DRIVERS. I'M STILL FACING CRIMINAL CHARGES DUE TO THIS ACCIDENT THOUGH THE FAMILY HAS NOT PRESSED CHARGES AND HAS BEEN VERY SUPPORTIVE OF ME EVER SINCE. SOMETHING IS REALLY WRONG WITH THIS PICTURE THAT I'M BEING PROSECUTED FOR SOMETHING THAT WASN'T MY FAULT AND WAS CAR DEFECT. *JB

MY TURN SIGNALS HAVE BEEN ACTING UP LATELY. AFTER DOING SOME RESEARCH ONLINE, I DECIDED TO FILE THE CLAIM-SEEMS I AM NOT THE ONLY ONE HAVING THE SAME PROBLEM. WHEN I USE MY LEFT TURN SIGNAL, MORE OFTEN THEN NOT IT DOESN'T WORK, MY DASH LIGHTS FLASH AND MY WINDSHIELD WIPERS WILL NOT SHUT OFF. WHEN I USE MY RIGHT SIGNAL, THE DASH LIGHTS FLASH BUT MY WINDSHIELD WIPERS ONLY STAY ON FOR ABOUT A MINUTE. IF I HAVE MY HEADLIGHTS ON (FOR NIGHT DRIVING) THE WIPERS ARE ON CONSTANTLY. ALSO, MY WINDSHIELD FLUID DOES NOT SPRAY. I HAD THE WIRING REPLACED SOME TIME AROUND WHEN I PURCHASED IT 4 YEARS AGO (OLD PART NOT AVAILABLE). IT CORRECTED THE PROBLEM FOR ABOUT A YEAR, HOWEVER SINCE THEN IT HAS BEEN A COME AND GO ISSUE. *NM

VEHICLE: 2000 PONTIAC SUNFIRE THE DAYTIME RUNNING LIGHTS DO NOT WORK; WHEN THE VEHICLE IS PUT IN GEAR, THE LIGHTS "FLICKER" AS THE RELAY FIRES, BUT THE LIGHTS DO NOT REMAIN ON, THEN THE "SERVICE" LIGHT COMES ON. ABOUT 75% OF THE TIME, THE HEADLIGHTS WILL NOT TURN ON, AND IF THEY DO, THE BRIGHT LIGHTS DO NOT WORK AT ALL. YOU CAN "OVER-RIDE" THE SYSTEM BY PULLING THE DIMMER SWITCH BACK PARTIALLY, WHICH THEN ALLOWS THE HEADLIGHTS TO COME ON. I HAVE REPLACED THE HEADLAMP BULBS, AND THE DRL RELAY, BUT THE PROBLEM IS STILL THERE. AS I HAVE BEEN RESEARCHING THIS, I SAW A WEBSITE CALLED "CARSURVEY.ORG" WHERE THERE ARE NUMEROUS COMPLAINTS ABOUT THIS SAME PROBLEM ON SUNFIRES AND CAVALIERS (1998 - 2002). MANY OF THESE COMMENTS SAY THAT ACCORDING TO GM DEALERSHIPS, THIS IS A WIRING HARNESS PROBLEM, AND THAT GM IS AWARE OF THIS PROBLEM, BUT WILL OFFER NO ASSISTANCE IN CORRECTING IT. MY QUESTION TO YOU IS THIS: DOES YOUR ORGANIZATION HAVE TO WAIT UNTIL PEOPLE DIE AS A RESULT OF THIS PROBLEM

Mileage: 98,000