Total Complaints
1 filings
PETERBILT 537 · model year
2025 PETERBILT 537
1 NHTSA complaints, and 5 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2025PETERBILT537 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2025 537 is visibility/wiper with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 5 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 3 investigation files overlapping the 2025 537. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| VISIBILITY/WIPER | 1 |
Recalls (5)
25V04100030/01/2025
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth T180, Peterbilt 535, 567, 2025-2026 Kenworth T280, 2023-2026 Kenworth T380, 2024-2026 Kenworth T480, 2024-2026 Peterbilt 536, 537, and 548 trucks. The exterior lighting switch may fail, resulting in the hazard lights and the instrument
25V43600026/06/2025
EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn
24V04400025/01/2024
STEERING
PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are require
24V43300012/06/2024
STEERING:LINKAGES:TIE ROD ASSEMBLY
PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth K270, K370, L770, T280, T380, T480, T680, T880, W900, W990, 2025 Peterbilt 220, 520, 536, 537, 548, 567, 579, and 589 trucks. The tie rod or drag link assembly may contain an improperly heat-treated ball stud, causing the ball stud to
24V91500009/12/2024
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to
Recent Complaints
20250616VISIBILITY/WIPER
When the wipers are turned on in the low speed, they switch to interval mode when the turn signal switch is activated. When the turn signal switch is in the off position, the wipers will remain on interval. To get the wipers back into the low setting, you have to jiggle the turn signal switch to get them to function properly. Sometimes this takes several attempts. All of these trucks in my employerâs ownership have the same issue with some being worse than others.
Compare 2025PETERBILT537 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2025 PETERBILT 537 have?▼
The 2025 PETERBILT 537 has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2025 PETERBILT 537?▼
Yes, the 2025 PETERBILT 537 has 5 recall(s). The most common affected component is EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2025 PETERBILT 537?▼
The most-complained component for the 2025 PETERBILT 537 is VISIBILITY/WIPER with 1 complaints. Other frequently reported areas include various components.
Is the 2025 PETERBILT 537 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.