Total Complaints
1 filings
PETERBILT 520 · model year
2019 PETERBILT 520
1 NHTSA complaints, and 8 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2019PETERBILT520 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2019 520 is service brakes with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 8 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 3 investigation files overlapping the 2019 520. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES | 1 |
Recalls (8)
21V39100026/05/2021
FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL
PACCAR Incorporated (PACCAR) is recalling certain 2018-2021 Peterbilt 337, 348, 365, 367, 520, 567, Kenworth T270, T370, T440, T470, T800 and T880 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
22V27700025/04/2022
STEERING:CRITICAL FASTENERS
PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 Kenworth T270, T370, T440, T470, T660, T680, T880, T800, W900, W990; and 2018-2020 Peterbilt 330, 337, 348, 365, 367, 389, 520, 567, and 579 vehicles. The Dana D-Series axle steer arm fasteners that attach the steering arm to the steering
19V91700020/12/2019
STEERING
PACCAR Incorporated (PACCAR) is recalling certain 2018-2019 Peterbilt 520 vehicles built in Right-Hand Stand-Up configuration. The steering assist cylinder bracket may not have been properly mounted.
22V93900016/12/2022
SUSPENSION:MULTIPLE AXLE
PACCAR Incorporated (PACCAR) is recalling certain 2015-2023 Peterbilt 320 and 520 refuse trucks equipped with Haulmaax/EX suspensions. The suspension tracking rod brackets may fail and detach from the forward drive axle, causing the axle to become unstable.
19V45200014/06/2019
EXTERIOR LIGHTING:TURN SIGNAL
PACCAR Incorporated (PACCAR) is recalling certain 1990-2020 Peterbilt 320 and 520 vehicles built with specific amber rear turn signals. The turn signals may also light up with the stop/tail lights when the brakes are applied. As such, these vehicles fail to comply with the requirements of Federal
21V00400011/01/2021
STEERING:COLUMN
PACCAR Incorporated (PACCAR) is recalling certain 2015-2021 Peterbilt 320 and 520 vehicles. The steering column support structure may crack or break in certain right-hand, stand-up drive models.
19V28200009/04/2019
ELECTRICAL SYSTEM
PACCAR Incorporated (PACCAR) is recalling certain 2017-2020 Peterbilt 520 vehicles. Due to undersized wires, the connector between the cab power harness and the power distribution center (PDC) harness may overheat and melt, possibly resulting in an engine shutdown.
20V13200004/03/2020
SERVICE BRAKES, AIR
PACCAR Incorporated (PACCAR) is recalling certain 2016-2020 Peterbilt 320 and 520 vehicles with dual foot valves and a liftable tag or tri-drive rear axles. The rear brake signal hose may be missing a quick release valve, possibly causing a delay in their brake release timing. As such, these vehic
Recent Complaints
20190430SERVICE BRAKES
FRONT BRAKES DRAGGING AND LOCKING. WRONG SIZE S-CAM BUSHING INSTALLED FROM FACTORY. *DT
Mileage: 2,731
Compare 2019PETERBILT520 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2019 PETERBILT 520 have?▼
The 2019 PETERBILT 520 has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2019 PETERBILT 520?▼
Yes, the 2019 PETERBILT 520 has 8 recall(s). The most common affected component is FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2019 PETERBILT 520?▼
The most-complained component for the 2019 PETERBILT 520 is SERVICE BRAKES with 1 complaints. Other frequently reported areas include various components.
Is the 2019 PETERBILT 520 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.