2010 MINI COOPER S CLUBMAN

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Coo

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

BMW IS RECALLING CERTAIN MODEL YEAR 2007-2011 MINI COOPER S, 2008-2011 MINI COOPER S CLUBMAN, 2009-2011 MINI COOPER S CONVERTIBLE, 2009-2011 MINI COOPER JCW, 2009-2011 MINI COOPER JCW CLUBMAN, 2009-2011 COOPER JCW CONVERTIBLE, AND 2011 COOPER S COUNTRYMAN PASSENGER CARS MANUFACTURED FROM NOVEMBER 14

The contact owns a 2010 Mini Cooper S Clubman. The contact stated that the vehicle would shut off while driving at various speeds without warning. The contact had to wait for several minutes after the failure before restarting the vehicle and resuming normal operation. The contact also stated that while driving at various speeds, there was an abnormal ticking sound coming from the vehicle with white smoke coming from the engine. The contact pulled over and discovered that the plastic on the Body Control Module (BCM) had caused the engine to smoke. The contact also discovered that the ticking noise was coming from the fuel pump relay located inside the BCM. The vehicle was towed to an independent mechanic where the BCM was replaced. Despite the repair, the contact stated that multiple electrical features had failure in operating as needed. The dealer was notified of the failure and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and info

Mileage: 127,000

The contact owns a 2010 Mini Cooper Clubman S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 Mini Cooper S Clubman. The contact stated that when the front driver’s side door was opened, the contact smelled an odor of smoke and notice that underneath the steering wheel was burned. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The failure mileage was 110,000. VIN tool confirms parts not available.

Mileage: 110,000

6/21/2018, MY 2010 MINI COOPER CLUBMAN S DEVELOPED SERIOUS DEFECTS. I DROVE MY CAR ON THE LEFTMOST LANE OF THREE-LANE BOSTON TURNPIKE. CLOSE TO A TRAFFIC LIGHT, I BRAKED TO DECELERATE VEHICLE BUT THE ENGINE SUDDENLY DIED WITHOUT WARNING, WHILE CAR WAS IN MOTION. BOTH BATTERY AND STARTER WORKED. I TRIED MULTIPLE TIMES TO RESTART THE ENGINE IN FAILURE. I BLOCKED TRAFFIC DURING RUSH-HOUR. SEVERAL CARS TOOK ACROSS ROAD CURB AND PASSED TO MY LEFT. IT MADE ME AND MY SON IN DANGEROUS SITUATIONS. UNTIL A TRUCK DRIVER CAME TO HELP ME TO PUSH MY CAR OFF ROAD. AFTER DIAGNOSIS AND ANALYSIS IN LOCAL AUTO SHOP, MECHANIC FOUND OUT THE VEHICLE COMPUTER ENGINE CONTROL MODULE (ECM) WAS FAULTY, NOT SUPPLYING POWER TO THE IGNITION COILS. I WAS CHARGED $2298.13 TO REPLACE DEFECTIVE ECM AND $150 FOR THE TOWING SERVICE. THE WARRANTY HAS EXPIRED BUT I BELIEVE I AM STILL ENTITLED TO A FREE REPAIR BECAUSE THE EXISTENCE OF SUCH A SERIOUS DEFECT IN A CAR WHICH HAS ONLY RUN A LOW MILEAGE OF 47,812 MILES INDICATE

Mileage: 47,812

6/21/2018, MY 2010 MINI COOPER CLUBMAN S DEVELOPED SERIOUS DEFECTS. I DROVE MY CAR ON THE LEFTMOST LANE OF THREE-LANE BOSTON TURNPIKE. CLOSE TO A TRAFFIC LIGHT, I BRAKED TO DECELERATE VEHICLE BUT THE ENGINE SUDDENLY DIED WITHOUT WARNING, WHILE CAR WAS IN MOTION. BOTH BATTERY AND STARTER WORKED. I TRIED MULTIPLE TIMES TO RESTART THE ENGINE IN FAILURE. I BLOCKED TRAFFIC DURING RUSH-HOUR. SEVERAL CARS TOOK ACROSS ROAD CURB AND PASSED TO MY LEFT. IT MADE ME AND MY SON IN DANGEROUS SITUATIONS. UNTIL A TRUCK DRIVER CAME TO HELP ME TO PUSH MY CAR OFF ROAD. AFTER DIAGNOSIS AND ANALYSIS IN LOCAL AUTO SHOP, MECHANIC FOUND OUT THE VEHICLE COMPUTER ENGINE CONTROL MODULE (ECM) WAS FAULTY, NOT SUPPLYING POWER TO THE IGNITION COILS. I WAS CHARGED $2298.13 TO REPLACE DEFECTIVE ECM AND $150 FOR THE TOWING SERVICE. THE WARRANTY HAS EXPIRED BUT I BELIEVE I AM STILL ENTITLED TO A FREE REPAIR BECAUSE THE EXISTENCE OF SUCH A SERIOUS DEFECT IN A CAR WHICH HAS ONLY RUN A LOW MILEAGE OF 47,812 MILES INDICATE

Mileage: 47,812

6/21/2018, MY 2010 MINI COOPER CLUBMAN S DEVELOPED SERIOUS DEFECTS. I DROVE MY CAR ON THE LEFTMOST LANE OF THREE-LANE BOSTON TURNPIKE. CLOSE TO A TRAFFIC LIGHT, I BRAKED TO DECELERATE VEHICLE BUT THE ENGINE SUDDENLY DIED WITHOUT WARNING, WHILE CAR WAS IN MOTION. BOTH BATTERY AND STARTER WORKED. I TRIED MULTIPLE TIMES TO RESTART THE ENGINE IN FAILURE. I BLOCKED TRAFFIC DURING RUSH-HOUR. SEVERAL CARS TOOK ACROSS ROAD CURB AND PASSED TO MY LEFT. IT MADE ME AND MY SON IN DANGEROUS SITUATIONS. UNTIL A TRUCK DRIVER CAME TO HELP ME TO PUSH MY CAR OFF ROAD. AFTER DIAGNOSIS AND ANALYSIS IN LOCAL AUTO SHOP, MECHANIC FOUND OUT THE VEHICLE COMPUTER ENGINE CONTROL MODULE (ECM) WAS FAULTY, NOT SUPPLYING POWER TO THE IGNITION COILS. I WAS CHARGED $2298.13 TO REPLACE DEFECTIVE ECM AND $150 FOR THE TOWING SERVICE. THE WARRANTY HAS EXPIRED BUT I BELIEVE I AM STILL ENTITLED TO A FREE REPAIR BECAUSE THE EXISTENCE OF SUCH A SERIOUS DEFECT IN A CAR WHICH HAS ONLY RUN A LOW MILEAGE OF 47,812 MILES INDICATE

Mileage: 47,812

THE HIGH PRESSURE FUEL PUMP (HPFP) FAILED AT 88400 MILES AND I HAD TO PAY OVER $1300 TO HAVE IT REPLACED. MINI COOPER ISSUED AN EXTENDED WARRANTY ON SELECT 2007-2009 MODELS TO REPLACE THE HPFP AT NO CHARGE BECAUSE OF THIS HPFP PROBLEM IN SO MANY OF THEIR VEHICLES WITH THE R14 ENGINE. OUR VEHICLE WAS MANUFACTURED IN SEPTEMBER OF 2009. MINI COOPER IS SAYING THAT OUR VEHICLE IS NOT COVERED BY THEIR WARRANTY. I BELIEVE THIS FUEL PUMP WAS ONE OF THE FAULTY UNITS THAT PROMPTED THE REQUIREMENT AND APPLICATION OF THE WARRANTY EXTENSION AND THAT MINI SHOULD REIMBURSE US FOR THE TOTAL COST OF REPLACEMENT PLUS TAX. THE VEHICLE STARTED ACTING UP WHEN IT WAS STARTED IN A STATIONARY POSITION.

Mileage: 88,400

TIMING CHAIN TENSIONER MAKES VERY LOUD RATTLE WHEN ENGINE IS COLD. REQUIRES REPLACEMENT. COST $1500. KNOWN ISSUE BY MINI BUT THEY ARE UNWILLING TO REPAIR OR RECALL

THE VEHICLE IS A 2010 AND WAS PURCHASED NEW. IN 2012 THE VEHICLE WAS BROUGHT IN TO THE DEALER BECAUSE IT IDLED AND RAN ROUGH. THE DEALER REPAIRED AND/OR REPLACED THE TIMING CHAIN. IT HAD APPROXIMATELY 10,000 MILES ON IT. IN SEPTEMBER 2015 THE VEHICLE WAS AGAIN BROUGHT IN TO THE DEALER BECAUSE IT IDLED AND RAN ROUGH. THE DEALER AGAIN REPAIRED AND/OR REPLACED THE TIMING CHAIN. THE VEHICLE HAS APPROXIMATELY 23,000 MILES ON IT. AS OF TODAY, 10/07/15, THIS VEHICLE IS LEAKING OIL AND THE DEALER WILL NEED TO BE CONTACTED FOR REPAIRS. I HAVE ALL SERVICE RECEIPTS FOR REVIEW.

Mileage: 23,000

RATTLING SOUND DURING START UP AND EARLY IN IN DRIVING SEQUENCES, THAT COMES ALONG WITH A LOSS OF POWERE OR ACCELERATION. THE RATTLING SOUND CAN BE HEARD FROM THE UPPER RIGHT SIDE OF THE ENGINE (PASSENGER SIDE) . *TR

Mileage: 34,630

COLD START KNOCKING NOISE, AFTER DRIVING OUT MY LOT THE ENGINE WILL SUDDENLY TURN OFF AND HAVE TO START UP AGAIN. RATTLING SOUND CONTINUES.... *JS

Mileage: 45,000

2010 MINI CLUBMAN S TIMING CHAIN BROKE. SLOWED WITH NO POWER ACCELERATION. THEN NOTHING. INSTANTLY SHATTERED INTO PIECES. (PRODUCED "DEATH RATTLE" AND AND THEN SHATTERED.) *TR

MY 2010 COOPER CLUBMAN S RECENTLY HAD ITS TIMING CHAIN SUDDENLY AND WITHOUT WARNING FAIL. THE VEHICLE HAS BEEN MAINTAINED ACCORDING TO MINI'S SUGGESTED MAINTENANCE SCHEDULE SINCE I FIRST PURCHASED IT. IN FACT, I WAS ON MY WAY TO A SCHEDULED SERVICING OF THE VEHICLE WHEN THE MOTOR FAILED. IT STARTED WITH A LOUD RATTLING NOISE FROM THE MOTOR, WHICH MADE THE CAR INTERMITTENTLY SOUND LIKE EITHER A DIESEL ENGINE OR A CHAINSAW SLICING THROUGH SOMETHING. THEN AS I SLOWED DOWN IN TRAFFIC, THE RPMS ON THE CAR BEGAN TO SPASTICALLY JUMP. I WAS FORTUNATE THAT A BUSINESS COMPLEX PARKING LOT WAS IMMEDIATELY ACCESSIBLE. AS I BROUGHT THE CAR TO A STOP IN THE LOT, THE MOTOR CUT OUT AND REFUSED TO START. I WAS LESS THAN A HALF MILE FROM THE DEALERSHIP SERVICE CENTER! THE SERVICE REP FIRST TOLD ME MY TIMING CHAIN HAD SLIPPED. THEN SHE CALLS BACK THREE HOURS LATER TO TELL ME THERE'S REASON TO BELIEVE THAT A VALVE ISN'T UNDER COMPRESSION. THIS MORNING SHE INFORMS ME THAT I'M LOOKING AT POSSIBLY REPLACING M

Mileage: 55,000

MY 2010 COOPER CLUBMAN S RECENTLY HAD ITS TIMING CHAIN SUDDENLY AND WITHOUT WARNING FAIL. THE VEHICLE HAS BEEN MAINTAINED ACCORDING TO MINI'S SUGGESTED MAINTENANCE SCHEDULE SINCE I FIRST PURCHASED IT. IN FACT, I WAS ON MY WAY TO A SCHEDULED SERVICING OF THE VEHICLE WHEN THE MOTOR FAILED. IT STARTED WITH A LOUD RATTLING NOISE FROM THE MOTOR, WHICH MADE THE CAR INTERMITTENTLY SOUND LIKE EITHER A DIESEL ENGINE OR A CHAINSAW SLICING THROUGH SOMETHING. THEN AS I SLOWED DOWN IN TRAFFIC, THE RPMS ON THE CAR BEGAN TO SPASTICALLY JUMP. I WAS FORTUNATE THAT A BUSINESS COMPLEX PARKING LOT WAS IMMEDIATELY ACCESSIBLE. AS I BROUGHT THE CAR TO A STOP IN THE LOT, THE MOTOR CUT OUT AND REFUSED TO START. I WAS LESS THAN A HALF MILE FROM THE DEALERSHIP SERVICE CENTER! THE SERVICE REP FIRST TOLD ME MY TIMING CHAIN HAD SLIPPED. THEN SHE CALLS BACK THREE HOURS LATER TO TELL ME THERE'S REASON TO BELIEVE THAT A VALVE ISN'T UNDER COMPRESSION. THIS MORNING SHE INFORMS ME THAT I'M LOOKING AT POSSIBLY REPLACING M

Mileage: 55,000

MY FATHER PURCHASED A 2010 MINI COOPER CLUBMAN S IN LATE 2009. HE HAS MAINTAINED PROPER MAINTENANCE ON THE CAR SINCE DAY ONE. IN FEBRUARY 2014 HE GAVE THE CAR TO ME. THE CAR ONLY HAS 57,000 MILES ON IT AND WE NOTICED THAT THE TRANSMISSION WAS SLIPPING AND WE TOOK IT TO MINI OF LOUISVILLE. THEY HAD THE CAR FOR OVER 1 MONTH TO REPLACE THE VALVE BODY BECAUSE THE PART WAS ON NATIONAL BACKORDER. WE WERE ADVISED THAT IF WE CONTINUED TO DRIVE THE VEHICLE IT COULD CAUSE THE TRANSMISSION TO FAIL EVEN WHILE DRIVING. IF IT IS ON NATIONAL BACKORDER, AND FOR OVER 30 DAYS, I WONDER HOW MANY OTHER MINI'S ARE HAVING THE SAME REPAIRS. THE TOTAL COST FOR THE REPAIRS WERE JUST UNDER $2800. THE CAR HAS LESS THAN 60K MILES ON IT AND WAS JUST SLIGHTLY OVER THE WARRANTY, WHERE IT WOULD HAVE BEEN FIXED AT NO CHARGE. BOTH MY HUSBAND AND I HAVE NOTICED THAT THE TRANSMISSION IS STILL SLIPPING AND IS WORSE THAN IT WAS BEFORE THE REPAIRS AND WE HAVE ONLY HAD THE CAR BACK FOR 3 DAYS. I HAVE READ MANY PEOPLE HAVING

Mileage: 57,000

FIRST INCIDENT: ON A HOT DAY, VEHICLE WAS PARKED, DRIVERS SEAT OCCUPIED AND RECLINED. AIR BAG LIGHT ILLUMINATES UPON RESTART OF VEHICLE. FAULT WAS RESET BY DEALER WITH NO EXPLANATION. SECOND TIME SAME SITUATION; HOT DAY, PARKED, DRIVER SEAT OCCUPIED AND RECLINED, AIRBAG LIGHT ILLUMINATES UPON RESTART. DEALER REPLACED AIR BAG DUE TO ELECTRICAL CABLE FOR DRIVERS SEAT AIRBAG BEING NEARLY CUT IN TWO BY SHARP EDGE OF SEAT FRAME. *TR

FIRST INCIDENT: ON A HOT DAY, VEHICLE WAS PARKED, DRIVERS SEAT OCCUPIED AND RECLINED. AIR BAG LIGHT ILLUMINATES UPON RESTART OF VEHICLE. FAULT WAS RESET BY DEALER WITH NO EXPLANATION. SECOND TIME SAME SITUATION; HOT DAY, PARKED, DRIVER SEAT OCCUPIED AND RECLINED, AIRBAG LIGHT ILLUMINATES UPON RESTART. DEALER REPLACED AIR BAG DUE TO ELECTRICAL CABLE FOR DRIVERS SEAT AIRBAG BEING NEARLY CUT IN TWO BY SHARP EDGE OF SEAT FRAME. *TR