2016 MERCEDES-BENZ SPRINTER 2500

STRUCTURE:BODY

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015. The affected vehicles may have had multiple layers of paint applied, and as a result, in a crash, the windows may s

SEAT BELTS:FRONT:ANCHORAGE

Midwest Automotive Designs, LLC (Midwest) is recalling certain model year 2016 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2016, to September 30, 2016, equipped with certain left side seat adjusters, model number 486077 manufactured by Atwood. The affected seat adjusters may

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.

STRUCTURE:BODY:ROOF AND PILLARS

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015, to April 30, 2016. The affected vehicles are confi

POWER TRAIN:DRIVELINE:DRIVESHAFT

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500/3500 vehicles. The affected vehicles were manufactured without a driveshaft catch strap, allowing a loose driveshaft to strike the fuel tank.

EQUIPMENT:OTHER:LABELS

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015. The affected vehicles have a tire pressure label that incorrectly states a higher maximum load capacity than the vehi

EQUIPMENT:OTHER:LABELS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles. The label on the B-pillar may state a higher maximum vehicle load capacity than the vehicle is designed for. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Cert

SEAT BELTS:REAR/OTHER

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured March 1, 2016, to May 31, 2016. The bolts connecting the lower seat belt connection to the rear bench seat may not have been properly tightened.

EQUIPMENT:OTHER:LABELS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Sprinter 2500 and Sprinter 3500 vehicles, equipped with folding seats (sales code S20). The unloaded vehicle weight (UVW) label on these incomplete vehicles may be incorrect.

AIR BAGS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans. These vehicles were manufactured without a reinforcement plate and protective bracket on the air bag control unit. As a result, the air bag control unit m

EQUIPMENT

Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the driver frontal air bag modules used as original equipment or replac

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or rep

POWER TRAIN:DRIVELINE:DRIVESHAFT

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles and Freightliner Sprinter 2500 and 3500 vehicles. The bracket for the center support bearing of the drive shaft may not have been properly welded.

EQUIPMENT:OTHER:LABELS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles equipped with reinforced front axles. The affected vehicles have tire labels on the B-pillar that list a tire pressure that is too low.

The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.

The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.

The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on o

The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on o

Had 2 rims develop cracks causing loss of air pressure in tires. 1st occurred at approx. 45000 miles (2019), 2nd occurred at 110000 (2023). Both failures occurred to area of rim where welds to lock in center (with lug holes) on outer rim (where tire sits) are situated. Both failures manifested as small air leak then suddenly crack increases in size dramatically to where tire can only hold air for a few hours before deflating fully

The check engine light came on in the Sprinter van. There is a Hissing noise coming from the engine when accelerating. The Sprinter van loses speed when on the highway. The vehicle could not keep up with traffic on the road. The Mercedes Benz dealer, Ft. Mitchell, Kentucky has inspected the vehicle and stated that it has a defective intake manifold. This vehicle has 140,000 miles at this time. At this time the van has not been repaired, the cost is $3132.77

The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.

There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.

My 2016 Sprinter is suffering from a failing EGR valve that's causing intermittent power loss. The issue started after only 25000mi on the odometer. No errors are shown, nothing indicates malfunction. The problem is quite severe and presenting itself through random power loss. When accelerating the car will jerk and lose acceleration force suddenly. Driving uphill is the worst and producing constant jerking. Once moving at a good speed it's less notable but still present. The main safety concern is that the behavior is unpredictable and in situations where it's necessary to accelerate into a road with traffic, this can lead to a hazardous when the car doesn't accelerate as intended. In multiple occasions I was unable to properly speed up and get moving and thus blocking traffic behind me and forcing them to slow down or change lanes. The Mercedes dealer diagnosed a malfunctioning EGR valve on the edge of failing completely which would put the Sprinter in "limp home mode" which has limi

The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.

Mileage: 50,600

The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.

Mileage: 50,600

MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.

MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.

MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.

I'VE OWNED THIS CAR 2 YEARS. IN THE SUMMER TIME WHEN WE TURN ON THE A/C THERE IS A BAD ODOR COMING OUT OF THE VENTS. ONLY IN THE SUMMER IT'S NOT A PLEASANT SMELL. DURING THE WINTER TIME LAST YEAR WAS A GASOLINE SMELL BUT THAT GOT FIXED. I WOULD LIKE FOR YOU TO LOOK INTO IT PLEASE IT'S A MOLDY SMELL.

THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.

Mileage: 35,000

THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.

Mileage: 35,000

THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.

Mileage: 35,000