1998 MERCEDES-BENZ E CLASS

I AM WRITING REGARDING AN INVESTIGATION INTO MERCEDES BENZ E300 (W210 CHASSIS) FAILURES. WHILE DRIVING ON THE MASSACHUSETTS TURNPIKE, ROUTE 90 ON MONDAY, MY SPRING PERCH FAILED, BROKE AWAY FROM THE VEHICLE AND WAS LOST ON THE HIGHWAY. THE PERCH LET GO WITH A VERY LOUD BANG, THEN A PRONOUNCED BUMP (PRESUMABLY AS THE REAR TIRE DROVE OVER THE SPRING ASSEMBLY.) THE CAR SUDDENLY DROPPED HARD ON THE FRONT RIGHT BUMP STOPS. LOTS OF WARNING LIGHTS - BAS, ASR, ETC. I THOUGHT I BLEW A TIRE OR HIT SOME ROAD DAMAGE. SURPRISINGLY, JUST A LITTLE SWERVE IN THE LEFT LANE AND I MADE IT TO THE RIGHT SHOULDER AFTER A 1/4 MILE. I HAD HEARD OF THE SPRING PERCH FAILURES FROM THE USER FORUMS AT WWW.MERCEDESSHOP.COM. AT THIS POINT I WAS PRETTY SURE IT WAS A PERCH OR POSSIBLY SOMETHING WORSE BECAUSE THERE WAS NO TIRE SMOKE, BURNING OR NOISE. I CHECKED THE TIRES & DROVE IT 15 MILES HOME. PUT IT UP ON JACKS & FOUND NO SPRING AT ALL & SOME DISCONNECTED SENSOR WIRES. DROVE IT 10 MILES TO MY INDEPENDENT SHOP. W

Mileage: 201,500

I AM WRITING REGARDING AN INVESTIGATION INTO MERCEDES BENZ E300 (W210 CHASSIS) FAILURES. WHILE DRIVING ON THE MASSACHUSETTS TURNPIKE, ROUTE 90 ON MONDAY, MY SPRING PERCH FAILED, BROKE AWAY FROM THE VEHICLE AND WAS LOST ON THE HIGHWAY. THE PERCH LET GO WITH A VERY LOUD BANG, THEN A PRONOUNCED BUMP (PRESUMABLY AS THE REAR TIRE DROVE OVER THE SPRING ASSEMBLY.) THE CAR SUDDENLY DROPPED HARD ON THE FRONT RIGHT BUMP STOPS. LOTS OF WARNING LIGHTS - BAS, ASR, ETC. I THOUGHT I BLEW A TIRE OR HIT SOME ROAD DAMAGE. SURPRISINGLY, JUST A LITTLE SWERVE IN THE LEFT LANE AND I MADE IT TO THE RIGHT SHOULDER AFTER A 1/4 MILE. I HAD HEARD OF THE SPRING PERCH FAILURES FROM THE USER FORUMS AT WWW.MERCEDESSHOP.COM. AT THIS POINT I WAS PRETTY SURE IT WAS A PERCH OR POSSIBLY SOMETHING WORSE BECAUSE THERE WAS NO TIRE SMOKE, BURNING OR NOISE. I CHECKED THE TIRES & DROVE IT 15 MILES HOME. PUT IT UP ON JACKS & FOUND NO SPRING AT ALL & SOME DISCONNECTED SENSOR WIRES. DROVE IT 10 MILES TO MY INDEPENDENT SHOP. W

Mileage: 201,500

1998 MERCEDES BENZ E-320, SPEED <15 MPH HAD THE FRONT DRIVERS SIDE COIL SPRING EJECTED AND HOUSING COMPLETELY SEPARATED FROM THE VEHICLE MAKING THE FRONT END DROP DOWN ONTO DRIVER'S SIDE FRONT TIRE WITHOUT WARNING. THE IMPINGEMENT OF THE BODY ONTO THE TIRE AND WHEEL AND/OR THE SPRING ITSELF PRECLUDED ANY STEERING CONTROL. THE COIL SPRING MOUNT OR "SADDLE" HAD SEPARATED FROM THE WELDED POINT TO THE FRAME OF THE VEHICLE. MERCEDES OFFERRED TO PAY 25% OF THE REPAIR FEE DUE TO EXCELLENT SERVICE HISTORY. WE REPEATEDLY REQUESTED A TEAM FROM MERCEDES TO INSPECT THE VEHICLE BECAUSE THIS VEHICLE WOULD BE IDEAL TO INVESTIGATE AS NO OTHER COMPLICATING CRASH HAD OCCURRED. THEY REFUSED THIS. MY WIFE AUTHORIZED THE REPAIR BUT INDICATED THAT WE WANTED ALL PARTS TO BE SAVED FOR FURTHER INVESTIGATION BY THE NHTSA.THE NEXT DAY, THE SERVICE MANAGER REPORTED THAT MERCEDES NOW OFFERRED TO PAY 50% OF REPAIR COST BUT REQUIRED A "WAIVER" BE SIGNED TO "HOLD HARMLESS" MERCEDES FROM ANY FURTHER PROBLEMS OR

Mileage: 153,000

THE MAIN SUSPENSION SPRING FROM MY RIGHT FRONT TIRE FELL OUT ON THE GARAGE FLOOR AND THE CAR CAME DOWN ON THE TIRE. TWO MINUTES BEFORE THE CAR WAS BEING DRIVING ON THE ROAD AT 60 MPH AND HAD IT OCCURRED TWO MINUTES EARLIER SOMEONE WOULD HAVE BEEN KILLED. THE POOR DESIGN BY MB CAUSED EXCESS RUST AND FAILURE IN THE 1998 MB E320. *JB

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT A STOP, THE FRONT END COLLAPSED TO THE GROUND. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHERE IT WAS DETERMINED THE FRONT DRIVER SIDE SPRING PERCH FRACTURED. THE SPRING PERCH WAS REPLACED.

Mileage: 140,000

CATALYTIC CONVERTER LOOSE INSIDE, RATTLING AND NOT EFFECTIVE. *JB

Mileage: 156,982

TIRES OVERHEAT ON DRY PAVEMENT, CAUSING DECREASED TRACTION. *JB

Mileage: 150,000

1998 MERCEDES BENZ E300D 4 DOOR SEDAN. DRIVER SIDE SPRING PERCH IS RUSTED AND PEELING OFF DUE TO MANUFACTURING DEFECT. CAR IS DANGEROUS TO DRIVE THE WAY IT IS DUE TO THIS MANUFACTURING DEFECT. THIS IS A KNOWN ISSUE ON MANY FORUMS AS WELL AS PREVIOUS HTTP://WWW.MERCEDESSHOP.COM/SHOPFORUM/SHOWTHREAD.PHP3?T=95228. *NM

Mileage: 115,000

AUTOMATIC TRANSMISSION FAILURE, STAYS ON 1ST. GEAR (ROUGH RUN). TOOK TO AUTHORIZED MBZ REPAIR STATION, THEY RESET THE "COMPUTER" AND RUN APPROXIMATELY 450 MILES OK AND AGAIN THE SAME PROBLEM. WENT BACK AND THEY FLUSHED THE TRANSMISSION AND RESET AGAIN "COMPUTER FAULTS", RUN AGAIN FOR 75 MILES AND SAME PROBLEM, AND SO ON.....*JB

Mileage: 139,500

I HAVE NOTICED THAT THE SPRING/COIL UPPER TOWER PERCH HAS ALMOST COME COMPLETELY OFF. IF IT COMES OFF WHILE DRIVING THE CAR WILL LOSE CONTROL. IT HAS COME LOOSE DUE TO RUST,WHICH IS A PROBLEM WITH THESE CARS. THESE CARS WILL RUST ON THE BODY PANELS AND ON THE SUSPENSION COMPONENTS. PLEASE GET MERCEDES TO DO SOMETHING ABOUT THIS. NOT ONLY IS IT BAD COSMETICALLY, BUT THE RUSTED SPRING PERCHES CAN BE CATASTROPHIC.*AK

Mileage: 95,000

WHEN THE ENGINE GETS HOT, IT STALLS . AFTER IT COOLS FOR SOME TIME, IT RE-STARTS. IT HAPPENED TO ME ON THE HIGHWAY (BUMPER-TO-BUMPER TRAFFIC). FOUND OUT FROM THE MERCEDEZ FORUM THAT IT IS A KNOWN PROBLEM DUE TO CRANSHAFT POSITION SENSOR. IT HAS HAPPENED TO NUMBER OF PEOPLE.

Mileage: 52,000

DRIVING CAR AT 55 MILES PER HOUR WHEN HARMONIC BALANCER FAILED, LOST POWER STEERING, WAS ABLE TO DIRECT CAR TO SIDE OF ROAD. HAD CAR TOWED TO SHOP WHO DIAGNOSED PROBLEM, SUGGESTING IT GO TO A MB DEALER. HAD CAR TOWED TO DEALER WHERE

Mileage: 70,000

DRIVING CAR AT 55 MILES PER HOUR WHEN HARMONIC BALANCER FAILED, LOST POWER STEERING, WAS ABLE TO DIRECT CAR TO SIDE OF ROAD. HAD CAR TOWED TO SHOP WHO DIAGNOSED PROBLEM, SUGGESTING IT GO TO A MB DEALER. HAD CAR TOWED TO DEALER WHERE

Mileage: 70,000

DRIVING CAR AT 55 MILES PER HOUR WHEN HARMONIC BALANCER FAILED, LOST POWER STEERING, WAS ABLE TO DIRECT CAR TO SIDE OF ROAD. HAD CAR TOWED TO SHOP WHO DIAGNOSED PROBLEM, SUGGESTING IT GO TO A MB DEALER. HAD CAR TOWED TO DEALER WHERE

Mileage: 70,000

DRIVING CAR AT 55 MILES PER HOUR WHEN HARMONIC BALANCER FAILED, LOST POWER STEERING, WAS ABLE TO DIRECT CAR TO SIDE OF ROAD. HAD CAR TOWED TO SHOP WHO DIAGNOSED PROBLEM, SUGGESTING IT GO TO A MB DEALER. HAD CAR TOWED TO DEALER WHERE

Mileage: 70,000

THE GEAR MOVED ON ITS OWN WITH NO KEY. VEHICLE WAS IN PARK A CHILD ENTERED THE VEHICLE, MOVED THE GEAR FROM PARK TO NEUTRAL, AND VEHICLE ROLLED BACK, GOING THROUGH A FENCE AND STRIKING A TREE. THE CHILD SUSTAINED NO INJURIES.*AK

Mileage: 98,000

THE CRANK SHAFT BALANCER DISINTEGRATED WITHOUT WARNING AT 40 MPH RESULTING IN PARTIAL ENGINE DESTRUCTION, OIL PAN, FAN BLADE, FAN SHROUD, IDLER PULLEY,ETC. CAR WAS TOWED TO LOCAL MBZ DEALER AND REPAIRS COMPLETED IN AMOUNT OF $1584. MBZ AREA REPRESENTATIVE OFFERED 50% COMPENSATION. MERCEDES BENZ OF NORTH AMERICA WAS CONTACTED FOR COMPENSATION OF BALANCE AND OBLIGED. THE FAILURE OF THE CRANKSHAFT BALANCER MIGHT NOT BE CONSIDERED A SAFETY ISSUE BUT THE IMMEDIATE LOSS OF POWER STEERING AS A RESULT MOST CERTAINLY IS! I HATE TO THINK OF WHAT WOULD HAVE BEEN THE CONSEQUENCES OF THIS INCIDENT HAD MY WIFE BEEN DRIVING THE CAR IN TRAFFIC AT FREEWAY SPEED. IT IS MY CONTENTION THAT MERCEDES BENZ WAS WELL AWARE OF THIS PROBLEM (REFERENCE: MB TECH TIPS, DECEMBER 1, 2000, PAGE 4) AS WELL AS 27 PAGES OF OWNER DOCUMENTATION ON AN INTERNET WEBSITE < MERCEDESSHOP.COM > IT SHOULD HAVE BEEN THE SUBJECT OF A SAFETY RECALL! *AK

Mileage: 49,035

THE TOP SPRING MOUNT BROKE OFF THE SUSPENSION. THE VEHICLE WAS TAKEN FOR A CHECK UP, AND IT WAS FOUND THAT THE OTHER RIGHT SPRING NEEDED REPAIRS AS WELL. THE DEALER REPAIRED THE PROBLEM FREE OF CHARGE. *AK THE CONSUMER FOUND THAT THIS WAS A COMMON PROBLEM. *SC *JB

FAILURE OF HARMONIC CRANKSHAFT BALANCER IN 1998 MERCEDES BENZ E320. *LA

Mileage: 74,000

1998 MERCEDES BENZ E320 DASHBOARD HAS DEVELOPED SEVERE CRACKS AROUND THE PASSENGER-SIDE AIRBAG.

Mileage: 56,000