Total Complaints
44 filings
MERCEDES-BENZ C220 · model year
1996 MERCEDES-BENZ C220
44 NHTSA complaints, 6 crash reports. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 1996MERCEDES-BENZC220 carries 44 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 6 crashes, 2 fires, 3 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 1996 C220 is electrical system with 10 filings, followed by electrical system:wiring (5) and fuel/propulsion system (4). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause.
NHTSA currently has 15 investigation files overlapping the 1996 C220. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
44
Complaints
6
Crashes
2
Fires
3
Injuries
0
Deaths
Crashes Reported
6 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ELECTRICAL SYSTEM | 10 |
| ELECTRICAL SYSTEM:WIRING | 5 |
| FUEL/PROPULSION SYSTEM | 4 |
| ENGINE AND ENGINE COOLING | 3 |
| SEAT BELTS:FRONT:ANCHORAGE | 2 |
| AIR BAGS:FRONTAL | 2 |
| ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | 2 |
| VEHICLE SPEED CONTROL | 2 |
| ENGINE | 2 |
| SUSPENSION | 2 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | 1 |
| EQUIPMENT:APPLIANCE:AIR CONDITIONER | 1 |
| FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | 1 |
| STRUCTURE:BODY:DOOR | 1 |
| PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE | 1 |
Recent Complaints
20181025AIR BAGS
TAKATA RECALL; MAYBE. I WAS DRIVING ON FWY-405, HEADING SOUTH, IT WAS AROUND 4:00PM. I WAS GOING THE TRAFFIC SPEED. THERE WAS NO TRAFFIC JAM. MY SPEED WAS BETWEEN 60 AND 65 MPH (THE VEHICLE WAS IN MOTION). I DIDN'T HIT MY BREAKS, I WAS DRIVING UNDER THE CONDITIONS I JUST STATED; THEN ALL THE SUDDEN MY AIRBAGS DEPLOYED. FIRST THE DRIVER SIDE; THEN IMMEDIATELY (ALMOST SPONTANEOUSLY) THE PASSENGER AIRBAG DEPLOYED TOO. I TRIED MY BEST TO CONTROL THE CAR. THE CAR CAME TO A COMPLETE STOP TAKING TWO LANES ON THE HIGHWAY. ENGINE HAD STOPPED. THE AFTERMATH AFTER: COMPLETE STOP, SMOKE AND SMILE OF DEPLOYED AIRBAGS, A NON STOP SOUND OF THE HORN, AND THE CAR WAS NO LONGER IN A DRIVE MODE (IT WAS SHIFTED). I SWITCHED THE CAR KEY AND THE HORN NOISE STOPPED. THEN I CALLED 911.
Mileage: 128,000
20180921ELECTRICAL SYSTEM
WIRING THROUGHOUT VEHICLE IS INSULATED WITH A BIO-DEGRADABLE PLASTIC. SHORTING OUT OF IGNITION AND EMISSION LOOMS KILL MANY WHO STALL ON FREEWAYS AND 'INCONVENIENT SPOTS'. THE INSULATION FLAKES OFF LIKE CORN FLAKES AND ELECTRICAL LOSS IN MANY LOOMS DISABLE AND IMPERAL OCCUPANTS.
Mileage: 217
20170130CrashSERVICE BRAKES
CAR HAD UNEXPECTED ACCELLERATON DURING A ROUTINE LEFT HAND TURN IN AN INTERSECTION WITH A STOP LIGHT; PRESSING ON THE BRAKE DID NOT STOP THE FORWARD ACCELLERATION, CRASHED INTO A WALL, OCCURRED DOWNTOWN, EARLY EVENING, NO OTHER VEHICLES OR PEDESTRIANS HIT; DRIVER INJURED. DRIVER NOT UNDER THE INFLUENCE OF DRUGS OR ALCOHOL. BRAKES SERVICED RECENTLY.
Mileage: 110,000
20170130CrashFUEL/PROPULSION SYSTEM
CAR HAD UNEXPECTED ACCELLERATON DURING A ROUTINE LEFT HAND TURN IN AN INTERSECTION WITH A STOP LIGHT; PRESSING ON THE BRAKE DID NOT STOP THE FORWARD ACCELLERATION, CRASHED INTO A WALL, OCCURRED DOWNTOWN, EARLY EVENING, NO OTHER VEHICLES OR PEDESTRIANS HIT; DRIVER INJURED. DRIVER NOT UNDER THE INFLUENCE OF DRUGS OR ALCOHOL. BRAKES SERVICED RECENTLY.
Mileage: 110,000
20151006ELECTRICAL SYSTEM
WAS DRIVING ALL GAGES WENT CRAZY STARTED TO BACK FIRE AND DIED ON THE HIGHWAY SO I HAD A FRIEND PULL OFF THE HIGHWAY BACK TO THE SHOP THE SHOP SAID THE WIRING HARESS WAS DEGRADED AND IT COST 2,700 DOLLAR TO FIX THE SAD THING IS THIS CAR ONLY HAS 30,000 MILE'S
Mileage: 30,000
20151006FUEL/PROPULSION SYSTEM
WAS DRIVING ALL GAGES WENT CRAZY STARTED TO BACK FIRE AND DIED ON THE HIGHWAY SO I HAD A FRIEND PULL OFF THE HIGHWAY BACK TO THE SHOP THE SHOP SAID THE WIRING HARESS WAS DEGRADED AND IT COST 2,700 DOLLAR TO FIX THE SAD THING IS THIS CAR ONLY HAS 30,000 MILE'S
Mileage: 30,000
20151006VEHICLE SPEED CONTROL
WAS DRIVING ALL GAGES WENT CRAZY STARTED TO BACK FIRE AND DIED ON THE HIGHWAY SO I HAD A FRIEND PULL OFF THE HIGHWAY BACK TO THE SHOP THE SHOP SAID THE WIRING HARESS WAS DEGRADED AND IT COST 2,700 DOLLAR TO FIX THE SAD THING IS THIS CAR ONLY HAS 30,000 MILE'S
Mileage: 30,000
20150211ELECTRICAL SYSTEM
MY 1996 MERCEDES C220 HAS A DEFECTIVE ENGINE WIRING HARNESS. THE CHECK ENGINE LIGHT CAME ON AND I TOOK IT TO MY MECHANIC. HE TOLD ME THAT THIS WAS DUE TO THE TYPE OF INSULATION THAT MERCEDES USED FOR THE WIRING AND THE ENGINE HARNESS NEEDS TO BE REPLACED ASAP. MERCEDES USED A BIO-DEGRADABLE WIRE COVER THAT WITH HIGH TEMPS CRACKS AND FALLS OFF. THIS HAS CAUSED THE ENGINE TO RUN ROUGH, STALL AND LOOSE POWER AND IS NOT SAFE TO DRIVE IN TRAFFIC. THIS SHOULD HAVE BEEN TAKEN CARE OF WITH A RECALL BY MERCEDES. MERCEDES HAS BEEN OF NO HELP EXCEPT FOR ME TO PAY TO HAVE IT REPAIRED. *TR
20150211FUEL/PROPULSION SYSTEM
MY 1996 MERCEDES C220 HAS A DEFECTIVE ENGINE WIRING HARNESS. THE CHECK ENGINE LIGHT CAME ON AND I TOOK IT TO MY MECHANIC. HE TOLD ME THAT THIS WAS DUE TO THE TYPE OF INSULATION THAT MERCEDES USED FOR THE WIRING AND THE ENGINE HARNESS NEEDS TO BE REPLACED ASAP. MERCEDES USED A BIO-DEGRADABLE WIRE COVER THAT WITH HIGH TEMPS CRACKS AND FALLS OFF. THIS HAS CAUSED THE ENGINE TO RUN ROUGH, STALL AND LOOSE POWER AND IS NOT SAFE TO DRIVE IN TRAFFIC. THIS SHOULD HAVE BEEN TAKEN CARE OF WITH A RECALL BY MERCEDES. MERCEDES HAS BEEN OF NO HELP EXCEPT FOR ME TO PAY TO HAVE IT REPAIRED. *TR
20141214ENGINE
ENGINE WIRING HARNESS, AND THE TRANSMISSION WIRING HARNESS, AND THE IGNITION COIL HARNESS, DEGRADED TO THE POINT THERE ARE INCHES AND INCHES OF BARE WIRES TOUCHING AND SHORTING WHICH CAUSES THE ENGINE TO QUIT. ALL THREE SEPARATE HARNESS WHICH RESIDE WITH OTHER HARNESS WHICH HAVE NOT DEGRADED. THE ENGINE QUIT ON THE FREEWAY IN RUSH HOUR TRAFFIC AND NEARLY CAUSED SEVERAL ACCIDENTS AT 65 MILES PER HOUR. REPAIR SHOP WANT $3500 TO CHANGE OUT THE THREE HARNESS WITH NO ASSURANCE THAT THE PROBLEM WILL NOT COME BACK. *TR
Mileage: 94,655
20141214ELECTRICAL SYSTEM
ENGINE WIRING HARNESS, AND THE TRANSMISSION WIRING HARNESS, AND THE IGNITION COIL HARNESS, DEGRADED TO THE POINT THERE ARE INCHES AND INCHES OF BARE WIRES TOUCHING AND SHORTING WHICH CAUSES THE ENGINE TO QUIT. ALL THREE SEPARATE HARNESS WHICH RESIDE WITH OTHER HARNESS WHICH HAVE NOT DEGRADED. THE ENGINE QUIT ON THE FREEWAY IN RUSH HOUR TRAFFIC AND NEARLY CAUSED SEVERAL ACCIDENTS AT 65 MILES PER HOUR. REPAIR SHOP WANT $3500 TO CHANGE OUT THE THREE HARNESS WITH NO ASSURANCE THAT THE PROBLEM WILL NOT COME BACK. *TR
Mileage: 94,655
20141214FUEL/PROPULSION SYSTEM
ENGINE WIRING HARNESS, AND THE TRANSMISSION WIRING HARNESS, AND THE IGNITION COIL HARNESS, DEGRADED TO THE POINT THERE ARE INCHES AND INCHES OF BARE WIRES TOUCHING AND SHORTING WHICH CAUSES THE ENGINE TO QUIT. ALL THREE SEPARATE HARNESS WHICH RESIDE WITH OTHER HARNESS WHICH HAVE NOT DEGRADED. THE ENGINE QUIT ON THE FREEWAY IN RUSH HOUR TRAFFIC AND NEARLY CAUSED SEVERAL ACCIDENTS AT 65 MILES PER HOUR. REPAIR SHOP WANT $3500 TO CHANGE OUT THE THREE HARNESS WITH NO ASSURANCE THAT THE PROBLEM WILL NOT COME BACK. *TR
Mileage: 94,655
20141128SUSPENSION
DURING BRAKE INSPECTION RIGHT FRONT LOWER SUSPENSION CONTROL ARM WAS OBSERVED TO BE ON VERGE OF FAILURE DUE TO INTERNAL RUST OUT OF CONTROL ARM AT THE BALL JOINT JUNCTION. WHEEL WOULD HAVE SEPARATED FROM CONTROL ARM WITHIN A FEW MORE MILES AS THE CONTROL ARM WAS ALREADY SPLIT APART WITH ONLY A THREAD OF METAL REMAINING. FAILURE AT ANY SIGNIFICANT SPEED WOULD LIKELY HAVE BEEN LIFE THREATENING. *TR
Mileage: 158,000
20140904CrashSUSPENSION
UPPER SPRING PERCH RUSTED AWAY FROM CAR CAUSING MY 16YEAR OLD SON TO CRASH. I BOUGHT THE 1996 C220 FOR HIM FOR SAFETY. COME TO FIND OUT THIS IS A COMMON PROBLEM AND MERCEDES SHOULD BE HELD ACCOUNTABLE FOR THIS KNOWN PROBLEM. *TR
Mileage: 167,000
20140904CrashSTRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
UPPER SPRING PERCH RUSTED AWAY FROM CAR CAUSING MY 16YEAR OLD SON TO CRASH. I BOUGHT THE 1996 C220 FOR HIM FOR SAFETY. COME TO FIND OUT THIS IS A COMMON PROBLEM AND MERCEDES SHOULD BE HELD ACCOUNTABLE FOR THIS KNOWN PROBLEM. *TR
Mileage: 167,000
20140609ELECTRONIC STABILITY CONTROL (ESC)
CAR WENT DEAD. *TR
Mileage: 140,000
20130101ELECTRICAL SYSTEM
WHILE ACCELERATING THE MERCEDES C220 WILL SURGE, STALL AND CUT ENGINE POWER OR "CUT OUT". IDLE IS UNSTABLE. WIRING HARNESS INSULATION IS CRUMBLING. *TR
Mileage: 146,000
20130101VEHICLE SPEED CONTROL
WHILE ACCELERATING THE MERCEDES C220 WILL SURGE, STALL AND CUT ENGINE POWER OR "CUT OUT". IDLE IS UNSTABLE. WIRING HARNESS INSULATION IS CRUMBLING. *TR
Mileage: 146,000
20130101ENGINE
WHILE ACCELERATING THE MERCEDES C220 WILL SURGE, STALL AND CUT ENGINE POWER OR "CUT OUT". IDLE IS UNSTABLE. WIRING HARNESS INSULATION IS CRUMBLING. *TR
Mileage: 146,000
20120130ELECTRICAL SYSTEM
RECENTLY THERE WAS AN ISSUE WITH THE CAR. THE TEMPERATURE GAGE WAS SHOWING THE VEHICLE AS HEATING UP. THE TEMP WOULD REACH CLOSE TO 120 F. AFTER FURTHER INVESTIGATION BY OUR MECHANIC, THE VEHICLE NEEDED THE ENTIRE ELECTRICAL WIRING TO BE REPLACED. OUR MECHANIC SAID THAT IF NOT REPLACED, THE CAR WOULD EVENTUALLY CATCH ON FIRE. THE ELECTRICAL WIRING IS FAULTY NOT DUE TO WEAR AND TEAR ON THE CAR BUT SHOULD HAVE BEEN RECALLED BY MERCEDES FOR FAULTY WIRING. THE WIRING HAS COMPLETELY DETERIORATED AND THE WIRES ARE COMPLETELY EXPOSED AND IF THE WIRES HAPPEN TO TOUCH EACH OTHER, THAT IS WHAT WILL CAUSE THE FIRE. IN ORDER TO GET THESE WIRES REPLACED, IT WILL COST WELL OVER $1500.00 TO REPLACE ALL THE WIRING. *TT
Compare 1996MERCEDES-BENZC220 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 1996 MERCEDES-BENZ C220 have?▼
The 1996 MERCEDES-BENZ C220 has 44 NHTSA complaints, 6 crashes, 2 fires, 3 injuries, and 0 deaths reported.
What are the most common problems with the 1996 MERCEDES-BENZ C220?▼
The most-complained component for the 1996 MERCEDES-BENZ C220 is ELECTRICAL SYSTEM with 10 complaints. Other frequently reported areas include ELECTRICAL SYSTEM:WIRING and FUEL/PROPULSION SYSTEM.
Is the 1996 MERCEDES-BENZ C220 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 1996 MERCEDES-BENZ C220; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.