Total Complaints
1 filings
KENWORTH T880 · model year
2024 KENWORTH T880
1 NHTSA complaints, and 7 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2024KENWORTHT880 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2024 T880 is engine with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 7 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 3 investigation files overlapping the 2024 T880. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE | 1 |
Recalls (7)
25V43600026/06/2025
EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn
24V04300025/01/2024
STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 520, 567, and Kenworth T800, T880, W900, and W990 trucks. The bearing journals may not be fully seated in the steering knuckle assemblies, preventing the proper installation of the wheel end hub assemblies.
24V04400025/01/2024
STEERING
PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are require
24V19000020/03/2024
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communi
24V91500009/12/2024
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to
24V90800003/12/2024
STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in a loss of steering control.
25V56900002/09/2025
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T680, T880, and W990 trucks. The 15-inch digital display may fail to display warning lights or vehicle speed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101
Recent Complaints
20250719ENGINE
Injector system keeps truck constantly wanting to do a regen. Too much fuel is being pushed into the particulate filter.
Compare 2024KENWORTHT880 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2024 KENWORTH T880 have?▼
The 2024 KENWORTH T880 has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2024 KENWORTH T880?▼
Yes, the 2024 KENWORTH T880 has 7 recall(s). The most common affected component is EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2024 KENWORTH T880?▼
The most-complained component for the 2024 KENWORTH T880 is ENGINE with 1 complaints. Other frequently reported areas include various components.
Is the 2024 KENWORTH T880 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.