Total Complaints
4 filings
KENWORTH T880 · model year
2018 KENWORTH T880
4 NHTSA complaints, 3 crash reports, and 16 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2018KENWORTHT880 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 3 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2018 T880 is tires with 2 filings, followed by service brakes (1) and electronic stability control (esc) (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 16 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 3 investigation files overlapping the 2018 T880. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
3
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
3 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| TIRES | 2 |
| SERVICE BRAKES | 1 |
| ELECTRONIC STABILITY CONTROL (ESC) | 1 |
Recalls (16)
21V00N00029/12/2021
ELECTRICAL SYSTEM:WIRING
PACCAR Incorporated (PACCAR) is recalling certain 2016-2022 Peterbilt 567, 579, 2021-2022 Peterbilt 536, 2017-2021 Kenworth T880, 2016-2022 Kenworth T680, 2018-2020 Kenworth T440, 2020 Kenworth T270, and 2021 Kenworth T280 vehicles. The methane detection system will not function if the system loses
21V39100026/05/2021
FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL
PACCAR Incorporated (PACCAR) is recalling certain 2018-2021 Peterbilt 337, 348, 365, 367, 520, 567, Kenworth T270, T370, T440, T470, T800 and T880 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
22V27700025/04/2022
STEERING:CRITICAL FASTENERS
PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 Kenworth T270, T370, T440, T470, T660, T680, T880, T800, W900, W990; and 2018-2020 Peterbilt 330, 337, 348, 365, 367, 389, 520, 567, and 579 vehicles. The Dana D-Series axle steer arm fasteners that attach the steering arm to the steering
24V14500023/02/2024
SERVICE BRAKES, AIR:SUPPLY:RESERVOIR/TANK
PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 ve
17V84000022/12/2017
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
PACCAR Incorporated (PACCAR) is recalling certain 2018 Peterbilt 567, 579, Kenworth T680, and T880 trucks, equipped with certain Eaton Endurant and PACCAR AMT transmissions. The transmission control module (TCM) may allow the engine to crank briefly even if the transmission shifter is not in neutra
18V93100021/12/2018
POWER TRAIN:CLUTCH ASSEMBLY
PACCAR Incorporated (PACCAR) is recalling certain 2018-2019 Peterbilt 337, 348, 365, 367, 389, 567, 579 and 587 trucks and 2018-2019 Kenworth C500, T270, T370, T440, T660, T680, T800, T880 and W900 trucks equipped with automated manual transmissions. An internal component in the clutch assembly may
18V65700021/09/2018
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PACCAR Incorporated (PACCAR) is recalling certain 2017-2019 Kenworth C500, T600, T660, T680, T800, T880 and W900 trucks, as well as Peterbilt 367, 386, 389, 567, 579 and 587 trucks, equipped with Cummins ISX15 or X15 diesel engines. In certain driving conditions, such as on a long down-hill grade,
18V81600016/11/2018
EXTERIOR LIGHTING
PACCAR Incorporated (PACCAR) is recalling certain 2013-2019 Kenworth T680 and T880 and Peterbilt 579 trucks, greater than 30 feet long and equipped with side extender mounted intermediate marker lamp/turn signals that do not include a reflex reflector. Since both intermediate side marker lamps and
17V32200016/05/2017
SERVICE BRAKES, AIR
PACCAR Incorporated (PACCAR) is recalling certain 2012-2018 Kenworth T800 and T880 vehicles equipped with Neway ADZ tridem rear suspensions. The brake control airline may be the incorrect size, resulting in an imbalance in the service brake application timing. As such, these vehicles fail to comp
17V10300015/02/2017
FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
PACCAR Incorporated (PACCAR) is recalling certain 2015-2018 Kenworth K370, T680, T880 and 2017-2018 Peterbilt 567 and 579 trucks. The plastic fuel tee fittings on these trucks may leak fuel.
17V44300013/07/2017
FUEL SYSTEM, DIESEL
PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 367, 389, 567, 579 and 587 trucks, and 2018 Kenworth C500, T680, T800, T880 and W900 trucks equipped with Cummins ISX 15L engines. These engines have a fuel pump whose drive gear could possibly slip on its drive shaft, causing a
18V87000007/12/2018
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
PACCAR Incorporated (PACCAR) is recalling certain 2018 Kenworth T680 and T880, and Peterbilt 567 and 579 trucks. The seat belt buckle assemblies on these vehicles may have been glued and not sewn during manufacturing, possibly causing the assembly to come apart under load, such as in the event of a
20V19900006/04/2020
ELECTRONIC STABILITY CONTROL (ESC)
PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lo
19V27500005/04/2019
PARKING BRAKE
PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 T680 and T880 tandem axle vehicles equipped with a parking brake on a single axle and certain models of automated manual transmissions. During cold temperatures, the signal from the park brake pressure switch to the transmission controller
18V09200002/02/2018
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Kenworth T680 and T880 trucks, and Peterbilt 567 and 579 trucks, all equipped with an automated Eaton UltraShift Plus or Eaton Advantage Transmission with right hand stalk shifter. The display that indicates which transmission gear the dri
18V36800001/06/2018
ELECTRONIC STABILITY CONTROL (ESC)
PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 567 and 579 trucks and 2015-2018 Kenworth T660, T680, T800, T880 and W900 trucks. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may no
Recent Complaints
20260107TIRES
See attached document for complaint.
20200806CrashTIRES
I HAVE A HANKOOK TIRE , MODEL AM15+ WITH LABELING ON THE SIDEWALL "MADE IN CHINA" THE SIZE IS 385/65R22.5 THE DOT CODE ON THE TIRE : 1BB31 53H1 3218 THIS DOT CODE IS NOT CORRECT FOR THE ABOVE TIRE. DO YOU RECALL TIRES WITH AN INCORRECT DOT CODE?*DT*JB
20200608CrashSERVICE BRAKES
TL* THE CONTACT OWNED A 2018 KENWORTH T880. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, HE DEPRESSED HIS BRAKE PEDAL AND THE BRAKE PEDAL FAILED WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT VEERED THE VEHICLE TO RIGHT OFF OF THE ROAD AND DROVE INTO A DITCH. A POLICE REPORT WAS FILED AND THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE VEHICLE WAS DESTROYED DUE TO THE ACCIDENT AND WAS TOWED TO AN INDEPENDENT TOW YARD. RECENTLY, THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 20V199000(ELECTRONIC STABILITY CONTROL, SERVICE BRAKES, AIR) WHICH HE LINKED TO HIS FAILURE. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000. *DT*JB
Mileage: 34,000
20200608CrashELECTRONIC STABILITY CONTROL (ESC)
TL* THE CONTACT OWNED A 2018 KENWORTH T880. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, HE DEPRESSED HIS BRAKE PEDAL AND THE BRAKE PEDAL FAILED WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT VEERED THE VEHICLE TO RIGHT OFF OF THE ROAD AND DROVE INTO A DITCH. A POLICE REPORT WAS FILED AND THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE VEHICLE WAS DESTROYED DUE TO THE ACCIDENT AND WAS TOWED TO AN INDEPENDENT TOW YARD. RECENTLY, THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 20V199000(ELECTRONIC STABILITY CONTROL, SERVICE BRAKES, AIR) WHICH HE LINKED TO HIS FAILURE. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000. *DT*JB
Mileage: 34,000
Compare 2018KENWORTHT880 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2018 KENWORTH T880 have?▼
The 2018 KENWORTH T880 has 4 NHTSA complaints, 3 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2018 KENWORTH T880?▼
Yes, the 2018 KENWORTH T880 has 16 recall(s). The most common affected component is ELECTRICAL SYSTEM:WIRING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2018 KENWORTH T880?▼
The most-complained component for the 2018 KENWORTH T880 is TIRES with 2 complaints. Other frequently reported areas include SERVICE BRAKES and ELECTRONIC STABILITY CONTROL (ESC).
Is the 2018 KENWORTH T880 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.