Total Complaints
1 filings
Kenworth T800 · model year
2010 Kenworth T800
1 NHTSA complaints, and 11 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 1
- Recalls
- 11
The verdict
The 2010 Kenworth T800 posts top-quartile complaint standing among its own model-year siblings.
- Top 20%
- fewest complaints, own model years
- 11
- recall campaigns
The 2010KenworthT800 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 1 fire, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2010 T800 is unknown or other with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 11 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 3 investigation files overlapping the 2010 T800. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
1
Fires
0
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2010 Kenworth T800
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| UNKNOWN OR OTHER | 1 |
Recalls (11)
10V53500027/10/2010
SERVICE BRAKES, AIR:DISC:CALIPER
PACCAR IS RECALLING CERTAIN MODEL YEAR KENWORTH T660, T700, T800 AND W900 VEHICLES MANUFACTURED FROM DECEMBER 22, 2008, THROUGH AUGUST 2, 2010, AND EQUIPPED WITH AG400L AIR DISC BRAKES. THE AIR DISC BRAKE CALIPER COULD BE INSTALLED ON THE WRONG SIDE OF THE DRIVE AXLE POTENTIALLY CAUSING INTERFERENC
15V30900026/05/2015
ENGINE AND ENGINE COOLING:ENGINE
PACCAR Incorporated (PACCAR) is recalling certain model year 2010-2016 Kenworth T440, T800, and W900 trucks manufactured August 31, 2009, to April 20, 2015, and 2008-2015 Peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured July 27, 2007, to April 28, 2015, and equipped with certain Cummin
09V49000023/12/2009
STEERING
KENWORTH IS RECALLING MODEL YEAR 2010 T2000, T800, T660 AND W900S TRUCKS MANUFACTURED BETWEEN JULY 1 AND OCTOBER 23, 2009. THE FASTENERS ATTACHING THE STEERING GEAR TO THE FRONT DRIVE BRACKET MAY HAVE RECEIVED INSUFFICIENT TORQUE DURING THE INSTALLATION PROCESS RESULTING IN LESS THAN REQUIRED CLAMP
24V14500023/02/2024
SERVICE BRAKES, AIR:SUPPLY:RESERVOIR/TANK
PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 ve
11V12700023/02/2011
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2012 KENWORTH T2000, T660, T700, T800, AND W900, AS WELL AS MODEL YEAR 2009-2012 PETERBILT 365, 367, 384, 386, 387, 388, 389, AND 587 TRUCKS EQUIPPED WITH PACCAR MX ENGINES. THE OIL MODULE CENTRIFUGAL SPINNER FILTER CAP IN THE PACCAR MX ENGINE MAY BECOME
09V41500021/10/2009
POWER TRAIN:AXLE ASSEMBLY
KENWORTH IS RECALLING MODEL YEAR 2009 THROUGH 2010 T2000, T800, T660 AND W900 TRUCKS MANUFACTURED BETWEEN NOVEMBER 12, 2008 AND SEPTEMBER 30, 2009. THE AXLE U-BOLTS ATTACHING THE AXLE TO THE SUSPENSION LEAF SPRING ON CERTAIN AG400L REAR SUSPENSIONS MAY HAVE RECEIVED INSUFFICIENT FASTENER TORQUE DUR
13V57300018/11/2013
SERVICE BRAKES
PACCAR is recalling certain model year 2007-2014 Kenworth T800 and W900 trucks manufactured March 22, 2006, through July 15, 2013 and equipped with Primaax tridem rear suspensions and a pusher and/or tag axle. The affected trucks have brake chambers that take longer to apply or release the brakes th
20V19900006/04/2020
ELECTRONIC STABILITY CONTROL (ESC)
PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lo
10V18500004/05/2010
SUSPENSION:REAR:AXLE:SPINDLE
KENWORTH IS RECALLING CERTAIN MODEL YEAR 2010 T2000, T660, T800 AND W900 VEHICLES MANUFACTURED BETWEEN JULY 30, 2009 AND SEPTEMBER 18, 2009. THE REAR AXLE OUTER END HUB MAY HAVE NOT BEEN PRIMED WITH OIL PROPERLY DURING THE REAR AXLE INSTALLATION PROCESS. POTENTIAL LACK OF OIL MAY CAUSE THE OUTER E
09V34800003/09/2009
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PACCAR IS RECALLING MODEL YEAR 2008-2010 KENWORTH T300, T270, AND T370, MODEL YEAR 2009-2010 T800 AND PETERBILT MODEL YEAR 2008-2010 335, 340, AND 367 VEHICLES BUILT ON CUMMINS' DIESEL ENGINE. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO I
10V30800002/07/2010
STEERING:COLUMN
PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2010 TRUCKS EQUIPPED WITH TRW STEERING SHAFTS. THE CIRCUMFERENTIAL WELD AROUND THE STEERING SHAFT TUBE THAT WELDS THE SPLINED TUBE TO THE NON-SPLINED TUBE MAY BE MISLOCATED. MISLOCATION OF THE CIRCUMFERENTIAL WELD MAY ALLOW THE SPLINED TUBE AND NON-SPLIN
Recent Complaints
20161210FireUNKNOWN OR OTHER
TRU-FLEX TORSIONAL BELLOWS PIPE CONNECTING ENGINE TURBO CHARGER AND EXHAUST PIPE IN ENGINE COMPARTMENT LEAKS HOT EXHAUST GASES INTO CAB WHERE OPERATOR IS LOCATED. HOT EXHAUST GASES ESCAPE FROM THIS FREQUENTLY FAILING PART AND STARTS FIRES ON NEARBY COMBUSTIBLE COMPONENTS. FMCSA PART 393.83 2 E AND G IS VIOLATED. THIS PROBLEM EXTENDS AT LEAST TO MODEL YEAR 2010 THRU 2014 IN SEVERAL DIFFERENT FORMS. OPERATORS ARE FORCED TO REPLACE THESE DEFECTIVE DEVICES AT THEIR OWN EXPENSE. SOME OPERATORS HAVE EXPERIENCED SEVERAL SMALL FIRES AND THERE HAS BEEN AT LEAST ONE FIRE DESTROYING A TRUCK. MOST OF THESE FIRES HAVE BEEN SUPPRESSED BY THE OWNER OPERATORS WHEN THEY ARE SMALL. THESE FIRES ARE ESPECIALLY COMMON ON TRUCKS USED FOR CARRYING LOGS IN THE UP OF MICHIGAN. ONE SPECIFIC FIRE WAS REPORTED TO MICHIGAN STATE POLICE AND MICHIGAMME/SPUR FIRE DEPARTMENT. THE TRUCK WAS TRAVELING ON A FOREST ROAD AT THE TIME OF THE INCIDENT. OWNER OPERATORS ARE IN SOME CASES NOW PURCHASING EXTRA TRU-FLEX CONNECTO
Compare 2010KenworthT800 to Similar Vehicles
NHTSA Investigations
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2010 Kenworth T800 have?▼
The 2010 Kenworth T800 has 1 NHTSA complaints, 0 crashes, 1 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2010 Kenworth T800?▼
Yes, the 2010 Kenworth T800 has 11 recall(s). The most common affected component is SERVICE BRAKES, AIR:DISC:CALIPER. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2010 Kenworth T800?▼
The most-complained component for the 2010 Kenworth T800 is UNKNOWN OR OTHER with 1 complaints. Other frequently reported areas include various components.
Is the 2010 Kenworth T800 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2010 Kenworth T800; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.