KENWORTH T680 · model year

2016 KENWORTH T680

7 NHTSA complaints, and 16 active recalls for this specific cohort.

NHTSA overall rating

Not crash-tested

New Car Assessment Program

The 2016KENWORTHT680 carries 7 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.

Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2016 T680 is service brakes, hydraulic:foundation components:drum:drum with 1 filings, followed by visibility/wiper (1) and fuel/propulsion system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 16 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.

NHTSA currently has 3 investigation files overlapping the 2016 T680. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.

7
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths

Total Complaints

7 filings

Crashes Reported

0 reports

Source

NHTSA ODI

Federal complaints database

Complaints vs. fleet median (215)

At or below the fleet median complaint volume.

Complaints by Component

ComponentCount
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM1
VISIBILITY/WIPER1
FUEL/PROPULSION SYSTEM1
UNKNOWN OR OTHER1
ELECTRICAL SYSTEM1
SERVICE BRAKES1
SEAT BELTS1

Recalls (16)

21V00N00029/12/2021

ELECTRICAL SYSTEM:WIRING

PACCAR Incorporated (PACCAR) is recalling certain 2016-2022 Peterbilt 567, 579, 2021-2022 Peterbilt 536, 2017-2021 Kenworth T880, 2016-2022 Kenworth T680, 2018-2020 Kenworth T440, 2020 Kenworth T270, and 2021 Kenworth T280 vehicles. The methane detection system will not function if the system loses

20V59300028/09/2020

SERVICE BRAKES, AIR:ANTILOCK

PACCAR Incorporated (PACCAR) is recalling certain 2016-2021 Kenworth T680 trucks equipped with a 2.1m Cab and WABCO 6S/6M ABS brake system with drum brakes. The brake systems were manufactured with a standard rear-brake ABS modulator valve instead of a quick release valve, which may exceed the inte

17V47100025/07/2017

EXTERIOR LIGHTING

PACCAR Incorporated (PACCAR) is recalling certain 2013-2017 Peterbilt 567 and 579 Kenworth T680 and T880 trucks equipped with optional spotlights. The spotlight circuit may not be adequately protected in the event of a short.

15V59700024/09/2015

ELECTRICAL SYSTEM:IGNITION:MODULE

Paccar Incorporated (Paccar) is recalling certain model year 2016 Kenworth T370, T660, T680, T800, T880, and W900 vehicles manufactured July 31, 2015, to August 12, 2015, and 2016 Peterbilt 337, 348, 365, 367, 382, 386, 389, 567, 579, and 587 vehicles manufactured August 4, 2015, to August 12, 2015.

24V14500023/02/2024

SERVICE BRAKES, AIR:SUPPLY:RESERVOIR/TANK

PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 ve

17V59300022/09/2017

STEERING:LINKAGES:TIE ROD ASSEMBLY

PACCAR Incorporated (PACCAR) is recalling certain 2016 Peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389G, 567, 579 and 587 trucks and Kenworth K170, T170, T270, T370, T440, T470,T660, T680, T800, T880, and W900 trucks equipped with certain Spicer D or E series steer axles.

15V45800022/07/2015

EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS

PACCAR Incorporated (PACCAR) is recalling certain model year 2011-2016 Kenworth T440, T470, T660, T680, and T880 trucks manufactured January 14, 2010, to May 22, 2015, and equipped with HID Headlamps and the option for Daytime Running Lamps (DRL). The DRLs are required to deactivate when the hazard

15V45700022/07/2015

SERVICE BRAKES, AIR

PACCAR Incorporated (PACCAR) is recalling certain model year 2016 Kenworth T440, T470, T660, T680, T800, T880, and W900 trucks manufactured February 16, 2015, to March 9, 2015. The affected vehicles are equipped with an SR-7 spring brake valve assembly that may have had the primary and secondary se

18V81600016/11/2018

EXTERIOR LIGHTING

PACCAR Incorporated (PACCAR) is recalling certain 2013-2019 Kenworth T680 and T880 and Peterbilt 579 trucks, greater than 30 feet long and equipped with side extender mounted intermediate marker lamp/turn signals that do not include a reflex reflector. Since both intermediate side marker lamps and

17V10300015/02/2017

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

PACCAR Incorporated (PACCAR) is recalling certain 2015-2018 Kenworth K370, T680, T880 and 2017-2018 Peterbilt 567 and 579 trucks. The plastic fuel tee fittings on these trucks may leak fuel.

15V27200011/05/2015

WHEELS:LUGS/NUTS/BOLTS/STUDS

PACCAR Incorporated (PACCAR) is recalling certain model year 2016 Kenworth T660, T680, T800, T880, and W900 trucks manufactured February 1, 2015, to April 20, 2015. During assembly, the affected vehicles did not undergo the rear wheel mounting torque verification process, and thus the rear wheels m

15V63900009/10/2015

POWER TRAIN:MANUAL TRANSMISSION

Paccar (Paccar Incorporated) is recalling certain 2016 Kenworth T680, T800, and T880 trucks manufactured January 5, 2015, to January 7, 2015 and 2016 Peterbilt 367, 384, 567, and 579 trucks manufactured January 2, 2015, to January 9, 2015 and equipped with Eaton Fuller FR 10-speed manual transmissio

15V27000008/05/2015

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

PACCAR Incorporated (PACCAR) is recalling certain model year 2014-2016 Kenworth T660, T680, T880 trucks manufactured February 18, 2013, to April 10, 2015, and 2011-2016 Peterbilt 386, 389, 567, 579, and 587 trucks manufactured December 13, 2010, to April 20, 2015. The affected trucks, equipped with

20V19900006/04/2020

ELECTRONIC STABILITY CONTROL (ESC)

PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lo

15V19600003/04/2015

POWER TRAIN:AXLE ASSEMBLY

PACCAR Incorporated (PACCAR) is recalling certain model year 2015-2016 Kenworth T680 and T880 trucks manufactured November 17, 2014, to January 5, 2015. The affected vehicles are equipped with Meritor MT-40-14X rear drive axles that may circulate an inadequate amount of lubricant to the wheel end h

18V36800001/06/2018

ELECTRONIC STABILITY CONTROL (ESC)

PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 567 and 579 trucks and 2015-2018 Kenworth T660, T680, T800, T880 and W900 trucks. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may no

Recent Complaints

20201105SEAT BELTS

SEAT BELT CABLE BECOMES FRAYED AND BREAKS. WILL BREAK COMPLETELY IF IN AN ACCIDENT. WITH NOTHING HOLDING DRIVER IN DRIVER WILL BECOME INJURED AND POSSIBLY DEATH. REPLACE WITH A BETTER CONSTRUCTED DEVICE

20180816SERVICE BRAKES

DRIVER DRIVING DOWN ROAD I-35 TRUCK DEVELOPED MASSIVE AIR LEAK AND BRAKES APPLIED COULD NOT RELASE BRAKES ALONG SIDE OF INTERSTATE SERVICE CALL FOUND HALDEX BRAKE CHAMBER FAILED REPLACED BRAKE CHAMBER

Mileage: 250,000

20180113UNKNOWN OR OTHER

HAVE SOMEONE REMOTELY HACKING INTO ECM BOARD TURNING OFF THINGS ON TRUCKS HAD FREIGHTLINER YEARS BACK THEY KEPT REMOTELY SHUTTING OFF OPT IDLE AN JAKE BRAKE HAD INTERNATIONAL IN 2014 THEY THREW ON TRAILER BRAKES TRYING TO WRECK TRUCK STRAIGHTENED OUT THEN THEY DID AGAIN IN SNOW STORM? ON I-80 IN IOWA *BF *TR

Mileage: 319,220

20180113ELECTRICAL SYSTEM

HAVE SOMEONE REMOTELY HACKING INTO ECM BOARD TURNING OFF THINGS ON TRUCKS HAD FREIGHTLINER YEARS BACK THEY KEPT REMOTELY SHUTTING OFF OPT IDLE AN JAKE BRAKE HAD INTERNATIONAL IN 2014 THEY THREW ON TRAILER BRAKES TRYING TO WRECK TRUCK STRAIGHTENED OUT THEN THEY DID AGAIN IN SNOW STORM? ON I-80 IN IOWA *BF *TR

Mileage: 319,220

20170404FUEL/PROPULSION SYSTEM

THERE ARE NUMEROUS SERVICE BULLETINS ON QUANTUM'S WEBSITE, WWW.QTWW.COM , UNDER PRODUCTS AND SERVICE BULLETINS THAT SAY MANY DIFFERENT PARTS OF THEIR FUEL SYSTEMS WILL FAIL. IT ALSO STATES THAT THEIR BRACKET SYSTEM HOLDING THE TANKS IN PLACE WILL ALLOW THE HIGH PRESSURE TANKS TO MOVE LATERALLY THAT COULD CAUSE A RUPTURE IN THE FUEL LINES OR THE TANK ITSELF. I HAVE CONTACTED THEM TO HAVE THE PARTS REPLACED AND THEY ARE REFUSING TO CHANGE THEM OR TELL ME HOW I CAN MAKE MY SYSTEMS SAFE FOR MY EMPLOYEES TO OPERATE. I HAVE A HUGE CONCERN FOR THE SAFETY OF MY EMPLOYEES WHILE OPERATING THESE SYSTEMS UNTIL THE PARTS THAT WILL POSSIBLY FAIL HAVE BEEN REPLACED. IN ADDITION THEY ARE NOT FOLLOWING THE NFPA 52 GUIDELINES FOR THE LOCATION OF THE PRD VENTS WHICH IN THE EVENT OF A FIRE AND THE CURRENT LOCATION OF THE VENTS WOULD DISCHARGE FUEL DIRECTLY INTO THE FLAMES. THEY CURRENTLY ARE STILL NOT FOLLOWING THE GUIDELINES AS OF TODAY. AS I'M SURE YOU CAN UNDERSTAND MY CONCERNS AND WOULD LIKE TO H

20170131VISIBILITY/WIPER

THE DEFROST DOORS IN THE T680 IS WEAK AND BREAKS OFTEN LEAVING THE DRIVER WITHOUT ANY DEFROST CAUSING HIS VISIBILITY TO DECREASE IN AN UNSAFE MANNER. KENWORTH HAS BEEN UNWILLING TO ADDRESS THIS ISSUE AND REPAIR IT. WHEN I CONTACTED OUR DISTRICT SERVICE MANAGER HE KNEW THE PART NUMBER OF THE REPLACEMENT DOOR ASSEMBLY FROM MEMORY AND STATED IN AN EMAIL BACK TO ME THAT KENWORTH HAS IDENTIFIED THE ISSUE AND IS WORKING TO FIX IT ON FUTURE MODELS. LABOR TO REPAIR THIS IS OVER $3000 AND THE PART IS ANOTHER $886. WE HAVE 12 OF THESE VEHICLES, SO FAR 5 OF THE 12 HAVE BROKEN LEAVING MORE THAN ONE DRIVER STRUGGLING TO GET OFF THE HIGHWAY BEFORE HIS WINDOW FOGGED UP SO BAD HE BECAME UNSAFE TO DRIVE. THE VEHICLES ARE IN MOTION WHEN THESE DEFROST DOORS BREAK AND IT CREATES A VERY UNSAFE SITUATION AS TRUCKS CAN NOT JUST PULL OVER ANY SPOT THEY CHOOSE ON THE HIGHWAYS AND WAIT FOR A WINDOW TO THAW OUT. THERE ARE 2 ISSUES THAT HAPPEN ON THESE DOORS. 1 THE DOOR IS OVERFLEXED BY THE ELECTRIC ACTUATOR

Mileage: 165,462

20160712SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

TL* THE CONTACT OWNS A 2016 KENWORTH T680. WHILE DRIVING 65 MPH, THE STEEL DRUM FROM THE TIRE FRACTURED IN PIECES WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEEL PLATE DRUM WAS NOT WELDED CORRECTLY. THE STEEL PLATE DRUM WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.

Mileage: 20,000

Compare 2016KENWORTHT680 to Similar Vehicles

NHTSA Investigations

Frequently Asked Questions

How many complaints does the 2016 KENWORTH T680 have?
The 2016 KENWORTH T680 has 7 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2016 KENWORTH T680?
Yes, the 2016 KENWORTH T680 has 16 recall(s). The most common affected component is ELECTRICAL SYSTEM:WIRING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2016 KENWORTH T680?
The most-complained component for the 2016 KENWORTH T680 is SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM with 1 complaints. Other frequently reported areas include VISIBILITY/WIPER and FUEL/PROPULSION SYSTEM.
Is the 2016 KENWORTH T680 safe to buy?
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.

Vehicle Safety Guides

Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.