2008 INTERNATIONAL CE

SERVICE BRAKES, HYDRAULIC

NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, HC, AND BE COMMERCIAL BUSES AND INTERNATIONAL 1300, 3200, 3300, 4100, 4200, 4300, 4400, AND MXT TRUCKS MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTE

THE INTERNATIONAL DT 466 SCHOOL BUS ENGINE SUDDENLY EXPERIENCED EXTREME PERFORMANCE DEGRADATION WITHOUT ANY WARNING WHILE DRIVING. THE ENGINE STARTED A POPPING NOISE AND SEVERELY LACKED POWER. WE PURCHASED 75 SCHOOL BUSES IN 2008, AND 26 PERCENT OF THEM HAD ROLLER TAPPET GUIDES FAIL BY FEBRUARY 2013. IN EVERY CASE, THIS FAILURE MODE RESULTED IN MAJOR DAMAGE TO ENGINE VALVE TRAIN COMPONENTS. TWO ENGINES OUT OF 26 TOTAL FAILURES TO DATE WERE NOT REPAIRABLE AND REQUIRED REPLACEMENT. THE CURRENT FAILURE HAS NOW GROWN TO 34 PERCENT. IT IS A SAFETY HAZARD TO SCHOOL CHILDREN AND OTHER VEHICLES WHEN A SCHOOL BUS ENGINE SUDDENLY EXPERIENCES SEVERE ENGINE DEGRADATION ON THE ROAD.

Mileage: 10,721

THE INTERNATIONAL DT 466 SCHOOL BUS ENGINE SUDDENLY EXPERIENCED EXTREME PERFORMANCE DEGRADATION WITHOUT ANY WARNING WHILE DRIVING. THE ENGINE STARTED A POPPING NOISE AND SEVERELY LACKED POWER. WE PURCHASED 75 SCHOOL BUSES IN 2008, AND 26 PERCENT OF THEM HAD ROLLER TAPPET GUIDES FAIL BY FEBRUARY 2013. IN EVERY CASE, THIS FAILURE MODE RESULTED IN MAJOR DAMAGE TO ENGINE VALVE TRAIN COMPONENTS. TWO ENGINES OUT OF 26 TOTAL FAILURES TO DATE WERE NOT REPAIRABLE AND REQUIRED REPLACEMENT. THE CURRENT FAILURE HAS NOW GROWN TO 34 PERCENT. IT IS A SAFETY HAZARD TO SCHOOL CHILDREN AND OTHER VEHICLES WHEN A SCHOOL BUS ENGINE SUDDENLY EXPERIENCES SEVERE ENGINE DEGRADATION ON THE ROAD.

Mileage: 10,721

THE DRIVER OF THIS SCHOOL BUS APPROACHED A STUDENTS DROP-OFF LOCATION AND ACTIVATED THE AMBER 8-WAYS. AFTER COMING TO A COMPLETE STOP, THE DRIVER OPENED THE DOOR TO LET OFF THE STUDENTS. DUE TO A FAULTY DOOR SWITCH (INTERNATIONAL PART #2207601C1) THE RED FLASHING 8-WAY LIGHTS AS WELL AS THE STOP ARM FAILED TO ACTIVATE. THIS PROMPTED THE DRIVER OF ANOTHER VEHICLE TO GO PAST THE SCHOOL BUS WHILE IT WAS STOPPED AND THE STUDENTS WERE UNLOADING. LUCKILY, NO ONE WAS INJURED IN THIS INCIDENT. UNFORTUNATELY, IT'S NOT THE FIRST TIME THIS SWITCH HAS FAILED. DELIVERY DATE OF THIS VEHICLE WAS AUG. 2007. THE ORIGINAL SWITCH WAS REPLACED ON FEB. 2008 AT 31,000 MILES. IT WAS ALSO REPLACED ON SEPT. 2010 AT 60,000 MILES, AND NOW IN APRIL, 2012 AT 92,000 MILES. WE HAVE 12 OTHER BUSES WITH THIS SAME SWITCH AND ALL OF THEM HAVE HAD SIMILAR PROBLEMS. *TR

Mileage: 30,741

THE DRIVER OF THIS SCHOOL BUS APPROACHED A STUDENTS DROP-OFF LOCATION AND ACTIVATED THE AMBER 8-WAYS. AFTER COMING TO A COMPLETE STOP, THE DRIVER OPENED THE DOOR TO LET OFF THE STUDENTS. DUE TO A FAULTY DOOR SWITCH (INTERNATIONAL PART #2207601C1) THE RED FLASHING 8-WAY LIGHTS AS WELL AS THE STOP ARM FAILED TO ACTIVATE. THIS PROMPTED THE DRIVER OF ANOTHER VEHICLE TO GO PAST THE SCHOOL BUS WHILE IT WAS STOPPED AND THE STUDENTS WERE UNLOADING. LUCKILY, NO ONE WAS INJURED IN THIS INCIDENT. UNFORTUNATELY, IT'S NOT THE FIRST TIME THIS SWITCH HAS FAILED. DELIVERY DATE OF THIS VEHICLE WAS AUG. 2007. THE ORIGINAL SWITCH WAS REPLACED ON FEB. 2008 AT 31,000 MILES. IT WAS ALSO REPLACED ON SEPT. 2010 AT 60,000 MILES, AND NOW IN APRIL, 2012 AT 92,000 MILES. WE HAVE 12 OTHER BUSES WITH THIS SAME SWITCH AND ALL OF THEM HAVE HAD SIMILAR PROBLEMS. *TR

Mileage: 30,741

OWNER OPERATOR OF SCHOOL BUS STATES THAT FOUR (UPPER-LOWER-RIGHT-LEFT) DUAL PANE DOOR WINDOWS HAVE FOGGED DUE TO WATER ENTRY BETWEEN THE PANES. OWNER HAS REMOVED THE PANES IN AN ATTEMPT TO CORRECT AND FOUND THAT (AT LEAST ONE OF) THE PANES HAD COMPLETELY SEPARATED FROM THE PANE "SANDWICH." OWNER WAS UNABLE TO REMOVE COATING FROM THE GLASS WITH SOLVENTS, ETC. THIS OWNER IS PART OF A GROUP OF EIGHT PURCHASERS WHO PURCHASED A PORTION OF "ON-SITE" INVENTORY OF BUSSES WHICH WERE ALL EQUIPPED WITH THE SAME GLASS FEATURE (I.E. PURCHASERS DID NOT SPECIFY THIS OPTION). OWNER OF A RELATED VEHICLE PREVIOUSLY FILED VOQ 10416533. *TR

HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBOARD CALL FOR IT, THIS HAS NEVER WORKED PROPERLY, USES OIL AND ANTIFREEZE CONTINUALLY, STEERING COLUMN HAD TO BE REPLACED AT APPROX. 40,000 MILES, ALOT OF DIESEL FUEL HAS BEEN IN OIL, APRIL 2010,OIL AND AGAIN SEPT 2011. HAVE ALSO HAD TO REPLACE SERVICE DOOR MOTOR,CROSS GATE MOTOR(SEVERAL)THERMO PANE GLASS DOORS LEAKED, FORMED CONDENSATION AND DRIED LEAVING A CLOUDY RESIDUE RESTRICTING VISIBILITY, HAD TO BE REPLACED. MANY OTHER REPAIRS HAVE BEEN DONE TO. THIS VEHICLE DEALER REPAIR SHOPS ALSO DO NOT GIVE RECEIPTS WHEN WARRANTY WORK IS DONE. WHEN ASKED THEY TELL ME IT NEEDS TO GO THROUGH INTERNATIONAL FIRST AND THEN COPY WILL BE GIVEN, BUT RARELY HAPPENS. I SHOULD

Mileage: 1,745

HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBOARD CALL FOR IT, THIS HAS NEVER WORKED PROPERLY, USES OIL AND ANTIFREEZE CONTINUALLY, STEERING COLUMN HAD TO BE REPLACED AT APPROX. 40,000 MILES, ALOT OF DIESEL FUEL HAS BEEN IN OIL, APRIL 2010,OIL AND AGAIN SEPT 2011. HAVE ALSO HAD TO REPLACE SERVICE DOOR MOTOR,CROSS GATE MOTOR(SEVERAL)THERMO PANE GLASS DOORS LEAKED, FORMED CONDENSATION AND DRIED LEAVING A CLOUDY RESIDUE RESTRICTING VISIBILITY, HAD TO BE REPLACED. MANY OTHER REPAIRS HAVE BEEN DONE TO. THIS VEHICLE DEALER REPAIR SHOPS ALSO DO NOT GIVE RECEIPTS WHEN WARRANTY WORK IS DONE. WHEN ASKED THEY TELL ME IT NEEDS TO GO THROUGH INTERNATIONAL FIRST AND THEN COPY WILL BE GIVEN, BUT RARELY HAPPENS. I SHOULD

Mileage: 1,745

HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBOARD CALL FOR IT, THIS HAS NEVER WORKED PROPERLY, USES OIL AND ANTIFREEZE CONTINUALLY, STEERING COLUMN HAD TO BE REPLACED AT APPROX. 40,000 MILES, ALOT OF DIESEL FUEL HAS BEEN IN OIL, APRIL 2010,OIL AND AGAIN SEPT 2011. HAVE ALSO HAD TO REPLACE SERVICE DOOR MOTOR,CROSS GATE MOTOR(SEVERAL)THERMO PANE GLASS DOORS LEAKED, FORMED CONDENSATION AND DRIED LEAVING A CLOUDY RESIDUE RESTRICTING VISIBILITY, HAD TO BE REPLACED. MANY OTHER REPAIRS HAVE BEEN DONE TO. THIS VEHICLE DEALER REPAIR SHOPS ALSO DO NOT GIVE RECEIPTS WHEN WARRANTY WORK IS DONE. WHEN ASKED THEY TELL ME IT NEEDS TO GO THROUGH INTERNATIONAL FIRST AND THEN COPY WILL BE GIVEN, BUT RARELY HAPPENS. I SHOULD

Mileage: 1,745

HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE I PURCHASED IT 10/07. ELECTRICAL, WOULD NOT START IN COLD WEATHER, CONTINUAL DRAW ON BATTERIES REPLACED WITH NEW AND ALSO ADDED A THIRD. NUMEROUS EGR VALVES, EGR COOLERS, LOW PRESSURE FUEL PUMPS, FUEL SUPPLY CONNECTORS DPF'S, WILL NOT DO MANUAL REGEN WHEN INDICATORS ON DASHBOARD CALL FOR IT, THIS HAS NEVER WORKED PROPERLY, USES OIL AND ANTIFREEZE CONTINUALLY, STEERING COLUMN HAD TO BE REPLACED AT APPROX. 40,000 MILES, ALOT OF DIESEL FUEL HAS BEEN IN OIL, APRIL 2010,OIL AND AGAIN SEPT 2011. HAVE ALSO HAD TO REPLACE SERVICE DOOR MOTOR,CROSS GATE MOTOR(SEVERAL)THERMO PANE GLASS DOORS LEAKED, FORMED CONDENSATION AND DRIED LEAVING A CLOUDY RESIDUE RESTRICTING VISIBILITY, HAD TO BE REPLACED. MANY OTHER REPAIRS HAVE BEEN DONE TO. THIS VEHICLE DEALER REPAIR SHOPS ALSO DO NOT GIVE RECEIPTS WHEN WARRANTY WORK IS DONE. WHEN ASKED THEY TELL ME IT NEEDS TO GO THROUGH INTERNATIONAL FIRST AND THEN COPY WILL BE GIVEN, BUT RARELY HAPPENS. I SHOULD

Mileage: 1,745

TL* THE CONTACT OWNS A 2008 INTERNATIONAL CE SCHOOL BUS. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY DETECTED A CONDENSATION RESIDUE BUILDUP IN THE GLASS ON THE FOUR ENTRY DOOR PANELS. THE WHITE RESIDUE COMPLETELY OBSTRUCTED THE VISIBILITY. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 09/28/11*LJ UPDATED

Mileage: 60,000

HI, I WOULD LIKE TO REPORT DEFECTIVE FUEL LINES ON IHC BUSSES. THE YEARS RANGE FROM 2008 365 ENGINE TO 2011 MAXFORCE 7. THE PROBLEM IS THEY HAVE ALUMIUM FUEL LINES AND HAVE STAINLESS KEEPERS FOR THE QUICK DISCONECT. THEY ARE RUBBING THROUGH AND CAUSING FUEL LEAKS. IT SPAYS UP ON MOTOR AND EXHAUST. I TOLD OUR LOCAL DEALER IN 2008 AND SEVERAL TIMES SINCE. IT IS GOING TO CAUSE FIRE AND OR DEATH. I AM SURE THIS COULD BE SOLVED BY USING STAINLEES LINES. THE CHILDEREN THAT RIDE MY BUSSES COME FIRST. PLEASE HELP BEFORE THEY KILL SOMEONE. THANK YOU *TR

Mileage: 15,000