Total Complaints
7 filings
INTERNATIONAL 4300 · model year
2004 INTERNATIONAL 4300
7 NHTSA complaints, and 2 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004INTERNATIONAL4300 carries 7 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2004 4300 is service brakes, hydraulic:antilock/traction control/electronic limited slip:abs warning light with 1 filings, followed by service brakes, air (1) and engine and engine cooling:cooling system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 2 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 22 investigation files overlapping the 2004 4300. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
7
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT | 1 |
| SERVICE BRAKES, AIR | 1 |
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| ENGINE AND ENGINE COOLING:ENGINE | 1 |
| SERVICE BRAKES | 1 |
| SUSPENSION | 1 |
| WHEELS | 1 |
Recalls (2)
04V41400025/08/2004
EQUIPMENT:OTHER:LABELS
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS," AND WITH PART 567, 'CERTIFICATION.' THE "COMPLETE VEHICLE" LABEL WITH THE GROSS VEHICLE WEIGHT RATING (GVWR), GROSS AXLE WE
04V19300022/04/2004
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SEAT BELT LATCH FAILED A QUALITY REVIEW.
Recent Complaints
20151115SERVICE BRAKES
THIS TRUCK HAS BEEN LOCKING UP, THE FRONT RIGHT WHEEL, FOR SEVERAL YEARS, THE FIRST TIME IT HAD 28,000 MILES , I HAVE REPLACED SENSORS, AND NOTHING HELPS, THE ABS LIGHT STAYS ON CONTINUALLY...EVERY TIME I DRIVE IT, IT IS THE SAME LOCK UP WHEEL....IT DOES THIS WHEN VEHICLE IS IN MOTION...
Mileage: 28,000
20151115SUSPENSION
THIS TRUCK HAS BEEN LOCKING UP, THE FRONT RIGHT WHEEL, FOR SEVERAL YEARS, THE FIRST TIME IT HAD 28,000 MILES , I HAVE REPLACED SENSORS, AND NOTHING HELPS, THE ABS LIGHT STAYS ON CONTINUALLY...EVERY TIME I DRIVE IT, IT IS THE SAME LOCK UP WHEEL....IT DOES THIS WHEN VEHICLE IS IN MOTION...
Mileage: 28,000
20151115WHEELS
THIS TRUCK HAS BEEN LOCKING UP, THE FRONT RIGHT WHEEL, FOR SEVERAL YEARS, THE FIRST TIME IT HAD 28,000 MILES , I HAVE REPLACED SENSORS, AND NOTHING HELPS, THE ABS LIGHT STAYS ON CONTINUALLY...EVERY TIME I DRIVE IT, IT IS THE SAME LOCK UP WHEEL....IT DOES THIS WHEN VEHICLE IS IN MOTION...
Mileage: 28,000
20100601ENGINE AND ENGINE COOLING:COOLING SYSTEM
THE INTERNATIONAL DT466E DIESEL MOTOR THAT HAS CYLINDER LINER O-RING SEALS THAT FAIL PREMATURELY CAUSING THE ANTIFREEZE TO BE LEAKED INTO THE OIL CAUSING THE BEARINGS IN THE MOTOR TO FAIL. THE DT MOTOR HAS BEEN AROUND SINCE THE 1960'S IN THE INTERNATIONAL HARVESTOR FARM TRACTORS AND HAVE NOT HAD THIS CONCERN. MY 2004 INTERNATIONAL 4300 TRUCK SLOWLY PUT THE ANTIFREEZE IN THE OIL AT 204,000 CAUSING SEVERE ENGINE DAMAGE. THE ESTIMATE FOR REPAIR IS APPROX $14,000 DOLLARS. MY CONCERN IS THAT THE MOTOR SHOULD OF GONE 500,000 MILES BEFORE IT NEEDED OPENED UP FOR A OVERHAUL. I CAN GET 200,000 MILES OUT OF A GAS MOTOR AND NOT OF SPENT $5,500 FOR THE SEMI GRADE DIESEL MOTOR. IF YOU SEARCH DT466E ENGINE PROBLEMS ON GOOGLE YOU WILL FIND MANY DISGRUNTLED DT OWNERS WHO CANT GET 250,000 MILES OUT OF THEIR DT BEFORE IT FAILS. INTERNATIONAL HAS GOODWILLED SOME REPAIRS PROVIDING THE PARTS TO OVERHAUL THE MOTOR(NOT MINE YET AND I HAVE CALLED THEM). IT SEEM FROM MY EXPERIENCE AS A CHEVROLET SERVICE MANAGE
Mileage: 204,000
20100601ENGINE AND ENGINE COOLING:ENGINE
THE INTERNATIONAL DT466E DIESEL MOTOR THAT HAS CYLINDER LINER O-RING SEALS THAT FAIL PREMATURELY CAUSING THE ANTIFREEZE TO BE LEAKED INTO THE OIL CAUSING THE BEARINGS IN THE MOTOR TO FAIL. THE DT MOTOR HAS BEEN AROUND SINCE THE 1960'S IN THE INTERNATIONAL HARVESTOR FARM TRACTORS AND HAVE NOT HAD THIS CONCERN. MY 2004 INTERNATIONAL 4300 TRUCK SLOWLY PUT THE ANTIFREEZE IN THE OIL AT 204,000 CAUSING SEVERE ENGINE DAMAGE. THE ESTIMATE FOR REPAIR IS APPROX $14,000 DOLLARS. MY CONCERN IS THAT THE MOTOR SHOULD OF GONE 500,000 MILES BEFORE IT NEEDED OPENED UP FOR A OVERHAUL. I CAN GET 200,000 MILES OUT OF A GAS MOTOR AND NOT OF SPENT $5,500 FOR THE SEMI GRADE DIESEL MOTOR. IF YOU SEARCH DT466E ENGINE PROBLEMS ON GOOGLE YOU WILL FIND MANY DISGRUNTLED DT OWNERS WHO CANT GET 250,000 MILES OUT OF THEIR DT BEFORE IT FAILS. INTERNATIONAL HAS GOODWILLED SOME REPAIRS PROVIDING THE PARTS TO OVERHAUL THE MOTOR(NOT MINE YET AND I HAVE CALLED THEM). IT SEEM FROM MY EXPERIENCE AS A CHEVROLET SERVICE MANAGE
Mileage: 204,000
20100316SERVICE BRAKES, AIR
TL* THE CONTACT OWNS A 2004 INTERNATIONAL 4300. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS ENGAGED WHICH RESULTED IN THE VEHICLE MOVING INTO A SIDEWAYS DIRECTION. THE FAILURE OCCURRENCE WAS WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTIONS,THE TYPE OF SERVICE REPAIRS PERFORMED WAS UNKNOWN. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS 800. THE CURRENT MILEAGE WAS 12,000.
Mileage: 800
20080208SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
ABS LIGHT COMES ON AND THE HYDRAULIC BRAKES LOCK UP. THIS IS A RECURRING PROBLEM WITH THIS TRUCK. THE FIRST TIME THE ABS WENT OFF AND BRAKES RELEASED. THE SECOND TIME WAS IN SEPTEMBER 2006 WHEN THE ABS LIGHT STAYED ON. I HAD THE BRAKE LINES REPLACED AND THE SYSTEM RESET AND I ADDED AN EXHAUST BRAKES TO HELP WITH THE BRAKING. THIS COST ME AROUND $5,500. THE MILEAGE WAS ABOUT 10,200. JANUARY 7, 2008 THE ABS LIGHT CAME ON AND THE BRAKES LOCKED UP AGAIN, THIS TIME CAUSING MORE EXTENSIVE DAMAGE. THE ROTORS, CALIPERS, PADS, AND WHEEL SENSORS, HAVE TO BE REPLACED ON ALL WHEELS. THE ESTIMATE FROM THE DEALER THIS TIME IS ABOUT $5,500. I NOW HAVE 17,000 MILES ON THE TRUCK AND I AM AFRAID TO DRIVE IT. I HAVE CALLED CUSTOMER SERVICE AND FILED AN INCIDENT REPORT. I CAN NOT GET PAST CUSTOMER SERVICE. DESPITE PROMISES AND MY REPEATED CALLS, NO ONE WILL CALL ME BACK TO DISCUSS THIS PROBLEM. I HAVE SEARCHED THE INTERNET AND FOUND I AM NOT ALONE WITH THIS PROBLEM, EVENTUALLY SOMEBODY WILL BE KILLED DR
Mileage: 17,000
Compare 2004INTERNATIONAL4300 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 INTERNATIONAL 4300 have?▼
The 2004 INTERNATIONAL 4300 has 7 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2004 INTERNATIONAL 4300?▼
Yes, the 2004 INTERNATIONAL 4300 has 2 recall(s). The most common affected component is EQUIPMENT:OTHER:LABELS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2004 INTERNATIONAL 4300?▼
The most-complained component for the 2004 INTERNATIONAL 4300 is SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT with 1 complaints. Other frequently reported areas include SERVICE BRAKES, AIR and ENGINE AND ENGINE COOLING:COOLING SYSTEM.
Is the 2004 INTERNATIONAL 4300 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.