2001 HYUNDAI XG300

POWER TRAIN

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IMPROPERLY MANUFACTURED POWERTRAIN CONTROL MODULES (PCM) WERE INSTALLED IN SOME VEHICLES. THE IMPROPERLY MANUFACTURED PCMS CONTAINED A CONDENSER THAT WAS NOT CORRECTLY INSTALLED ONTO THE PCM PRINTED CIRCUIT BOARD. THE INCORRECT INSTALLATION OF THE CONDENS

EQUIPMENT:OTHER:LABELS

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 110. THESE VEHICLES DO NOT HAVE THE CORRECT TIRE PRESSURE PLACARD ATTACHED.

SUSPENSION

HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, O

AIR BAGS:SIDE/WINDOW

ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUS

DRIVING 65 MPH ON A MAJOR INTERSTATE WHEN VEHICLE #1 DROVE ACROSS INTERSTATE, VEHICLE #2 T-BONED VEHICLE #1, AND I STRUCK VEHICLE #2 FROM BEHIND AT APPROXIMATELY 45 MPH. TOTALED VEHICLE AND AIR BAGS NEVER DEPLOYED. NECK, BACK, SHOULDER, AND LEFT ELBOW INJURIES.

Mileage: 300,000

WHEN PUMPING GAS THE PUMP EITHER SHUTS OFF OR OVERFLOWS AFTER ONLY PUMPING 1 GALLON OF GAS. IT TAKES MORE THAN 15 MINUTES TO PUT IN 5 DOLLARS WORTH OF GAS. IS ANYONE ELSE HAVING THIS PROBLEM??? *TR

Mileage: 86,000

THE SUSPENSION AND BRAKES WILL LOCK UP AND WHEN IT IS WET I HAVE SLID INTO BANKS OF DIRT AND HIT MY OTHER VEHICLE AND IT DOES NOT MATTER HOW FAST I GO. I HAVE HAD MY BRAKES CHECKED AND HAVE HAD TO GET A WHEEL ALIGNMENT EVERY MONTH FOR THE LAST 12 MONTHS DUE TO SUSPENSION. *TR

Mileage: 138,000

THE SUSPENSION AND BRAKES WILL LOCK UP AND WHEN IT IS WET I HAVE SLID INTO BANKS OF DIRT AND HIT MY OTHER VEHICLE AND IT DOES NOT MATTER HOW FAST I GO. I HAVE HAD MY BRAKES CHECKED AND HAVE HAD TO GET A WHEEL ALIGNMENT EVERY MONTH FOR THE LAST 12 MONTHS DUE TO SUSPENSION. *TR

Mileage: 138,000

TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN CAUTIOUSLY ON THE SHOULDER. IN ADDITION, THERE WAS AN UNEXPECTED ACCELERATION AND UNKNOWN ELECTRICAL ISSUES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DETECT A TROUBLE CODE. THE CONTACT STATED THAT THE ALTERNATOR HAD BEEN PREVIOUSLY REPLACED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 51,000. ...UPDATED 12-24-13 *BF

Mileage: 51,000

TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN CAUTIOUSLY ON THE SHOULDER. IN ADDITION, THERE WAS AN UNEXPECTED ACCELERATION AND UNKNOWN ELECTRICAL ISSUES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DETECT A TROUBLE CODE. THE CONTACT STATED THAT THE ALTERNATOR HAD BEEN PREVIOUSLY REPLACED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 51,000. ...UPDATED 12-24-13 *BF

Mileage: 51,000

TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STARTED THE IGNITION AND THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY ON THE INSTRUMENT PANEL UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE SEPARATE TIMES AND EACH TIME THE AIR BAG COMPUTER MODULE WAS RESET. THE MALFUNCTION PERSISTED AFTER THE REPAIRS WERE PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS LESS THAN 10,000.

Mileage: 10,000

WE OWN A HYUNDAI 2001 XG300 WHICH HAS SEVERE CORROSION AND RUST ON THE SUB FRAME. SINCE NOVEMBER, WE HAD DIFFERENT WORK PERFORMED ON THE CAR. ALL THE MECHANIC HAVE SAID THAT THE CORROSION AND RUST IS SEVERE AND IS EFFECTING THE SUSPENSION AND OTHER MOUNTINGS TO THE FRAME. THE CARBON EMISSION EVAPORATOR NEEDED TO BE REPLACED AND THE DEALERSHIP TO GET IT TO MOUNT HAD TO USE PLASTIC ZIP TIES DUE TO THE AMOUNT OF RUSTS AND HOLES IN THE FRAME. THE DEALERSHIP MECHANICS HAVE STATED THAT THE CAR IS UNSAFE TO DRIVE DUE TO THE REAR TIRE IS NOT FULLY ATTACHED AND NEED WELDING WORK TO BE PERFORMED. THIS IS DUE TO THE SEVERE CORROSION. THE CONTROLLER ARM OF THE REAR RIGHT PASSENGER SIDE NEEDS TO BE REPLACED, BOTH REAR UPPER CONTROL ARM WERE REPLACED. THE REGIONAL DISTRICT MANAGER FOR THE NORTHEAST SAYS THIS IS NORMAL CORROSION FOR A 10 YEAR OLD CAR. *TR

WE OWN A HYUNDAI 2001 XG300 WHICH HAS SEVERE CORROSION AND RUST ON THE SUB FRAME. SINCE NOVEMBER, WE HAD DIFFERENT WORK PERFORMED ON THE CAR. ALL THE MECHANIC HAVE SAID THAT THE CORROSION AND RUST IS SEVERE AND IS EFFECTING THE SUSPENSION AND OTHER MOUNTINGS TO THE FRAME. THE CARBON EMISSION EVAPORATOR NEEDED TO BE REPLACED AND THE DEALERSHIP TO GET IT TO MOUNT HAD TO USE PLASTIC ZIP TIES DUE TO THE AMOUNT OF RUSTS AND HOLES IN THE FRAME. THE DEALERSHIP MECHANICS HAVE STATED THAT THE CAR IS UNSAFE TO DRIVE DUE TO THE REAR TIRE IS NOT FULLY ATTACHED AND NEED WELDING WORK TO BE PERFORMED. THIS IS DUE TO THE SEVERE CORROSION. THE CONTROLLER ARM OF THE REAR RIGHT PASSENGER SIDE NEEDS TO BE REPLACED, BOTH REAR UPPER CONTROL ARM WERE REPLACED. THE REGIONAL DISTRICT MANAGER FOR THE NORTHEAST SAYS THIS IS NORMAL CORROSION FOR A 10 YEAR OLD CAR. *TR

TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT A PASSENGER OPENED THE REAR PASSENGER SIDE DOOR FROM THE INTERIOR AND CUT THEIR HAND ON THE DOOR HANDLE. THE CONTACT STATED THAT THE METAL ON ALL FOUR OF THE INTERIOR DOOR HANDLES WERE PEELING ABNORMALLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 127,000.

Mileage: 127,000

TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THE CHECK ENGINE LIGHT REMAINED ILLUMINATED ON THE WARNING PANEL AND DESPITE THE FACT THAT ROUTINE OIL CHANGES WERE PERFORMED ON THE VEHICLE, THE LIGHT WOULD NOT SHUT OFF. THE DEALER WAS UNABLE TO PROVIDE A REASON AS TO WHY THE CHECK ENGINE LIGHT WAS ILLUMINATED. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 79,000.

Mileage: 70,000

DASHBOARD COMING AWAY FROM WINDSHIELD CAUSING THE AIR BAG LIGHT TO COME ON, AND DEFROSTERS NOT TO WORK. *TR

Mileage: 34,000

TL*THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT WHEN SHE DROVE VARIOUS SPEEDS INCLUDING APPROXIMATELY 35 MPH. SHE NOTICED THE FAILURE IN OCTOBER 2003. THE TIRES WERE CHECKED AND ALIGNED; HOWEVER, THE FAILURE CONTINUED TO OCCUR. A LOCAL MECHANIC STATED THAT THE FRONT SUBFRAME WAS CORRODED. SHE LATER INQUIRED ABOUT RECALL 09V124000, SUSPENSION AND WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED. SHE ALSO STATED THAT IN AUGUST 2007 SHE NOTICED THAT THE SRS LIGHT WAS ILLUMINATED. THE VEHICLE WAS INSPECTED AND IT WAS CITED THAT THE SRS LIGHT WAS ON BECAUSE OF A FAULTY WIRE WHICH WAS CONNECTED TO THE FRONT SEAT AND COULD NOT BE ADJUSTED. THE VEHICLE WOULD HAVE TO BE TAKEN APART TO CONFIRM THAT THE WIRE WAS FAULTY. SHE ALSO WAS INFORMED THAT RECALL 02V105000, AIR BAGS, SIDE/WINDOW WAS RELATED TO HER FAILURE BUT DID NOT INCLUDE HER VIN. IN JULY 2009, SHE NOTICED THAT THE FUEL TANK WOULD NOT TAKE GASOLINE. SHE FELT AS IF IT WAS BECAUSE OF THE FUE

Mileage: 24,000

TL*THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT WHEN SHE DROVE VARIOUS SPEEDS INCLUDING APPROXIMATELY 35 MPH. SHE NOTICED THE FAILURE IN OCTOBER 2003. THE TIRES WERE CHECKED AND ALIGNED; HOWEVER, THE FAILURE CONTINUED TO OCCUR. A LOCAL MECHANIC STATED THAT THE FRONT SUBFRAME WAS CORRODED. SHE LATER INQUIRED ABOUT RECALL 09V124000, SUSPENSION AND WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED. SHE ALSO STATED THAT IN AUGUST 2007 SHE NOTICED THAT THE SRS LIGHT WAS ILLUMINATED. THE VEHICLE WAS INSPECTED AND IT WAS CITED THAT THE SRS LIGHT WAS ON BECAUSE OF A FAULTY WIRE WHICH WAS CONNECTED TO THE FRONT SEAT AND COULD NOT BE ADJUSTED. THE VEHICLE WOULD HAVE TO BE TAKEN APART TO CONFIRM THAT THE WIRE WAS FAULTY. SHE ALSO WAS INFORMED THAT RECALL 02V105000, AIR BAGS, SIDE/WINDOW WAS RELATED TO HER FAILURE BUT DID NOT INCLUDE HER VIN. IN JULY 2009, SHE NOTICED THAT THE FUEL TANK WOULD NOT TAKE GASOLINE. SHE FELT AS IF IT WAS BECAUSE OF THE FUE

Mileage: 24,000

TL*THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT WHEN SHE DROVE VARIOUS SPEEDS INCLUDING APPROXIMATELY 35 MPH. SHE NOTICED THE FAILURE IN OCTOBER 2003. THE TIRES WERE CHECKED AND ALIGNED; HOWEVER, THE FAILURE CONTINUED TO OCCUR. A LOCAL MECHANIC STATED THAT THE FRONT SUBFRAME WAS CORRODED. SHE LATER INQUIRED ABOUT RECALL 09V124000, SUSPENSION AND WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED. SHE ALSO STATED THAT IN AUGUST 2007 SHE NOTICED THAT THE SRS LIGHT WAS ILLUMINATED. THE VEHICLE WAS INSPECTED AND IT WAS CITED THAT THE SRS LIGHT WAS ON BECAUSE OF A FAULTY WIRE WHICH WAS CONNECTED TO THE FRONT SEAT AND COULD NOT BE ADJUSTED. THE VEHICLE WOULD HAVE TO BE TAKEN APART TO CONFIRM THAT THE WIRE WAS FAULTY. SHE ALSO WAS INFORMED THAT RECALL 02V105000, AIR BAGS, SIDE/WINDOW WAS RELATED TO HER FAILURE BUT DID NOT INCLUDE HER VIN. IN JULY 2009, SHE NOTICED THAT THE FUEL TANK WOULD NOT TAKE GASOLINE. SHE FELT AS IF IT WAS BECAUSE OF THE FUE

Mileage: 24,000

TL*THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT WHEN SHE DROVE VARIOUS SPEEDS INCLUDING APPROXIMATELY 35 MPH. SHE NOTICED THE FAILURE IN OCTOBER 2003. THE TIRES WERE CHECKED AND ALIGNED; HOWEVER, THE FAILURE CONTINUED TO OCCUR. A LOCAL MECHANIC STATED THAT THE FRONT SUBFRAME WAS CORRODED. SHE LATER INQUIRED ABOUT RECALL 09V124000, SUSPENSION AND WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED. SHE ALSO STATED THAT IN AUGUST 2007 SHE NOTICED THAT THE SRS LIGHT WAS ILLUMINATED. THE VEHICLE WAS INSPECTED AND IT WAS CITED THAT THE SRS LIGHT WAS ON BECAUSE OF A FAULTY WIRE WHICH WAS CONNECTED TO THE FRONT SEAT AND COULD NOT BE ADJUSTED. THE VEHICLE WOULD HAVE TO BE TAKEN APART TO CONFIRM THAT THE WIRE WAS FAULTY. SHE ALSO WAS INFORMED THAT RECALL 02V105000, AIR BAGS, SIDE/WINDOW WAS RELATED TO HER FAILURE BUT DID NOT INCLUDE HER VIN. IN JULY 2009, SHE NOTICED THAT THE FUEL TANK WOULD NOT TAKE GASOLINE. SHE FELT AS IF IT WAS BECAUSE OF THE FUE

Mileage: 24,000

I HAVE ONGOING PROBLEMS WITH MY CAR SINCE AFTER PURCHASE IN 2007. HYUNDAI CASE #3479162 CHECK ENGINE LIGHT WAS GOING ON AND STAYING ON UNLESS THE BATTERY WOULD DIE.FAILED EMISSIONS SAID TO BE CAUSED BY AIR SENSORS BUT CODES KEPT GETTING WHIPPED OUT.CAR HAS BEEN TO DEALER COUNTLESS TIMES! CAR LUNGES THRASHING MOTION WHILE AT A STOP OR DRIVING.THE AIR BAG LIGHT STAYS ON AT ALL TIMES,THE FIRST TIME THE LUNGING HAPPENED I THOUGHT I WAS OUT OF GAS, WITH THE EXCEPTION OF THE VIOLENT THRASHING THAT OCCURRED/S. MY CARS CONTROL PANEL,HEADLIGHTS AND INTERIOR LIGHTS DIM,SHUT OFF AT WILL. ALL RADIO & CONTROL PANEL LIGHTS COME ON AND GO OFF AT ANY TIME.THE RADIO STARTS CHANGING FROM FM TO AM TO CD AT ANY GIVEN TIME INCLUDING WHILE THE CAR IS TURNED OFF AND UNATTENDED. THE TAIL LIGHTS, BRAKE LIGHTS AND RUNNING LIGHTS ALSO TURN ON/OFF BY THEMSELVES WHETHER DRIVING THE CAR OR IF THE CAR IS SITTING IN MY DRIVEWAY. I HAVE TO GET MY CAR JUMPED EVERY TIME I GO TO START IT .IT WASN'T UNTIL EARLIER THIS YE

Mileage: 52,000

I HAVE ONGOING PROBLEMS WITH MY CAR SINCE AFTER PURCHASE IN 2007. HYUNDAI CASE #3479162 CHECK ENGINE LIGHT WAS GOING ON AND STAYING ON UNLESS THE BATTERY WOULD DIE.FAILED EMISSIONS SAID TO BE CAUSED BY AIR SENSORS BUT CODES KEPT GETTING WHIPPED OUT.CAR HAS BEEN TO DEALER COUNTLESS TIMES! CAR LUNGES THRASHING MOTION WHILE AT A STOP OR DRIVING.THE AIR BAG LIGHT STAYS ON AT ALL TIMES,THE FIRST TIME THE LUNGING HAPPENED I THOUGHT I WAS OUT OF GAS, WITH THE EXCEPTION OF THE VIOLENT THRASHING THAT OCCURRED/S. MY CARS CONTROL PANEL,HEADLIGHTS AND INTERIOR LIGHTS DIM,SHUT OFF AT WILL. ALL RADIO & CONTROL PANEL LIGHTS COME ON AND GO OFF AT ANY TIME.THE RADIO STARTS CHANGING FROM FM TO AM TO CD AT ANY GIVEN TIME INCLUDING WHILE THE CAR IS TURNED OFF AND UNATTENDED. THE TAIL LIGHTS, BRAKE LIGHTS AND RUNNING LIGHTS ALSO TURN ON/OFF BY THEMSELVES WHETHER DRIVING THE CAR OR IF THE CAR IS SITTING IN MY DRIVEWAY. I HAVE TO GET MY CAR JUMPED EVERY TIME I GO TO START IT .IT WASN'T UNTIL EARLIER THIS YE

Mileage: 52,000

I HAVE ONGOING PROBLEMS WITH MY CAR SINCE AFTER PURCHASE IN 2007. HYUNDAI CASE #3479162 CHECK ENGINE LIGHT WAS GOING ON AND STAYING ON UNLESS THE BATTERY WOULD DIE.FAILED EMISSIONS SAID TO BE CAUSED BY AIR SENSORS BUT CODES KEPT GETTING WHIPPED OUT.CAR HAS BEEN TO DEALER COUNTLESS TIMES! CAR LUNGES THRASHING MOTION WHILE AT A STOP OR DRIVING.THE AIR BAG LIGHT STAYS ON AT ALL TIMES,THE FIRST TIME THE LUNGING HAPPENED I THOUGHT I WAS OUT OF GAS, WITH THE EXCEPTION OF THE VIOLENT THRASHING THAT OCCURRED/S. MY CARS CONTROL PANEL,HEADLIGHTS AND INTERIOR LIGHTS DIM,SHUT OFF AT WILL. ALL RADIO & CONTROL PANEL LIGHTS COME ON AND GO OFF AT ANY TIME.THE RADIO STARTS CHANGING FROM FM TO AM TO CD AT ANY GIVEN TIME INCLUDING WHILE THE CAR IS TURNED OFF AND UNATTENDED. THE TAIL LIGHTS, BRAKE LIGHTS AND RUNNING LIGHTS ALSO TURN ON/OFF BY THEMSELVES WHETHER DRIVING THE CAR OR IF THE CAR IS SITTING IN MY DRIVEWAY. I HAVE TO GET MY CAR JUMPED EVERY TIME I GO TO START IT .IT WASN'T UNTIL EARLIER THIS YE

Mileage: 52,000

I HAVE ONGOING PROBLEMS WITH MY CAR SINCE AFTER PURCHASE IN 2007. HYUNDAI CASE #3479162 CHECK ENGINE LIGHT WAS GOING ON AND STAYING ON UNLESS THE BATTERY WOULD DIE.FAILED EMISSIONS SAID TO BE CAUSED BY AIR SENSORS BUT CODES KEPT GETTING WHIPPED OUT.CAR HAS BEEN TO DEALER COUNTLESS TIMES! CAR LUNGES THRASHING MOTION WHILE AT A STOP OR DRIVING.THE AIR BAG LIGHT STAYS ON AT ALL TIMES,THE FIRST TIME THE LUNGING HAPPENED I THOUGHT I WAS OUT OF GAS, WITH THE EXCEPTION OF THE VIOLENT THRASHING THAT OCCURRED/S. MY CARS CONTROL PANEL,HEADLIGHTS AND INTERIOR LIGHTS DIM,SHUT OFF AT WILL. ALL RADIO & CONTROL PANEL LIGHTS COME ON AND GO OFF AT ANY TIME.THE RADIO STARTS CHANGING FROM FM TO AM TO CD AT ANY GIVEN TIME INCLUDING WHILE THE CAR IS TURNED OFF AND UNATTENDED. THE TAIL LIGHTS, BRAKE LIGHTS AND RUNNING LIGHTS ALSO TURN ON/OFF BY THEMSELVES WHETHER DRIVING THE CAR OR IF THE CAR IS SITTING IN MY DRIVEWAY. I HAVE TO GET MY CAR JUMPED EVERY TIME I GO TO START IT .IT WASN'T UNTIL EARLIER THIS YE

Mileage: 52,000